2012 Lancia Thema air condition

Cavity Cartridge Fuse Mini-Fuse Description
1— —Spare
2 40 Amp Green — Radiator Fan #1
3 50 Amp Red — Power Steering #1
4 30 Amp Pink — Starter
5 40 Amp Green — Anti-Lock Brakes
6 — —Spare
7 50 Amp Red — Cabin Heater #1 — Diesel Only
8 50 Amp Red — Cabin Heater #2 — Diesel Only
9 — 20 Amp Yellow DTCM
10 — 5 Amp Tan Security
11 — 20 Amp Yellow Horns
12 — 10 Amp Red Air Conditioning Clutch
13 — —Spare
14 — 25 Amp Natural Anti-Lock Brakes
15 — —Spare
16 — —Spare
18 50 Amp Red — Radiator Fan #2
19 50 Amp Red — Power Steering #2
20 30 Amp Pink — Wiper Motor
21 30 Amp Pink — Headlamp Washers
22 50 Amp Red — Glow Plug Module — Diesel Only
23 30 Amp Pink — Fuel Pump Feed/Diesel Fuel Heater — Diesel Only
24 50 Amp Red — Cabin Heater #3 — Diesel Only
28 — 25 Amp Natural Fuel Pump
29 — 15 Amp Blue Transmission/Shifter (TCM Module)
30 — —Spare
31 — 25 Amp Natural Engine Module (PCM)
32 — —Spare
33 — —Spare
34 — 25 Amp Natural ASD Feed #1
35 — 20 Amp Yellow ASD Feed #2
275

2. Anytime you store your vehicle, or
keep it out of service (i.e., vacation)
for two weeks or more, run the air
conditioning system at idle for about
five minutes in the fresh air and high
blower setting. This will ensure ad-
equate system lubrication to minimize
the possibility of compressor damage
when the system is started again.
REPLACEMENT BULBS
Interior Bulb Number
Rear Courtesy/Reading
Lamps . . . . . . . . . . . . . . . . . W5W
Rear Compartment (Trunk)
Lamp . . . . . . . . . . . . . . . . . . . 562
Overhead Console Reading
Lamps . . . . . . . . . . . . . . . . . . 578
Visor Vanity Lamps . . . . . . . . . 194
Glove Box Lamp (for versions/
markets, where provided) . . . . . 194
Door Courtesy . . . . . . . . . . . . . 562
Shift Indicator Lamp . . JKLE14140
Optional Door Map Pocket/Cup-
holder . . . . . . . . . . . . . . . . . . LED(Serviced at Authorized Dealer) NOTE:
For lighted switches, see your au-
thorized dealer for replacement
instructions.
All of the interior bulbs are glass
wedge base or glass cartridge types.
Aluminum base bulbs are not ap-
proved and should not be used for
replacement.
Exterior
Bulb Number
Low Beam/High Beam (Bi-Xenon
Headlamp) . . . . . . . . . . . . . . . D3S
(Serviced at Authorized Dealer)
Front Turn Signal
Lamp . . . . . . . . . . . . . PSY24WSV
Front Park Lamp . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Daytime Running Lamp . . . . . LED
(Serviced at Authorized Dealer)
Front Fog Lamp (for versions/
markets, where provided) . . . . H11
Front Position Lamp . . . . . . . LED
(Serviced at Authorized Dealer)
Front Side Marker Lamp . . . . LED
(Serviced at Authorized Dealer)
Side Repeater Lamps . . . . . . . LED
(Serviced at Authorized Dealer) Rear Tail/Stop/Side Marker
Lamp . . . . . . . . . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Rear Turn Signal Lamp . . . WY21W
Rear Fog Lamps . . . . . . . . . . LED
(Serviced at Authorized Dealer)
Backup Lamp . . . . . . . . . . . W16W
Center High Mount Stop Lamp
(CHMSL) . . . . . . . . . . . . . . . LED
(Serviced at Authorized Dealer)
License . . . . . . . . . . . . . . . . W5W
280

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Replace spark plugs. 
Replace air filter cartridge.    
Change engine oil and replace oil filter. Every 12.000 km or 12 months whichever comes first
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 000 km
or 48 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);  operation of windshield washer/
wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
292

 check and, if necessary, replace pol-len filter;
 check and, if necessary, replace air cleaner filter.
MAINTENANCE
SCHEDULE – DIESEL
ENGINE
To help you have the best driving
experience possible, the manufacturer
has identified the specific vehicle
maintenance service intervals that are
required to keep your vehicle operat-
ing properly and safely. The manufacturer recommends that
these maintenance intervals be per-
formed at your selling dealer. The
technicians at your dealership know
your vehicle best, and have access to
factory trained information, genuine
LANCIA parts, and specially designed
electronic and mechanical tools that
can help prevent future costly repairs.
The maintenance intervals shown
should be performed as indicated in
this section.
NOTE:
Under no circumstances should oil
change intervals exceed 20 000 km
or 12 months, whichever comes
first.
CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following pages for the required maintenance intervals.
Thousands Of Kilometers 20 40 60 80 100 120 140 160
Months 12 24 36 48 60 72 84 96
Flush and replace the engine coolant (or at 60 months). 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if neces-
sary.        
Check operation of lighting system (headlamps, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.).        
293

Thousands Of Kilometers20 40 60 80 100 120 140 160
Months 12 24 36 48 60 72 84 96
Check operation of windscreen washer system and adjust
jets if necessary.        
Check windshield/rear window wiper blade position/
wear.        
Check cleanliness of hood and tailgate locks and cleanli-
ness and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, under-
body protection, pipes and hoses (exhaust - fuel system -
brakes), rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes,
windshield washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Adjust parking brake shoes as necessary. 
Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter (*). 
Replace fuel filter. 
Replace accessory drive belt/s. 
Replace air filter cartridge. 
Change engine oil and replace oil filter (**).
Change brake fluid (or every 24 months). 
Replace pollen filter.        
294

(*) Change the automatic transmis-
sion fluid and filter(s) at 100 000 km
or 60 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
(**) The actual oil and oil filter re-
placement interval depends on the car
usage conditions and is indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
Periodic Checks
Every1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner filter.
295

About Your Brakes . . . . . . . . . 206
ABS (Anti-Lock Brake
System) . . . . . . . . . . . . . . . . 208
Adaptive Cruise Control (ACC)
(Cruise Control) . . . . . . . . . . 117
Adding Engine Coolant
(Antifreeze) . . . . . . . . . . . . . . 266
Adding Fuel . . . . . . . . . . . . . 226
Adding Washer Fluid . . . . . . . 263
Additives, Fuel . . . . . . . . . . . 224
Adjustable Pedals . . . . . . . . . 114
Air Cleaner, Engine (Engine
Air Cleaner Filter) . . . . . . . . . 259Air Conditioner Maintenance
. . 261
Air Conditioning Filter . . . 185,261
Air Conditioning Refrigerant . . 261
Air Conditioning System
. . 184,261
Air Pressure, Tires . . . . . . . . . 214
Airbag . . . . . . . . . . . . . . . . 33,39
Airbag Deployment . . . . . . . . . 40
Airbag Light . . . . . . 38,41,52,156
Airbag Maintenance . . . . . . . . . 40
Airbag, Side . . . . . . . . . . 35,37,39
Airbag, Window
(Side Curtain) . . . . . . . . 35,37,39
Alarm Light . . . . . . . . . . . . . 158
Alarm System (Security Alarm)
. . 15
Alterations/Modifications,
Vehicle . . . . . . . . . . . . . . . . . . . 7 Anti-Lock Brake System
(ABS) . . . . . . . . . . . . . . 208,209
Anti-Lock Warning Light . . . . 158
Antifreeze
(Engine Coolant) . . . . . . . 266,283
Disposal . . . . . . . . . . . . . . 267
Appearance Care . . . . . . . . . . 271
Assist, Hill Start . . . . . . . . . . 211
Auto Down Power Windows . . . 23
Auto Unlock, Doors . . . . . . . . . 19
Auto Up Power Windows . . . . . 23
Automatic Dimming Mirror . . . 63
Automatic Door Locks . . . . . . . 19
Automatic Headlights . . . . . . . 105
Automatic Oil Change
Indicator . . . . . . . . . . . . . . . . 164
Automatic Temperature
Control (ATC) . . . . . . . . . . . . 184
Automatic Transaxle
Special Additives . . . . . . . . 270
Automatic
Transmission . . . 196,199,270,271 Adding Fluid . . . . . . . . 271,285
Autostick . . . . . . . . . . . . . . 202
Fluid and Filter Changes . . . 271
Fluid Change . . . . . . . . . . . 271
Fluid Level Check . . . . . . . 270
Fluid Type . . . . . . . . . . . . . 285
Special Additives . . . . . . . . 270 Automatic Transmission Limp
Home Mode . . . . . . . . . . . . . 198
Autostick . . . . . . . . . . . . . . . 202
Axle Fluid . . . . . . . . . . . . . . . 285
Axle Lubrication
(Axle Fluid) . . . . . . . . . . . . . 285
Battery . . . . . . . . . . . . . . . . . 260
Keyless Transmitter
Replacement (RKE) . . . . . . . 17
Location . . . . . . . . . . . . . . 260
Belts, Seat . . . . . . . . . . . . . 26,51
Body Mechanism
Lubrication . . . . . . . . . . . . . . 262
Brake Assist System . . . . . . . . 209
Brake Control System,
Electronic . . . . . . . . . . . . . . . 209
Brake Fluid . . . . . . . . . . . . . . 285
Brake System . . . . . . . . . . . . 268 Anti-Lock (ABS) . . . . . . . . 208
Fluid Check . . . . . . . . 269,285
Master Cylinder . . . . . . . . . 269
Parking . . . . . . . . . . . . . . . 206
Warning Light . . . . . . . . . . 157
Brake, Parking . . . . . . . . . . . 206
Brake/Transmission
Interlock . . . . . . . . . . . . . . . . 196
Brakes . . . . . . . . . . . . . . . . . 268
298

Through Flowing, Rising, or
Shallow Standing Water . . . 204
Driving to Achieve Maximum
Fuel Economy . . . . . . . . . . . . 165
Electric Rear Window
Defrost . . . . . . . . . . . . . . . . . 145
Electric Remote Mirrors . . . . . . 64
Electrical Power Outlets . . . . . 140
Electronic Brake Control
System . . . . . . . . . . . . . . . . . 209
Anti-Lock Brake System . . . 209
Brake Assist System . . . . . . 209
Traction Control System . . . 209
Electronic Power Distribution
Center (Fuses) . . . . . . . . . . . . 274
Electronic Speed Control
(Cruise Control) . . . . . . . 115,117
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 210
Electronic Vehicle Information
Center (EVIC) . . . . . . . . 134,159
Emergency Deck Lid Release . . 25
Emergency Trunk Release . . . . 25
Emergency, In Case of Freeing Vehicle When
Stuck . . . . . . . . . . . . . . . . 248
Hazard Warning Flasher . . . 240
Jump Starting . . . . . . . . . . 246 Overheating . . . . . . . . . . . . 240
Towing . . . . . . . . . . . . . . . 251
Engine Air Cleaner . . . . . . . . . . . . 259
Break-In Recommendations . . 50
Compartment . . . . . . . 255,256
Compartment
Identification . . . . . . . . 255,256
Coolant (Antifreeze) . . . 265,284
Cooling . . . . . . . . . . . . . . . 265
Exhaust Gas Caution . . . . . . 51
Fails to Start . . . . . . . . . . . 192
Flooded, Starting . . . . . . . . 192
Fuel Requirements . . . . . . . 223
Jump Starting . . . . . . . . . . 246
Oil . . . . . . . . . . . . 258,283,284
Oil Change Interval . . . 164,258
Oil Disposal . . . . . . . . . . . . 259
Oil Filter . . . . . . . . . . . . . . 259
Oil Selection . . . . . 258,259,283
Oil Synthetic . . . . . . . . . . . 259
Overheating . . . . . . . . . . . . 240
Starting . . . . . . . . . . . . . . . 191
Temperature Gauge . . . . . . 159
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 39
Entry System, Illuminated . . . . 16
Ethanol . . . . . . . . . . . . . . . . 224
Event Data Recorder . . . . . . . . 41 Exhaust Gas Caution . . . . . 51,264
Exhaust System . . . . . . . . 51,264
Exterior Folding Mirrors . . . . . . 63
Exterior Lighting . . . . . . . . . . 104
Exterior Lights . . . . . . . . . . . . 53
Filler Location Fuel . . . . . . . . 156
Filters
Air Cleaner . . . . . . . . . . . . 259
Air Conditioning . . . . . 185,261
Engine Oil . . . . . . . . . . 259,284
Flash-To-Pass . . . . . . . . . . . . 108
Flashers Hazard Warning . . . . . . . . . 240
Turn Signal . . . . . . . 53,107,154
Flooded Engine Starting . . . . . 192
Floor Console . . . . . . . . . . . . 143
Fluid Capacities . . . . . . . . . . . 283
Fluid Leaks . . . . . . . . . . . . . . 53
Fluid Level Checks Automatic Transmission . . . 270
Brake . . . . . . . . . . . . . . . . 269
Cooling System . . . . . . . . . 265
Engine Oil . . . . . . . . . . . . . 258
Fluid, Brake . . . . . . . . . . . . . 285
Fluids . . . . . . . . . . . . . . . . . . 284
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 284
Fog Lights . . . . . . . . . . . . . . 154
300