2012 FORD FUSION (AMERICAS) transmission fluid

Normal Scheduled Maintenance
At every oil change
interval as indicated
by the message
centerChange engine oil and filter
Rotate tires, inspect tire wear and measure tread
depth
Perform multi-point inspection (recommended)
Inspect automatic transmission fluid level (if
equipped with dipstick); consult dealer for
requirements
Inspect brake pads, shoes, rotors, drums, brake
linings, hoses and parking brake
Inspect cabin air filter (if equipped)
Inspect engine cooling system strength and hoses
Inspect exhaust system and heat shields
Inspect rear axle and U-joints; lubricate if
equipped with grease fittings (AWD vehicles)
Inspect half-shaft boots (if equipped)
Inspect steering linkage, ball joints, suspension,
tie-rod ends, driveshaft and U-joints; lubricate if
equipped with grease fittings
Inspect wheels and related components for
abnormal noise, wear, looseness or drag
Reset your Intelligent Oil Life Monitor™ after each engine oil and filter
change; refer to theInstrument Clusterchapter
Do not exceed one year or 10,000 miles (16,000 km) between
service intervals
Scheduled Maintenance
353
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

Additional maintenance items
1
Miles (x 1,000) 20 30 40 60 80 90 100 120 140 150
Kilometers (x 1,000) 32 48 64 96 128 144 160 192 225 240
Replace cabin air filter (if equipped)• ••• •••
Replace climate-controlled seat filter (if equipped)•••••
Replace engine air filter•••••
Change engine coolant
2
•
Replace spark plugs•
Inspect accessory drive belt(s)••
Change automatic transmission fluid and filter•
Change manual transmission fluid•
Replace accessory drive belt(s) if not replaced within the last
100,000 miles (160,000 km)•
1Additional maintenance items can be performed within 3,000 miles (4,800 km) of the last oil change. Do not exceed
the designated distance for the interval.2Initial replacement at 6 years or 100,000 miles (160,000 km), then every 3 years or 50,000 miles (80,000 km)
Scheduled Maintenance
354
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

SPECIAL OPERATING CONDITIONS
If you operate your vehicleprimarilyin any of the following conditions,
you need to perform additional maintenance as indicated. If you
occasionallyoperate your vehicle under any of these conditions, it is
not necessary to perform the additional maintenance. For specific
recommendations, see your dealership service advisor or technician.
Towing a trailer or using a camper or car-top carrier
As required Change engine oil and filter as indicated by
message center and perform services listed in the
Normal Scheduled Maintenance chart
Inspect frequently,
service as requiredInspect and lubricate U-joints
See axle maintenance items underExceptions
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 60,000 miles
(96,000 km)Change manual transmission fluid
Perform the services in the preceding table when specified or within
3,000 miles (4,800 km) of the OIL CHANGE REQUIRED message
appearing in the message center.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Extensive idling and/or low-speed driving for long distances as
in heavy commercial use (i.e. delivery, taxi, patrol car or livery)
As required Change engine oil and filter as indicated by
message center and perform services listed in the
Normal Scheduled Maintenance chart
Inspect frequently,
service as requiredReplace cabin air filter (if equipped)
Replace engine air filter
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 60,000 miles
(96,000 km)Replace spark plugs
Scheduled Maintenance
358
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

Perform the services in the preceding table when specified or within
3,000 miles (4,800 km) of the OIL CHANGE REQUIRED message
appearing in the message center.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently,
service as requiredReplace cabin air filter (if equipped)
Replace engine air filter
Every 5,000 miles
(8,000 km)Inspect the wheels and related components for
abnormal noise, wear, looseness or drag
Rotate tires, inspect tires for wear and measure
tread depth
Every 5,000 miles
(8,000 km) or
6 monthsChange engine oil and filter
Every 30,000 miles
(48,000 km)Change automatic transmission fluid (except
Focus)
Every 50,000 miles
(80,000 km)Change manual transmission fluid
Reset your Intelligent Oil Life Monitor™ after each engine oil and filter
change; refer to theInstrument Clusterchapter
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change If ran exclusively on E85, fill the fuel tank full
with regular unleaded fuel
Scheduled Maintenance
359
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

A
Accessory delay ..........................81
AdvanceTrac ..............................214
Airbag supplemental restraint
system ........................145, 154, 157
and child safety seats ............147
description ..............145, 154, 157
disposal ....................................160
driver airbag ....145, 147, 155, 158
indicator light .........153, 156, 160
operation .........145, 147, 155, 158
passenger
airbag ...............145, 147, 155, 158
side airbag ...............................154
Air cleaner filter .......324–325, 330
Air conditioning
automatic temperature
control system ....................47, 50
All Wheel Drive (AWD),
driving off road .........................241
Ambient mood/lighting ...............60
Antifreeze
(see Engine coolant) ................299
Anti-lock brake system
(see Brakes) ......................212–213
Anti-theft system ..............112, 116
arming the system ..................116
disarming a triggered
system .....................................117
triggering .................................117
Audio system (see Radio) .........28
Automatic transmission
driving an automatic
overdrive .........................222, 224
fluid, adding ....................320, 324
fluid, checking ................320, 324
fluid, refill capacities ..............331fluid, specification ..................331
Selectshift (SST) ....................226
Auxiliary input jack (Line in) ....35
Axle
lubricant specifications ..........331
B
Battery .......................................297
acid, treating emergencies .....297
jumping a disabled battery ....264
maintenance-free ....................297
replacement, specifications ...330
servicing ..................................297
Belt-Minder.............................140
Blind Spot Information
System .......................................235
Blind spot mirror ......................234
Booster seats .............................174
Brakes ........................................212
anti-lock ...........................212–213
anti-lock brake system (ABS)
warning light ...........................213
fluid, checking and adding ....319
fluid, refill capacities ..............331
fluid, specifications .................331
lubricant specifications ..........331
parking ....................................214
shift interlock ..........................220
Break-in period .............................5
Bulbs ............................................60
C
Capacities for refilling fluids ....331
CD ................................................28
Cell phone use ..............................8
Changing a tire .........................257
Index
364
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

Child safety seats ......................165
attaching with tether straps ..171
in front seat ............................166
in rear seat ..............................166
LATCH .....................................169
recommendations ...................163
Child safety seats - booster
seats ...........................................174
Cleaning your vehicle
engine compartment ..............280
instrument panel ....................282
interior .....................................283
plastic parts ............................281
washing ....................................278
waxing .....................................279
wheels ......................................279
wiper blades ............................282
Climate control (see Air
conditioning or Heating) ......47, 50
Clock ............................................28
Clutch
fluid ..........................................319
operation while driving ..........228
recommended shift
speeds ..............................227–228
Compass, electronic ....................76
calibration .................................77
set zone adjustment .................77
Console ........................................78
overhead ....................................76
Controls
power seat ...............................122
steering column ........................86
Coolant
checking and adding ..............299
refill capacities ................303, 331
specifications ..........................331
Cross Traffic Alert ....................235Cruise control
(see Speed control) ....................83
Cupholder(s) .............................130
Customer Assistance ................248
Ford Extended Service
Plan ..................................342, 345
Getting assistance outside the
U.S. and Canada .....................274
Getting roadside assistance ...248
Getting the service you
need .........................................270
Ordering additional owner’s
literature .................................276
Utilizing the
Mediation/Arbitration
Program ...................................274
D
Daytime running lamps
(see Lamps) ................................57
Defrost
windshield .................................50
Dipstick
automatic transmission
fluid ..................................320, 322
engine oil .................................292
Driving under special
conditions ..................228, 242, 244
sand .........................................243
snow and ice ...........................245
through water .................243, 247
E
Electronic message center .........18
Emergencies, roadside
jump-starting ..........................264
running out of fuel .........264, 311
Emission control system ..........315
Index
365
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

manual heating and air
conditioning system .................45
Hood ..........................................287
I
Ignition ...............................207, 336
Illuminated visor mirror .............75
Infant seats
(see Safety seats) .....................165
Inspection/maintenance (I/M)
testing ........................................317
Instrument panel ........................79
cleaning ...................................282
cluster ........................................12
lighting up panel and
interior .......................................57
J
Jack ............................................257
positioning ...............................257
storage .....................................257
Jump-starting your vehicle ......264
K
Keyless entry system
autolock ...................................101
keypad .....................................111
locking and unlocking doors ..112
programming entry code .......111
Keys .....................................95, 114
positions of the ignition .........207
L
Lamps
autolamp system .......................55bulb replacement
specifications chart ..................61
daytime running light ...............57
fog lamps ...................................56
headlamps .................................55
headlamps, flash to pass ..........57
instrument panel, dimming .....57
interior lamps .....................59, 62
replacing bulbs .........................62
LATCH anchors .........................169
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........213
Load limits .................................200
Locks
autolock ...................................101
childproof ................................105
doors ........................................101
Lubricant specifications ...........331
Lug nuts ....................................263
Lumbar support, seats .....121, 123
M
Manual transmission .................228
fluid capacities ........................331
lubricant specifications ..........331
reverse .....................................229
Message center .....................18–19
english/metric button ...............23
system check button ................23
warning messages .....................23
Mirrors ...................................82–83
automatic dimming rearview
mirror ........................................82
heated ........................................83
side view mirrors (power) .......83
Moon roof ....................................87
Motorcraftparts ..............285, 330
Index
367
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)

Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............352
Seats ..........................................118
child safety seats ....................165
front seats ...............................120
heated ......................................124
SecuriCode keyless entry
system ........................................111
SecuriLock passive anti-theft
system ........................................112
Servicing your vehicle ..............286
Setting the clock .........................28
Side air curtain .........................157
SOS Post Crash Alert ...............160
Spark plugs,
specifications .....................330, 336
Specification chart,
lubricants ...................................331
Speed control ..............................83
Starting your
vehicle ........................207–208, 210
jump starting ..........................264
Steering
speed sensitive .......................220
Steering wheel
controls ......................................86
tilting .........................................74
Stereo
CD-MP3 .....................................28
SYNC..........................................44
T
Tilt steering wheel ......................74Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....194
Tires ...........................179–180, 257
alignment ................................187
care ..........................................183
changing ..................................257
checking the pressure ............183
inflating ...................................181
label .........................................193
replacing ..................................185
rotating ....................................188
safety practices .......................187
sidewall information ...............188
snow tires and chains ............199
spare tire .................................258
terminology .............................180
tire grades ...............................180
treadwear ........................179, 184
Towing .......................................205
trailer towing ..........................205
wrecker ....................................268
Transmission .............................222
brake-shift interlock (BSI) ....220
fluid, checking and adding
(automatic) .............................322
fluid, checking and adding
(manual) .........................322, 324
fluid, refill capacities ..............331
lubricant specifications ..........331
manual operation ....................228
Trunk .........................................105
remote release ..................94, 109
Turn signal ..................................59
U
Universal garage door opener ....89
USB port ......................................37
Index
369
2012 Fusion(fsn)
Owners Guide, 3rd Printing
USA(fus)