2012 Lancia Musa light

173
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MANUTENZIONEE CURA
3
12
45
L0D0488mfig. 5 - 1.6 Multijet versions
1 Engine coolant - 2 Engine oil - 3 Brake fluid - 4 Battery - 5 Windscreen/rear
window washer/wiper
fig. 6 -1.4 8V versions
(for versions/markets, where provided)L0D0258m
ENGINE OIL fig. 6-7-8-9-10
Checking engine oil level
Check the oil level a few minutes
(about 5) after the engine has
stopped, with the car parked on level
ground.
The oil level shall be included be-
tween the MINandMAXmarks on
the dipstick . The range between the
MINandMAXlevels corresponds to
approximately 1 litre of oil.

174
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
Proceed very carefully in-
side the engine compart-
ment when the engine is hot: risk of
burns. Remember that the fan may
start up if the engine is hot: risk of
injury. Pay attention to scarves,
ties and other loose fitting gar-
ments: they could get dragged by
the moving parts.
WARNING
Waste engine oil and oil fil-
ters contains substances
which are dangerous for the
environment. You are ad-
vised to go to a Lancia Dealership to
have the oil and filters replaced.
fig. 9 - 1.3 Multijet 95 HP
versionsL0D0495mfig. 8 - 1.3 Multijet versionsL0D0209m
Engine oil consumption
The maximum engine oil consump-
tion is usually 400 grams every 1000
km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered sta-
bilised after the first 5000 - 6000 km.
IMPORTANT The oil consumption
depends on driving style and the con-
ditions under which the car is used.
IMPORTANT Always top up using
engine oil of the same types as that al-
ready in the engine.
fig. 7 - 1.416VversionsL0D0208m
Topping up engine oil
If the oil level is near or even under
theMINline, add oil through the filler
to reach the MAXline. Oil level shall
never exceed the MAXline.
IMPORTANT If the engine oil level
after the check is over the MAXlevel,
go to a Lancia Dealership to have the
correct level restored.
IMPORTANT After adding or chang-
ing the oil, let the engine turn over for
a few seconds and wait a few minutes
after turning it off before you check
the level.

175
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
ENGINE COOLANT fig. 11-12
The coolant level must be checked
when the engine is cold and must be
between the MINandMAXlines on
the vessel.
If the level is so, slowly pour a mixture of
demineralised water and PETRONAS
LUBRICANTSPA R A F L U
UPin a 50-50
proportion.
A 50-50 mixture of PA R A F L U
UPand
distilled water gives freeze protection
to 35°C.
IMPORTANT Do not remove the cap
from the vessel when the engine is
very hot: risk of burns.
fig. 11 - 1.48Vversions
(for versions/markets,
where provided) and 1.4
16V
L0D0210mfig. 12 - 1.3 Multijet
and 1.6 Multijet versionsL0D0211m
When the vehicle is used under par-
ticularly harsh weather conditions, we
recommend using a 60-40 mixture of
PA R A F L U
UPand demineralised wa-
ter.
PA R A F L UUPantifreeze is
used in the engine cooling
system. Use fluid of the same type
contained in the cooling system for
top-ups. PARAFLU
UPmay not be
mixed with other types of fluids. If
this accidentally occurs, do not start
the engine and contact a Lancia
Dealership.
WARNING
The engine cooling system
is pressurized. If required,
replace the cap with an original
spare part so as not to compromise
system efficiency.
WARNING
fig. 10 - 1.6 Multijet versionsL0D0489m

176
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
BRAKE FLUID fig. 14
Release cap: check that the liquid
contained in the tank is at the maxi-
mum level.
Fluid level in the reservoir must not
exceed the MAXmark.
Use the brake fluid shown in the
“Fluids and lubricants” table (see
“Technical Specifications”).
NOTE Carefully clean the cap of
reservoir A and the surrounding sur-
face.
When opening the cap, make sure
that no dirt gets into the reservoir.
For topping up always use a funnel
with built-in filter (mesh smaller than
or equal to 0.12 mm).
IMPORTANT Brake fluid is hygro-
scopic (i.e. it absorbs moisture). For
this reason, if the car is mainly used
in areas with a high degree of atmos-
pheric humidity, the fluid should be
replaced at more frequent intervals
than specified in the “Service sched-
ule”.
fig. 14L0D0213m
Do not travel with the
windscreen washing reser-
voir empty: the action of the wind-
screen washer is essential for im-
proving visibility.
WARNING
Some commercial addi-
tives for windscreen wash-
ing are flammable. The engine
compartment contains hot parts
which could start a fire if they
come into contact.
WARNINGWINDSCREEN/REAR WINDOW
WASHER FLUID fig. 13
To add fluid, lift the cap Aand pour
in a mixture of water and TUTELA
PROFESSIONAL SC35fluid in the
following proportions:
❒30% of TUTELA PROFESSIONAL
SC35and 70% water in summer.
❒50% of TUTELA PROFESSIONAL
SC35and 50% water in summer.
UseTUTELA PROFESSIONAL SC35
neat at temperatures lower than 20°C.
Check level through the reservoir.
fig. 13L0D0212m

177
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
Prevent brake fluid which
is highly corrosive from
coming into contact with
painted parts. Should this
occur, immediately wash with wa-
ter.
Brake fluid is poisonous
and highly corrosive. In
the case of accidental contact, wash
the parts with water and mild soap
and rinse with plenty of water.
Call a doctor immediately if swal-
lowed.
WARNING
Symbolπon the contain
indicates a synthetic brake
fluid, which is different from a
mineral fluid. Use of a mineral
type fluid will damage the special
rubber seals of the braking system
beyond repair.
WARNING
FUEL FILTER
(green filter)
DRAINING CONDENSATION
(Multijet versions)
The presence of water in
the feeding circuit may
cause severe damage to the injec-
tion system and irregular engine
operation. If the warning lights c
on the cluster lights up or a mes-
sage appears on the reconfigurable
multifunctional display (some ver-
sions), contact a Lancia Dealership
to have the system bled. Water may
have been introduced in the tank if
this appears immediately after re-
fuelling: in this case, stop the en-
gine immediately and contact a
Lancia Dealership.
WARNING
CHECKING CHARGE
AND ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner’s Handbook
only by specialised personnel.
Topping must be carried out by spe-
cialised personnel at a Lancia Dealer-
ship.
Battery liquid is poisonous
and corrosive. Avoid con-
tact with the skin and eyes. Keep
naked flames and sources of
sparks away from the battery: risk
of explosion and fire.
WARNING
BATTERY
The battery is of the low maintenance
type and the electrolyte does not need
to be topped up with distilled water in
normal conditions of use.

178
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
Running the battery with
an excessively low liquid
level will damage the battery be-
yond repair and even cause an ex-
plosion.
WARNING
CHANGING THE BATTERY
If required, replace the battery with a
genuine spare part having the same
specifications.
If a battery with different specifica-
tions is fitted, the service intervals
given in the “Service schedule” in this
section will no longer apply.
Follow the battery manufacturer’s in-
structions for maintenance.Batteries contain very dan-
gerous substances for the
environment. You are rec-
ommended to go to a Lan-
cia Dealership to have the battery
replaced where the old battery will
be disposed of respecting both the
environment and the laws in force.Incorrect assembly of elec-
tric and electronic devices
may cause severe damage
to your car. Go to a Lancia
Dealership if you want to install ac-
cessories (alarms, mobile phone,
etc.): they will suggest the most suit-
able devices and advise you if a
higher capacity battery needs to be
installed.USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and
lengthen its life, observe the following
indications:
❒when the car is parked, make sure
that the doors, bonnet and tailgate
are closed properly to make sure
that the lights inside the passenger
compartment go out;
❒switch off all lights inside the vehi-
cle: the car is however equipped
with a system which switches all in-
ternal lights off automatically;
❒do not keep devices (e.g. sound sys-
tem, hazard lights, etc.) on for a
long time with the engine off;
❒before performing any operation on
the electrical system, disconnect the
battery negative cable;
❒battery terminals shall always be
perfectly tightened.
If the car is left for long
periods in very cold envi-
ronments, remove the battery and
store it in a warm place to prevent
freezing.
WARNING
Always wear the proper
protective eyewear when
working on the battery or near it.
WARNING

179
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
IMPORTANT A battery which is kept
at a charge of less than 50% (optical
indicator with dark colour without
green area in the middle) for any
length of time will be damaged by sul-
phation leading to a reduction in
cranking power.
The battery will also be more at risk
of freezing (e.g. already at -10°C).
In case of prolonged halt, refer to the
“Storing the car” paragraph in the
“Starting and driving” chapter.
If after buying the car, you want to in-
stall electric accessories which require
permanent electric supply (alarm,
etc.) contact Lancia Dealership whose
qualified personnel, in addition to
suggesting the most suitable devices
from Lineaccessori Lancia, will eval-
uate the overall electric absorption,
checking whether the car’s electric
system is capable of withstanding the
load required, or whether it should be
integrated with a more powerful bat-
tery.
Since these devices continue absorb-
ing energy even when the ignition key
is off, they gradually run down the
battery.WHEELS AND
TYRES
Check the pressure of each type, in-
cluding the spare, approximately once
every two weeks and before starting a
long journey: this check must be per-
formed with the tyre rested and cold.
It is normal for pressure to increase
when the car is used. For the correct
tyre inflation pressure, see “Wheels”
in “Technical specifications” section.
Incorrect pressure causes abnormal
tyre wearfig. 15:
A: normal pressure: evenly worn
tread.
B: low pressure: tread particularly
worn on the edges.
C: excessive pressure: tread particu-
larly worn in the middle.
The tyres must be replaced when the
tread is less than 1.6 mm thick. In all
cases, follow the laws in force in the
country where you are driving.IMPORTANT NOTES
❒Avoid braking suddenly, burning
starts and violent knocks against
the curb, potholes or other obsta-
cles if possible. Long distances on
rough roads may damage the tyres;
❒check the tyres regularly for cuts on
the sides, swelling or irregular tread
wear. Go to a Lancia Dealership if
required.
❒Do not overload your vehicle: this
may cause serious damage to
wheels and tyres;
❒if a tyre is punctured, stop the ve-
hicle immediately and charge it to
avoid damage to the tyre, the rim,
suspensions and steering system;
fig. 15L0D0216m

180
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
❒a tyre will age even if it is not used
much. Cracks in the tread and on
the sidewalls are a sign of ageing.
Have the tyres checked by spe-
cialised personnel if they have been
fitted for longer than 6 years. Re-
member to check the spare wheel
very carefully;
❒In case of replacement, always fit
new tyres, avoiding those with an
unknown origin.
❒If a tyre is replaced, also change the
inflation valve.
❒to allow even wear between the
front and rear tyres, it is advisable
to change them over every 10-15
thousand kilometres, keeping them
on the same side of the car so as not
to reverse the direction of rotation.
Remember that the road
holding qualities of your
car also depends on the correct in-
flation pressure of the tyres.
WARNING
Excessively low pressure
will cause overheating of
the tyre and may cause severe tyre
damage.
WARNING
Do not exchange the tyres
from the left to the right of
the car and vice versa.
WARNING
Do not repaint alloy wheel
rims at temperatures
higher than 150°C. The mechani-
cal features of the wheels could be
compromised.
WARNING
RUBBER HOSES
Carefully follow the information con-
tained in the “Service schedule” in
this section for maintenance of brake
system and fuel feed rubber hoses.
Ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the
hoses, with possible leaks. Careful in-
spections are therefore necessary.