2012 Lancia Delta transmission

1
KNOWING YOUR CAR151
ELECTRICAL/ELECTRONIC
DEVICE INSTALLATION
The electric/electronic devices installed subsequent to the
purchase of the car and included in the after-sales service
must be marked:
FIAT S.p.A. authorises the installation of transceiver de-
vices on condition that such installations are carried out
in a workmanlike fashion, following the manufacturer’s
instructions, at a specialised centre.
IMPORTANT Traffic authorities may not allow the ve-
hicle on the road if devices are fitted that modify vehicle
specifications. This may also invalidate the warranty in
relation to faults caused by the change or either directly
or indirectly related to it. FIAT S.p.A. shall not be liable
for damage caused by the installation of accessories ei-
ther not supplied or recommended by FIAT S.p.A. and/or
not installed in compliance with the provided instruc-
tions.RADIO TRANSMITTERS AND CELLULAR PHONES
Radio transmitter equipment (vehicle mobile phones, CB
radios, amateur radio etc.) cannot be used inside the car
unless a separate aerial is mounted on the roof.
IMPORTANT The use of such devices inside the passen-
ger compartment (without a separate aerial), may cause
the car’s electronic systems to malfunction. This could
compromise safety in addition to constituting a poten-
tial hazard for passengers.
In addition, transmission and reception of these devices
may be affected by the shielding effect of the vehicle
body. As far as the use of EC-approved mobile phones is
concerned (GSM, GPRS, UMTS), follow the instructions
for use provided by the mobile phone manufacturer.

236SERVICING AND MAINTENANCE
Perform the following inspections more frequently than
indicated in the Scheduled Servicing Plan:
❍check front disc brake pad condition and wear;
❍check cleanliness of bonnet and boot locks, as well as
cleanliness and lubrication of linkages;
❍visually inspect the condition of engine, gearbox,
transmission, pipes and hoses (exhaust – fuel supply
– brakes) rubber elements (boots – sleeves – bushes
etc.);❍check battery charge and fluid level (electrolyte);
❍visually inspect the condition of auxiliary drive belts;
❍check air filter and replace, if required.

6
TECHNICAL SPECIFICATIONS257
Identification data .......................................................... 258
Engine codes – bodywork versions .................................. 260
Engine ............................................................................ 261
Fuel supply system ......................................................... 263
Transmission .................................................................. 264
Brakes ............................................................................. 264
Suspensions .................................................................... 265
Steering ........................................................................... 265
Wheels ............................................................................ 266
Dimensions ..................................................................... 271
Performance ................................................................... 272
Weights ........................................................................... 273
Capacities ....................................................................... 275
Fluids and lubricants ...................................................... 277
Fuel consumption ........................................................... 279
CO
2emissions ................................................................ 280

Six forward speed plus reverse with synchronisers for the engagement of the forward speeds
Self-adjusting pedal without idle stroke
Front
264TECHNICAL SPECIFICATIONS
TRANSMISSION
Self-ventilated discs
Disc
Controlled by hand lever, acting on rear brakes
BRAKES
IMPORTANT Water, ice and salt spread on the roads may deposit on the brake disks reducing braking efficiency
the first time the brakes are applied.
1.4 Turbo Jet – 1.4 Turbo Multi Air ––1.6 Multijet ––1.9 Twin Turbo Multijet – 2.0 Multijet
Service brakes:
– front
– rear
Parking brake
1.4 Turbo Jet – 1.4 Turbo Multi Air ––1.6 Multijet ––1.9 Twin Turbo Multijet – 2.0 Multijet
Gearbox
Clutch
Drive

57 –
8/10 –
6.0 –
3.1 2.65
3.5 3.0
1.99 1.8
–0.8
6–57 –
8/10 –
5,9 –
2.75 2.4
2.9 2.55
2.4 2.0
–0.8
6–
TECHNICAL SPECIFICATIONS275
6
Unleaded petrol not less than
95 R.O.N (EN228 specifications)
Mixture of demineralised
water and PARAFLU
UP
in 50-50 proportion (▲)
SELENIA K P.E.
SELENIA WR P.E. (❍)
TUTELA CAR MATRYX ()
TUTELA TRANSMISSION
GEARFORCE (❍)
TUTELA TOP 4
Water and liquid mixture
TUTELA PROFESSIONAL SC 35
CAPACITIES
(▲) When the vehicle is used in particularly harsh climate conditions, we recommend using a mixture of 60% PARAFLUUP
and 40% distilled water.
() 1.4 Turbo Jet 150 HP version
(❍) 1.4 Turbo Jet 120 HP and 1.4 Turbo Multi Air versions
1.4 Turbo Jet 1.4 Turbo MultiAir Recommended fuelslitres kg litres kg and original lubricants
Fuel tank:including a reserve of:
Engine cooling system:
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit with ABS:
Windscreen/rear window washer
fluid reservoir:

57 –
8/10 –
7.1 –
4.3 3.6
4.9 4.1
1.87 (❍) 1.7 (❍)
3.1 () 2.7 ()
–0.8
6–Diesel fuel for motor vehicles
(Specification EN590)
Mixture of 50% demineralised water and
50% PARAFLU
UP(▲)
SELENIA WR P.E.
TUTELA TRANSMISSION GEARFORCE (❍)
TUTELA CAR MATRYX ()
TUTELA TOP 4
Water and liquid mixture
TUTELA PROFESSIONAL SC 35
57 –
8/10 –
7.1 –
4.3 3.6
4.9 4.1
1.87 (❍) 1.7 (❍)
–0.8
6–
276TECHNICAL SPECIFICATIONS
(▲) When the vehicle is used in particularly harsh climate conditions, we recommend using a mixture of 60% PARAFLUUPand
40% distilled water.
(❍) 1.6 Multijet and 2.0 Multijet versions
() 1.9 Twin Turbo Multijet version
1.6 Multijet 1.9 Twin Turbo Multijet Recommended fuels
2.0 Multijet and original lubricants
litres kg litres kg
Fuel tank:including a reserve of:
Engine cooling system:
Engine sump:Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit with ABS:
Windscreen/rear window
washer fluid reservoir:

Petrol
engine
lubricants
SAE 75W grade synthetic base lubricant.
Classification 9.55550-MZ6
Synthetic based lubricant, grade SAE 75W-85.
Exceeds API GL-4 specifications.
Classification 9.55550-MZ1
Grease for constant-velocity joints with low
friction coefficient. NL.GI. 0-1 consistency
Classification 9.55580
Molybdenum disulphide grease
for high temperatures. NL.GI. 1-2 consistency
Classification 9.55580
Synthetic fluid for brake and clutch systems.
It exceedes the specifications: FMVSS no. 116 DOT 4,
ISO 4925, SAE J 1704. Classification 9.55597
Red protective with antifreeze action, based
on inhibited monoethyl glycol with organic formula.
Exceeding CUNA NC 956-16,
ASTM D 3306 specifications.
Additive for diesel fuel, protecting Diesel engines
Mixture of spirits and surfactants.
Exceeds CUNA NC 956-11 specifications.
Classification 9.55522
278TECHNICAL SPECIFICATIONS
TUTELA TRANSMISSIONGEARFORCE
Contractual Technical
Reference No. F002.F10
TUTELA CAR MATRYX Contractual Technical
Reference No. F108.F02
TUTELA STAR 700
Contractual Technical
Reference No. F701.C07
TUTELA ALL STAR
Contractual Technical
Reference No. F702.G07
TUTELA TOP 4
Contractual Technical
Reference No.F001.A93
PARAFLU
UP(●)
Contractual Technical
Reference No. F101.M01
TUTELA DIESEL ARTContractual Technical
Reference No. F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference No. F201.D02 Brake fluid
Protective
agent for
radiators
Additive for
diesel fuel
Windscreen/
rear window
washer fluid
(
●) IMPORTANT Do not use fluids with different specifications for topping up or mixing.
(❑) When the vehicle is used in particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLUUPand distilled water.
Gearboxes and manual
mechanical (1.4 Turbo Jet
120 HP, 1.4 Turbo Multi Air,
1.6 Multijet and 2.0 Multijet
versions)
Gearboxes and manual
differentials
(1.9 Multijet versions)
CV joints differential side
CV joints wheel side
Hydraulic brakes and
hydraulically operated clutch
windscreen/rear window
washer/wiper
Cooling circuits.
Percentage of use:
50% water
50% PARAFLU
UP(❑)
To be mixed with diesel
(25 cc per 10 litres)
To be used diluted or undiluted
in windscreen/rear window
washer/wiper systems
Use Fluid and lubricant features for correct use of the car Genuine fluids and lubricants Applications

LIST OF CONTENTS291
7
Ty r e s
– inflation pressure ............270
– provided as standard ......268
– reading tyre markings ....266
– replacement ....................199
– Rim Protector .................268
– snow tyres ......................268
Using the manual
gearbox .............................182
Warning lights on panel ..... 11
Weights ...............................273
Wheel (changing) ................199
Wheel rims
– reading rim markings .....268
Wheels ................................266
When parked ......................181Window cleaning washer .... 68
Windows (cleaning) ............249
Windscreen wipers
– blades .............................245
– control ............................ 68
– nozzles ...........................246 Supply ................................263
Suspension ..........................265
– Reactive Suspension
System ...........................107
Symbols .............................. 40
T.P.M.S. system ..................129
Technical specifications .......257
Third brake lights
(bulb replacement) ............214
Top speeds ..........................272
Towing the car ....................227
Towing trailers ....................185
Transmission .......................264
Trip Computer .................... 38
TTC system ........................118