2012 HONDA INSIGHT transmission

CONT INUED
Saf ely pull to the side of the road.
Put the transmission in Park, and
set the parking brake. Turn of f all
the accessories, and turn on the
hazard warning lights.If you see steam and/or spray
coming f rom under the hood, turn
of f the engine. Wait until you see
no more signs of steam or spray,
then open the hood.
If you do not see steam or spray,
leave the engine running, and
check the high temperature
indicator. If the high heat is due to
overloading, the engine should
start to cool down almost
immediately. If it does, wait until
the high temperature indicator
goes of f , then continue driving.
If the high temperature indicator
stays on, turn of f the engine.Look f or any obvious coolant leaks,
such as a split radiator hose.
Everything is still extremely hot,
so use caution. If you f ind a leak, it
must be repaired bef ore you
continue driving (see
on page ).
If you don’t f ind an obvious leak,
check the coolant level in the
radiator reserve tank (see page ). Add coolant if the level is
below the MIN mark.
If there was no coolant in the
reserve tank, you may need to add
coolant to the radiator. Let the
engine cool down until the high
temperature indicator goes of f
bef ore checking the radiator.
1. 2.
3.
4.5.
6.
7.
376
252
If theEngineOverheats
Emergency
Towing
T aking Care of t he Unexpect ed
363
Steam and spray from an
overheated engine can
seriously scald you.
Do not open the hood if steam
is coming out.

µ
µ If , due to damage, your vehicle must
be towed with the f ront wheels on
the ground, do this:
With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
Therearetwowaystotowyour
vehicle:
The tow
truck uses two pivoting arms that go
under the tires (f ront) and lif t them
of f the ground. The other two tires
remain on the ground. The operator
loads your vehicle on the back of a
truck. Start the engine.
Shif t to the D position and hold f or
5 seconds, then to N.
Turn of f the engine.
Release the parking brake.
Leave the ignition switch in the
ACCESSORY (I) position so the
steering wheel does not lock.Wheel-lif t Equipment
Flat -bed Equipment
T his is an
acceptable way to tow your
vehicle. T his is the best way to
transport your vehicle.
Emergency Towing
376
Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine, your vehicle must be
transported with the f ront wheels of f
the ground.

The engine number is stamped into
the engine block.
The transmission number is on a
label on top of the transmission.
The IMA Motor Number is stamped
on the motor housing.
Identif ication Numbers
Technical Inf ormation
381
ENGINE NUMBER
TRANSMISSION NUMBER IMA MOTOR NUMBER

Î
Î
Î
Î
Specif ications
382
Dimensions
Weights
Seating CapacitiesCapacities
Engine 172.3 in (4,377 mm)
66.7 in (1,695 mm)
56.2 in (1,427 mm)
100.4 in (2,550 mm)
58.3 in (1,481 mm)
58.0 in (1,472 mm)
Length
Width
Height
Wheelbase
Track
Gross vehicle weight rating See the certification label attached
to the driver’s doorjamb. 3.4 US qt (3.2
)
3.2 US qt (3.0)
4.0 US qt (3.8)
Total
Front
Rear 5
2
3
Excluding the oil remaining in the engine Including the coolant in the reserve tank and that remaining in the
engine
Reserve tank capacity: 0.116 US gal (0.44
)
2.6 US qt (2.5
)
4.76 US qt (4.50)
Fuel tank
Engine
coolant
Engine oil
Automatic
transmission
fluid (CVTF)
Windshield
washer
reservoir
Type
BorexStroke
Displacement
Compression ratio
Spark plugs 10.8 : 1
82 cu-in (1,339 cm
)
2.87 x 3.15 in (73.0 x 80.0 mm) 3.0 US qt (2.8
)
5.5 US qt (5.2)
10.6 US gal (40
)
1.165 US gal (4.41)
1.295 US gal (4.90)
Water cooled 4-stroke SOHC i-VTEC gasoline engine with Hybrid Electric Motor
DILFR6J11
Front
Rear
Approx.
1:
2: Change
Total
Change
Including filter
Without filter
Total
Change
Total
U.S. Vehicles
Canada Vehicles
(NGK)
1
2

CONT INUED
....................................
Accessories . 256
ACCESSORY (Ignition Key
.....................................
Position) . 131
.............
Accessory Power Socket . 157
................
Active Head Restraints . 144
....................
Additives, Engine Oil . 313
.............................
Airbag (SRS) . 10, 25
...
Airbags, Additional Information . 25
...
Additional Safety Precautions . 37
..........
AdvancedAirbagSystem .30
.............................
Airbag Service . 36
How the Passenger Airbag Of f ......................
Indicator Works . 35
How the Side Airbag Of f ......................
Indicator Works . 34
..
How the SRS Indicator Works . 34
How Your Front Airbags
.........................................
Work . 28
...
How Your Side Airbags Work . 32
How Your Side Curtain Airbags
.........................................
Work . 33
........................
SRS Components . 25
..............
Air Conditioning System . 164
.......................
Air Pressure, Tires . 341................................
Ambient Meter . 72
......................................
Antif reeze . 317
Anti-lock Brakes (ABS) ...............................
Indicator . 64, 289
...................................
Operation . 289
..............
Anti-thef t, Audio System . 221
Anti-thef t Steering Column
............................................
Lock . 131
..........................................
Armrest . 146
................................
Audio System . 170
.......................
Auto Door Locking . 109
...................
Auto Door Unlocking . 110
................................
Auto Idle Stop . 283
...
Automatic Seat Belt Tensioners . 23
.............
Automatic Speed Control . 224
.
Automatic Transmission (CVT) . 273
..........................
Capacity,Fluid .382
...............
Checking Fluid Level . 420
Paddle Shif ters in the
..............................
D Position . 278
Paddle Shif ters in the ...............................
S Position . 281
.....
Recommended Shif t Points . 282
.......................................
Shif ting . 274
Shif t Lever Position ...............................
Indicators . 273 ................
Shif t Lever Positions . 275
....................
Shif t Lock Release . 277
......................
Auxiliary Input Jack . 220
Battery Charging System ...........................
Indicator . 63, 366
............................
Jump Starting . 360
..............................
Maintenance . 346
............................
Specif ications . 383
..............................
Bef ore Driving . 245
....................................
Belts,Seat .9,21
...........................
Beverage Holder . 156
.......
Bluetooth
HandsFreeLink. 227
Brakes ...........
Anti-lock System (ABS) . 289
.............
Break-in, New Linings . 246
....................
Bulb Replacement . 332
...........................................
Fluid . 321
...................
Pad Wear Indicator . 288
.......................................
Parking . 151
...........
System Indicator . 63, 64, 368
Index
A
B
INDEX
I

.............................
Braking System . 287
.................
Break-in, New Vehicle . 246
Brightness Control,
...............................
Instruments . 124
Bulb Replacement ..........................
Back-up Lights . 329
..............................
Brake Lights . 332
........
Front Side Marker Lights . 328
.........
Front Turn Signal Lights . 327
.................................
Headlights . 323
..........................
Parking Lights . 326
..........
Rear Turn Signal Lights . 329
............................
Specif ications . 383
..............................
Bulbs, Halogen . 323
.........................
Cargo Area Cover . 153
..........................
Cargo Area Light . 162
............................
Capacities Chart . 382
.............
Carbon Monoxide Hazard . 56
.............................
Carrying Cargo . 258
.............
CAUTION, Explanation of . iii
..................................
Ceiling Light . 161
..............................
Center Pockets . 159
...................................
Center Tray . 158 ........................
Certif ication Label . 380
............................................
Chains . 314
....................
Changing a Flat Tire . 351
Changing Oil
........................................
How to . 314
......................................
When to . 301
...
Charging System Indicator . 63, 366
............
Checklist, Bef ore Driving . 264
.....................................
Child Saf ety . 38
Child Seats
.............
LATCH Anchor System . 47
.............................
Lower Anchor . 47
............................
Tether Anchor . 51
................
Childproof Door Locks . 134
.............................
Climate Control . 164
.........................
Clock, Setting the . 222
........................
CO in the Exhaust . 389
............
Cold Weather, Starting in . 265
..............................
Compact Spare . 350
.................
Console Compartment . 158
.............
Controls, Instruments and . 59
Coolant
........................................
Adding . 317
....................................
Checking . 252
.........................
Proper Solution . 317
...............
Temperature Indicator . 67 Crankcase Emissions Control
........................................
System . 389
............
Cruise Control Operation . 224
.........................
Customer Service . 396
...............
DANGER, Explanation of . iii
...................................
Dashboard . 3, 60
..............
Daytime Running Lights . 123
............
Def ects, Reporting Saf ety . 398
..............
Def ogger, Rear Window . 126
......
Def rosting the Windows . 167, 168
....................................
Dimensions . 382
.............
Dimming the Headlights . 120
Dipstick
..........
Automatic Transmission . 320
..................................
Engine Oil . 251
........................
Directional Signals . 120
Disc Brake Pad Wear
...................................
Indicators . 288
.....................................
Disc Player . 190
.....................
Disposal of Used Oil . 316
Index
C D
II

CONT INUED
Doors...................
Auto Door Locking . 109
...............
Auto Door Unlocking . 110
............
Childproof Door Locks . 134
............
Locking and Unlocking . 133
..........
DOT Tire Quality Grading . 384
...........
Driver and Passenger Safety . 5
...........................................
Driving . 263
....................................
Economy . 253
..................
Dust and Pollen Filter . 334 ...................................
Fan, Interior . 166
.........................................
Features . 163
....................
Filling the Fuel Tank . 247
Filters
.........................
Dust and Pollen . 334
...............................................
Oil . 315
...........
Flashers, Hazard Warning . 125
...................
Flat Tire, Changing a . 351
.....................................
Floor Mats . 333
Fluids
..........
Automatic Transmission . 320
..........................................
Brake . 321
..................
Windshield Washer . 319
FM Stereo Radio ...................................
Reception . 214
........................
Four-way Flashers . 125
............................
Front Airbags . 10, 25
........................
Eco Assist System . 266
.......
Eco Guide Feedback Monitor . 81
................................
ECON Button . 124
..................................
ECON Mode . 124
..............................
Economy, Fuel . 253
............
Emergencies on the Road . 349
.............
Battery, Jump Starting . 360
.....
Brake System Indicator . 63, 368
................
Changing a Flat Tire . 351
Charging System
...........................
Indicator . 63, 366
..................
Checking the Fuses . 371 Low Oil Pressure
...........................
Indicator . 62, 365
Malf unction Indicator ................................
Lamp . 62, 367
..................
Overheated Engine . 362
.........................
Emergency Brake . 151
....................
Emergency Flashers . 125
...........
Emergency Hatch Opener . 140
......................
Emergency Towing . 376
.......................
Emissions Controls . 389
........................
Emissions Testing . 392
Engine ............
Adding Engine Coolant . 317
Coolant Temperature
...................................
Indicator . 67
.........................
If It Won’t Start . 358
Malf unction Indicator ................................
Lamp . 62, 367
.........................
Oil Lif e Display . 301
........
Oil Pressure Indicator . 62, 365
..............
Oil, What Kind to Use . 312
...............................
Overheating . 362
............................
Specif ications . 382
............................
Speed Limiter . 276
.......................................
Starting . 265
.
Evaporative Emissions Controls . 389 ...............................
Exhaust Fumes . 56
Expectant Mothers, Use of Seat ........................................
Belts by . 19
Index
F
E
INDEX
III

.................................................
Fuel . 246
......................
Fill Door and Cap . 247
...........................................
Gauge . 73
................
Octane Requirement . 246
...............................
Oxygenated . 246
........................
Reserve Indicator . 70
........................
Tank, Filling the . 247
.....................
Fuses, Checking the . 371
...............
Gas Mileage, Improving . 253
.........................................
Gasoline . 246
...............
Fuel Reserve Indicator . 70
...........................................
Gauge . 73
................
Octane Requirement . 246
........................
Tank, Filling the . 247
................
Gas Station Procedures . 247
Gauges
.............................
Charge/Assist . 74
...............................................
Fuel . 73
............
Gearshif t Lever Positions . 273
..........
Automatic Transmission . 273
......................................
Glove Box . 158
...
Identif ication Number, Vehicle . 380 Ignition
............................................
Keys . 129
.........................................
Switch . 131
............
Timing Control System . 390
IMA System Power Flow ........................................
Monitor . 84
......................
Immobilizer System . 130
.........
Important Safety Precautions . 6
.........
Indicators, Instrument Panel . 62
...
Indicators, Messages (MID) . 62, 89
...............
ABS (Anti-lock Brake) . 64
..............................
Auto Idle Stop . 66
Brake (Parking and Brake
............................
System) . 63, 368
.............................
Cruise Control . 69
.................................
Cruise Main . 69
................
Door/Hatch Open . 12, 68
DRL (Daytime Running
....................................
Lights) . 123
.
EPS (Electric Power Steering) . 68
................................
ECON Mode . 71
...................................
High Beam . 69
....
High Temperature (Coolant) . 67
......................
IMA Battery Level . 85
.................................
IMA System . 66
........
Key (Immobilizer System) . 63
.............
Halogen Headlight Bulbs . 323
...........................
HandsFreeLink
. 227
..............................................
Hatch . 139
......................................
Opening . 139
............................
Open Indicator . 68
............
Hazard Warning Flashers . 125
Headlights
........................................
Aiming . 323
.........
Daytime Running Lights . 123
..................
High Beam Indicator . 69
......................
Reminder Beeper . 121
........
Replacing Halogen Bulbs . 323
.................................
Turning on . 121
............................
Head Restraints . 142
.............................
Heated Mirrors . 148
.............
High Altitude, Starting at . 265
...............
High-Low Beam Switch . 120
...............
Hill Start Assist System . 297
.......................
Hood, Opening the . 250
....................................................
Horn . 4
Index
I H
G
IV