2012 FIAT FREEMONT oil dipstick

ENGINE COMPARTMENT — 3.6L (fig. 177)(fig. 177)1 — Engine Coolant Reservoir 5 — Air Cleaner Filter
2 — Power Steering Fluid Reservoir 6 — Washer Fluid Reservoir
3 — Brake Fluid Reservoir 7 — Engine Oil Dipstick
4 — Totally Integrated Power Module (Fuses) 8 — Engine Oil Fill
270
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

ENGINE COMPARTMENT — 2.0L DIESEL (fig. 178)(fig. 178)1 — Engine Coolant Reservoir 5 — Brake Fluid Reservoir
2 — Power Steering Fluid Reservoir 6 — Totally Integrated Power Module (Fuses)
3 — Engine Oil Fill 7 — Air Cleaner Filter
4 — Engine Oil Dipstick 8 — Washer Fluid Reservoir
271
KNOWING
YOURVEHICLE SAFETY
STARTING ANDDRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

MAINTENANCE PROCEDURES
The pages that follow contain therequiredmainte-
nance services determined by the engineers who de-
signed your vehicle.
Besides those maintenance items specified in the fixed
maintenance schedule, there are other components
which may require servicing or replacement in the
future.
 Failure to properly maintain your ve-
hicle or perform repairs and service when
necessary could result in more costly re-
pairs, damage to other components or negatively
impact vehicle performance. Immediately have
potential malfunctions examined by an autho-
rized dealership or qualified repair center.
 Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended mainte-
nance intervals. Do not use chemical flushes in
these components as the chemicals can damage
your engine, transmission, power steering or air
conditioning. Such damage is not covered by the
New Vehicle Limited Warranty. If a flush is needed
because of component malfunction, use only the
specified fluid for the flushing procedure. ENGINE OIL
Checking Oil Level – Gasoline Engine
To assure proper engine lubrication, the engine oil
must be maintained at the correct level. Check the oil
level at regular intervals, such as every fuel stop.
The best time to check the engine oil level is about five
minutes after a fully warmed engine is shut off. Do not
check oil level before starting the engine after it has sat
overnight. Checking engine oil level when the engine is
cold will give you an incorrect reading.
Checking the oil while the vehicle is on level ground
and only when the engine is hot, will improve the
accuracy of the oil level readings. Maintain the oil level
between the range markings on the dipstick. Either the
range markings consist of a crosshatch zone marked
SAFE or a crosshatch zone marked with MIN at the low
end of the range and MAX at the high end of the range.
Adding 1 Liter of oil when the reading is at the low end
of the range marking will raise the oil level to the high
end of the range marking.
Do not overfill the engine. Overfilling the
engine will cause oil aeration, which can
lead to loss of oil pressure and an in-
crease in oil temperature.This could damage your
engine.Also, be sure the oil fill cap is replaced and
tightened after adding oil.
272
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Checking Oil Level – Diesel Engine
To assure proper engine lubrication, the engine oil
must be maintained at the correct level. Check the oil
level at regular intervals, such as every fuel stop.
The best time to check the engine oil level is about five
minutes after a fully warmed engine is shut off or
before starting the engine after it has sat overnight.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Maintain
the oil level between the MIN and MAX markings on
the dipstick. Adding 1 Liter of oil when the reading is at
the MIN mark will result in a MAX reading on theseengines.
Change Engine Oil – Gasoline Engine
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Change Engine Oil – Diesel Engine
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Engine Oil Viscosity – 3.6L Gasoline Engine
SAE 5W-30 engine oil is recommended for all operating
temperatures. This engine oil improves low tempera-
ture starting and vehicle fuel economy.The engine oil filler cap also shows the recommended
engine oil viscosity for your vehicle. For information on
engine oil filler cap location, refer to “Engine Compart-
ment” in “Servicing And Care” for further information.
Engine Oil Viscosity – 2.0L Diesel Engine
For best performance and maximum protection under
all types of operating conditions, the manufacturer
recommends Fully Synthetic Low Ash 5W-30 engine
oils that meet the requirements of FIAT 9.55535-S1
spec and ACEA C1/C2.
Materials Added To Engine Oil
Do not add any supplemental materials, other than leak
detection dyes, to the engine oil. Engine oil is an
engineered product and its performance may be im-
paired by supplemental additives.
Disposing Of Used Engine Oil And Oil Filters
Care should be taken in disposing of used engine oil and
oil filters from your vehicle. Used oil and oil filters,
indiscriminately discarded, can present a problem to
the environment. Contact your authorized dealer, ser-
vice station, or governmental agency for advice on how
and where used oil and oil filters can be safely discarded
in your area.
273
KNOWING
YOURVEHICLE SAFETY
STARTING ANDDRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Fluid Level Check – Six-Speed Automatic
Routine fluid level checks are not required, therefore
the transmission has no dipstick. Your authorized
dealer can check your transmission fluid level using a
special service dipstick. If you notice fluid leakage or
transmission malfunction, visit your authorized dealer
immediately to have the transmission fluid level
checked. Operating the vehicle with an improper fluid
level can cause severe transmission damage.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter if the transmis-
sion is disassembled for any reason.
MANUAL TRANSMISSION (for versions/
markets, where provided)
Fluid Level Check
Visually inspect manual transmission for leakage at each
oil change. Add fluid, if necessary, to maintain the
proper fluid level.
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and
a point not more that 4.7 mm below the bottom of the
hole.
Lubricant Selection
Use only manufacturers recommended transmission
fluid. Do not add any materials (other than leak detec-tion dyes). Refer to “Fluids, Lubricants, and Genuine
Parts” in “Technical Specifications” for further
information.
Frequency Of Fluid Change
Change the manual transmission fluid at the intervals
shown in the “Maintenance Schedule” in this manual.
REAR DRIVE ASSEMBLY (RDA) – AWD
MODELS ONLY
Lubricant Selection
Use only the manufacturer's recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Technical
Specifications” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage.
If leakage is detected, check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 4 mm below the fill
hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
286
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCYSERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Disposal of Used Coolant . . . . . . . . . . . . . . . . . 283
Drain, Flush, and Refill . . . . . . . . . . . . . . . . . . . 281
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 283
Points to Remember . . . . . . . . . . . . . . . . . . . . 283
Pressure Cap . . . . . . . . . . . . . . . . . . . . . . . . . 282
Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . 282
Selection of Coolant (Antifreeze) . . . . . . 281,301,302
Temperature Gauge . . . . . . . . . . . . . . . . . . . . . . . 7
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . 287
Cupholders . . . . . . . . . . . . . . . . . . . . . . . . . . 92,290
Data Recorder, Event . . . . . . . . . . . . . . . . . . . . . 191
Daytime Brightness, Interior Lights . . . . . . . . . . . . . 74
Daytime Running Lights . . . . . . . . . . . . . . . . . . . . . 72
Defroster, Rear Window . . . . . . . . . . . . . . . . . . . . 80
Defroster, Windshield . . . . . . . . . . . . . . . . . . . 64,193
Delay (Intermittent) Wipers . . . . . . . . . . . . . . . . . . 76
Diagnostic System, Onboard . . . . . . . . . . . . . . . . . 120
Diesel Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 300,302
Diesel Fuel Requirements . . . . . . . . . . . . . . . . . . . 300
Dimmer Switch, Headlight . . . . . . . . . . . . . . . . . . . 73Dipsticks Automatic Transmission . . . . . . . . . . . . . . . . . . 286
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . 272,273
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 122
Disabled Vehicle Towing . . . . . . . . . . . . . . . . . . . . 262Disposal
Antifreeze (Engine Coolant) . . . . . . . . . . . . . . . 283
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . 273
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Door Locks, Automatic . . . . . . . . . . . . . . . . . . . . . 97
Downshifting . . . . . . . . . . . . . . . . . . . . . . . . . . . 203 Driving
On Slippery Surfaces . . . . . . . . . . . . . . . . . . . . 210
Through Flowing, Rising, or Shallow Standing
Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Driving to Achieve Maximum Fuel Economy . . . . . . . 24
Electric Remote Mirrors . . . . . . . . . . . . . . . . . . . . 57
Electrical Outlet, Auxiliary (Power Outlet) . . . . . . . . 89
Electrical Power Outlets . . . . . . . . . . . . . . . . . . . . 89
Electronic Brake Control System . . . . . . . . . . . . . . 114 Anti-Lock Brake System . . . . . . . . . . . . . . . . . . 113
Brake Assist System . . . . . . . . . . . . . . . . . . . . . 116
Electronic Roll Mitigation . . . . . . . . . . . . . . . . . 117
Electronic Stability Program . . . . . . . . . . . . . . . . 117
Traction Control System . . . . . . . . . . . . . . . . . . 116
Electronic Roll Mitigation (ERM) . . . . . . . . . . . . . . 117
Electronic Speed Control (Cruise Control) . . . . . . . . 81
Electronic Stability Program (ESP) . . . . . . . . . . . . . 117
Electronic Vehicle Information Center (EVIC) . . . 19,134
Emergency, In Case of Freeing Vehicle When Stuck . . . . . . . . . . . . . . . 259
Hazard Warning Flasher . . . . . . . . . . . . . . . . . . . 85
Jacking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . 231
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195,271
Air Cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . 274
Break-In Recommendations . . . . . . . . . . . . . . . . 195
Checking Oil Level . . . . . . . . . . . . . . . . . . . 272,273
Compartment . . . . . . . . . . . . . . . . . . . . . . . . . 270
Compartment Identification . . . . . . . . . . . . . . . 270
Coolant (Antifreeze) . . . . . . . . . . . . . . . . . 280,302
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 280
309
KNOWING
YOURVEHICLE SAFETY
STARTING ANDDRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS

Vanity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Mode Fuel Saver . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Modifications/Alterations, Vehicle . . . . . . . . . . . . . . . 5
Monitor, Tire Pressure System . . . . . . . . . . . . . . . . 123
Multi-Function Control Lever . . . . . . . . . . . . . . . . . 73
Navigation System (Uconnect™ gps) . . . . . . . . 134,136
New Vehicle Break-In Period . . . . . . . . . . . . . . . . . 195
Occupant Restraints . . . . . . . . . . . . . . . . 158,186,189
Occupant Restraints (Sedan) . . . . . . . . 183,184,186,188
Octane Rating, Gasoline (Fuel) . . . . . . . . . . . . 298,302
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
Oil Change Indicator . . . . . . . . . . . . . . . . . . . . 23,226
Oil Change Indicator, Reset . . . . . . . . . . . . . . . 23,226
Oil, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . 272,302 Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 301
Change Interval . . . . . . . . . . . . . . . . . . . . . . 23,273
Checking . . . . . . . . . . . . . . . . . . . . . . . . . 272,273
Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . 272,273
Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 273
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 302
Filter Disposal . . . . . . . . . . . . . . . . . . . . . . . . . 273
Materials Added to . . . . . . . . . . . . . . . . . . . . . 273
Recommendation . . . . . . . . . . . . . . . . . . . . . . 301
Viscosity . . . . . . . . . . . . . . . . . . . . . . . . . 273,301
Onboard Diagnostic System . . . . . . . . . . . . . . . . . 120
Operating Precautions . . . . . . . . . . . . . . . . . . . . . 120
Operator Manual (Owner's Manual) . . . . . . . . . . . . . 4
Outside Rearview Mirrors . . . . . . . . . . . . . . . . . . . 57
Overhead Console . . . . . . . . . . . . . . . . . . . . . . . . 83
Owner's Manual (Operator Manual) . . . . . . . . . . . . . 4 Paint Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 287
Park Sense System, Rear . . . . . . . . . . . . . . . . . . . . 129
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Passenger Seat Back Tilt (Easy Entry System) . . . . . . . 52
Passing Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Pets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Power
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Distribution Center (Fuses) . . . . . . . . . . . . . . . . 256
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Outlet (Auxiliary Electrical Outlet) . . . . . . . . . . . 89
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . 121,122
Transfer Unit . . . . . . . . . . . . . . . . . . . . . . . . . 287
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Power Steering Fluid . . . . . . . . . . . . . . . . . . . . . . 303
Power Transfer Unit . . . . . . . . . . . . . . . . . . . 287,303
Pregnant Women and Seat Belts . . . . . . . . . . . . . . 169
Preparation for Jacking . . . . . . . . . . . . . . . . . . . . . 234
Pretensioners Seat Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Programming Transmitters (Remote Keyless Entry) . . 12
Radial Ply Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 293
Radiator Cap (Coolant Pressure Cap) . . . . . . . . . . . 282
Radio (Sound Systems) . . . . . . . . . . . . . . . . . . . . . 136
Radio Operation . . . . . . . . . . . . . . . . . . . . . . . . . 155
Radio Remote Controls . . . . . . . . . . . . . . . . . . . . 137
Rear Air Conditioning . . . . . . . . . . . . . . . . . . . . . . 66
Rear Axle (Differential) . . . . . . . . . . . . . . . . . . . . 286
Rear Camera . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Rear Cupholder . . . . . . . . . . . . . . . . . . . . . . . . . . 92
314
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND
CARETECHNICAL
SPECIFICATIONSCONTENTS