2012 FORD ESCAPE HYBRID ignition

These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel, properly closing the fuel fill inlet or letting the
electrical system dry out. After three driving cycles without these or any
other temporary malfunctions present, the service engine soon
indicator should stay off the next time the engine is started. A driving
cycle consists of a cold engine startup followed by mixed city/highway
driving. No additional vehicle service is required.
If the service engine soon
indicator remains on, have your vehicle
serviced at the first available opportunity. Although some malfunctions
detected by the OBD-II may not have symptoms that are apparent,
continued driving with the service engine soon
indicator on can
result in increased emissions, lower fuel economy, reduced engine and
transmission smoothness, and lead to more costly repairs.
Readiness for Inspection/Maintenance (I/M) testing
Some state/provincial and local governments may have
Inspection/Maintenance (I/M) programs to inspect the emission control
equipment on your vehicle. Failure to pass this inspection could prevent
you from getting a vehicle registration. Your vehicle may not pass the I/M
test if the service engine soon
indicator is on or not working
properly (bulb is burned out), or if the OBD-II system has determined
that some of the emission control systems have not been properly
checked. In this case, the vehicle is considered not ready for I/M testing.
If the service engine soon
indicator is on or the bulb does not
work, the vehicle may need to be serviced. Refer toOn-board
diagnostics (OBD-II)in this chapter.
If the vehicle’s engine or transmission has just been serviced, or the
battery has recently run down or been replaced, the OBD-II system may
indicate that the vehicle is not ready for I/M testing. To determine if the
vehicle is ready for I/M testing, turn the ignition key to the on position
for 15 seconds without cranking the engine. If the service engine
soon
indicator blinks eight times, it means that the vehicle is not
ready for I/M testing; if the service engine soon
indicator stays on
solid, it means that the vehicle is ready for I/M testing.
The OBD-II system is designed to check the emission control system
during normal driving. A complete check may take several days. If the
vehicle is not ready for I/M testing, the following driving cycle consisting
of mixed city and highway driving may be performed:
15 minutes of steady driving on an expressway/highway followed by
20 minutes of stop-and-go driving with at least four 30-second idle periods.
Maintenance and Specifications
318
2012 Escape Hybrid(ehv)
Owners Guide, 1st Printing
USA(fus)

Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete. If
the vehicle is still not ready for I/M testing, the above driving cycle will
have to be repeated.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Check fluid levels with the ignition
in the on position. Fluid levels
between the MIN and MAX lines are
within the normal operating range;
there is no need to add fluid.
If the fluid levels are outside of the
normal operating range the
performance of your brake system could be compromised; seek service
from your authorized dealer immediately.
TRANSMISSION FLUID
Checking electronically controlled continuously variable
transmission (eCVT)
The eCVT does not have an underhood transmission fluid dipstick.
Your transmission does not consume fluid. It is designed to be filled for
life. However, the fluid level should be checked if the transmission is not
working properly, or if you notice some sign of fluid leakage.
Transmission fluid should be checked and, if required, fluid
should be added by an authorized dealer.
Do not use supplemental transmission fluid additives, treatments or
cleaning agents. The use of these materials may affect transmission
operation and result in damage to internal transmission components.
Maintenance and Specifications
319
2012 Escape Hybrid(ehv)
Owners Guide, 1st Printing
USA(fus)

ENGINE DATA
Engine 2.5L I4 engine
Cubic inches 152
Required fuel Minimum 87 octane
Firing order 1-3-4-2
Ignition system Coil on plug
Spark plug gap 0.049–0.053 inch (1.25–1.35mm)
Compression ratio 12.3:1
Engine drivebelt routing
HIGH VOLTAGE BATTERY DATA
High voltage battery
Battery chemistry Nickel metal hydride
Nominal voltage 330 volts
Battery system capacity 6 amp-hours
Maintenance and Specifications
327
2012 Escape Hybrid(ehv)
Owners Guide, 1st Printing
USA(fus)

specifications ..........................324
Event data recording ..................14
Exhaust fumes ..........................214
F
Fleet MyKey programming ........98
Floor mats .............................92–93
Fluid capacities .........................324
Fog lamps ....................................60
Four-Wheel Drive vehicles
driving off road .......................239
preparing to drive your
vehicle .....................................225
Fuel ............................................307
calculating fuel
economy ............................29, 313
cap ...........................................309
capacity ...................................324
choosing the right fuel ...........310
detergent in fuel .....................311
filler funnel .............................312
filling your vehicle
with fuel ..................307, 309, 314
filter, specifications ........307, 323
fuel pump/high voltage
shut-off switches ....................248
improving fuel economy ........313
octane rating ...................311, 327
quality ......................................311
running out of fuel .........269, 312
safety information relating
to automotive fuels ................307
Fuses ..................................249–250
G
Garage door opener ....................86
Gas cap (see Fuel cap) ............309Gas mileage
(see Fuel economy) .................313
Gauges .........................................25
H
Hazard flashers .........................247
Headlamps ...................................59
aiming ........................................62
bulb specifications ....................66
daytime running lights .............61
flash to pass ..............................60
high beam .................................60
replacing bulbs .........................67
turning on and off ....................59
Heating
heating and air conditioning
system .......................................54
Hood ..........................................292
I
Ignition ...............................211, 327
Illuminated visor mirror .............73
Infant seats
(see Safety seats) .....................163
Inspection/maintenance (I/M)
testing ........................................318
Instrument panel
cleaning ...................................286
cluster ........................................20
lighting up panel and
interior .......................................61
J
Jack ............................................258
positioning ...............................258
storage .....................................258
Jump-starting your vehicle ......270
Index
355
2012 Escape Hybrid(ehv)
Owners Guide, 1st Printing
USA(fus)

K
Keyless entry system
autolock ...........................103, 105
keypad .....................................111
locking and unlocking doors ..113
programming entry code .......111
Keys .....................................97, 115
positions of the ignition .........211
L
Lamps
bulb replacement
specifications chart ..................66
daytime running light ...............61
fog lamps ...................................60
headlamps .................................59
headlamps, flash to pass ..........60
instrument panel, dimming .....61
interior lamps ...............63–64, 66
replacing bulbs .........................67
LATCH anchors .........................167
Liftgate ................................93, 109
Lights, warning and indicator ....20
anti-lock brakes (ABS) ..........217
Loading instructions .................205
Load limits .................................199
Locks
autolock ...........................103, 105
childproof ................................107
doors ........................................103
Lubricant specifications ...........324
Luggage rack ...............................94
Lug nuts ....................................268
Lumbar support, seats .............121M
Manual transmission
fluid capacities ........................324
lubricant specifications ..........324
Message center ...........................27
english/metric button ...............31
system check button ................31
warning messages .....................31
Mirrors ...................................79–80
automatic dimming rearview
mirror ........................................79
fold away ...................................80
heated ........................................81
side view mirrors (power) .......80
Moon roof ....................................84
Motorcraftparts ..............289, 323
MyKey ..........................................98
N
Navigation system .......................53
O
Octane rating ............................311
Oil (see Engine oil) ..................296
P
Parental MyKey programming ...98
Park Assist ................................233
Parking brake ............................218
Parts
(see Motorcraftparts) ...........323
Passenger Occupant
Classification Sensor .................131
Index
356
2012 Escape Hybrid(ehv)
Owners Guide, 1st Printing
USA(fus)