2012 FIAT DUCATO door lock

104
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0063mfig. 123
BONNET
OPENING
Proceed as follows:
❒open the driver’s door to gain access to the bonnet
release;
❒pull the lever fig. 123 in the direction of the arrow;
❒pull the lever A-fig. 124 as shown in the figure;
❒lift the bonnet and, at the same time, release the
bonnet stay fig. 125 from its locking device D, then
insert the end C-fig. 126 of the stay into the bonnet
housing E.
IMPORTANT Before opening the bonnet, check that
windscreen wiper arms are not lifted from the
windscreen. IMPORTANT With the ignition key in the STOP
position or extracted, the electric windows remain
activated for about 3 minutes and are then deactivated
immediately when one of the doors is opened.
Incorrect use of the electric windows
may be dangerous. Before and during
operation, always check that no-one is exposed
to the risk of being injured either directly by the
moving window or through objects getting
caught and being dragged. When leaving the
vehicle, always remove the key from the ignition
to avoid the risk of injury to anyone remaining
in the car due to accidental operation of the
electric windows.
WARNING
Front passenger side door
A dedicated switch for operating the window is located
on the inner armrest of the passenger side front door.

160
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
INCOMPLETE DOOR/LOAD
COMPARTMENT CLOSURE (red)
On some versions the warning light turns on
when one or more doors or the tailgate are not
properly closed.
On some versions, the display shows a dedicated
message that indicates left/right front door or rear/load
compartment door opening.
A buzzer will sound when doors/tailgate are open and
the vehicle is moving.
´
Degraded engine oil should be replaced as
soon as possible after the warning light
comes on, and never more than 500 km after it
first comes on.
If the above instructions are not complied with,
the engine could be severely damaged and it may
invalidate the warranty. Please note also that the
switching on of this warning light does not depend
on the oil quantity in the engine; when the
warning light flashes, never add oil.
WARNING
EBD FAILURE (red)
(amber)
Warning lights
xand >lit at the
same time with the engine running,
indicate an EBD system failure or that the system is not
available. Early locking of the rear wheels may occur in
the event of violent braking causing the car to swerve.
Drive very carefully to a Fiat Dealership to have the
system inspected immediately.
On some versions the display shows the dedicated
message.
>
SEAT BELT NOT FASTENED (red)
The warning light on the display will light up
when the vehicle is moving and the driver’s
seat belt is not correctly fastened. The warning
light will flash and a buzzer will sound if the front seat
belts are not correctly fastened with the vehicle in
motion. The SBR (Seat Belt Reminder) system’s audible
warning can be disabled only by a Fiat Dealership. On
some versions the system may be reactivated from the
setup menu.
<
x

191
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0241mfig. 193
REAR FOG LIGHTS (Maxi Van)
To change the bulb proceed as follows:
❒take up position at the rear of the side bumper;
❒unscrew the lower fastening A between the central
and side bumpers fig. 193;
❒after removing the tail-light, unscrew upper
fastening B;
❒unscrew both fastenings C-fig. 194 on the side of the
accessible rear swing door and open the door
slightly;
❒unscrew the three side fastenings D on the panel
side, accessible after removing the side mounting
fig. 194. To remove the moulding, undo the three
lower self-tapping screws and undo the pins with
care to avoid breaking them. If you break one or
more pins, they will have to be replaced;
F0N0242mfig. 194
F0N0243mfig. 195
❒remove the bulb holder;
❒turn bulb holder E anticlockwise (1/8 of a turn),
remove the bayonet bulb by pushing gently and
turning anticlockwise, then replace fig. 195.

198
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
FUSE SUMMARY TABLE
Dashboard fuse box fig. 205-206
USERSFUSE AMPERE
Right dipped headlamp F12 7.5
Left dipped headlamp F13 7.5
Engine compartment control unit relay, instrument panel control unit relay (+key) F31 5
Lighting of roof lights in the passenger compartment (+battery) F32 7.5
Battery monitoring sensor for Start&Stop versions (+battery) F33 20
Minibus interior lights (emergency) F34 20
Radio, A/C control, alarm, tachograph, F36 10
Battery disconnecting unit, Webasto timer (+battery)
Brake light control (main), third brake light, instrument panel (+key) F37 7.5
Door lock (+battery) F38 20
ABS, ASR, ESP, brake light control (secondary) (+key) F42 5
Windscreen washer (+key) F43 20
Driver's side electric window F47 20
Passenger side electric window F48 20
Parking sensor control unit, radio, controls on the steering wheel, F49 5
centre dashboard, left dashboard, auxiliary dashboard,
battery disconnecting unit (+key)
Airbag (+key) F50 7.5
Climate control system, power steering control unit, reversing lights, F51 5
water in diesel filter sensor, flow meter, tachograph (+key)

275
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– jump starting ....................... 169
– maintenance ........................ 218
– recharging ............................ 202
– replacement ........................ 218
– tips for extending life ........ 219
Body (marking) ......................... 228
Body
– maintenance ........................ 224
– version code ....................... 229
Bonnet ........................................ 104
Brake Assist (emergency
braking assistance) ................. 110
Brakes
– fluid level .............................. 215
– technical specifications ...... 232
Bulb replacement ..................... 181
– bulb types ....................182-183
– external bulb
replacement ............................ 184
– general information ........... 181
– internal bulb replacement .. 193Cab glove compartment
(Capucine) ............................... 91
Carrying children safely .......... 130
Carrying children safely .......... 130
– “Universal Isofix” child
restraint assembly setup ...... 134
– child seats ............................ 130
– positioning of child seats on
seats ..............................133-136
Ceiling lights .............................. 76
– bulb replacement ....... 193-194
Central door
locking/unlocking system ..... 96
Chassis (marking) .................... 229
Checking the levels ................. 209
Checking the levels ................. 209
– brake fluid ............................ 215
– brake fluid ............................ 216
– engine coolant .................... 213
– engine oil ............................. 211ABS SYSTEM ............................ 108
ABS .............................................. 108
Accessories purchased
by the owner .......................... 121
Additional heater ..................... 60
Additional rear heating ........... 66
Additional independent
heater ....................................... 61
Additional rear air
conditioning ............................ 67
Air filter ..................................... 217
Arm rests.................................... 33
Ashtray ........................................ 88
ASR .............................................. 112
Automatic climate control ..... 54
Automatic headlight sensor
(dusk sensor) .......................... 70
Battery
– battery disconnection
function (disconnector) .... 80
INDEX

276
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– washer fluid for
windscreen/rear
window/headlamps ............ 214
Cigar lighter .............................. 88
Cleaning and maintenance
– bodywork ............................ 223
– engine compartment .......... 225
– front headlights .................... 225
– glasses ................................... 225
– interiors ............................... 225
– leather upholstery .............226
– paintwork ............................ 224
– plastic parts .......................... 226
– rubber tubes ....................... 221
– seats and fabric parts ........ 226
– windows ................................ 225
CO
2emissions........................... 268
Instrument panel .................... 14
Code card................................... 5
Compartment under front
passenger seat ........................ 86
Compartment under the seat .. 36
Controls .................................... 79Cruise Control (constant speed
regulation) ............................... 74
Cruise Control (constant speed
regulator) ................................ 74
Cup/can holder ........................ 87
Dashboard ................................ 3
Daytime lights
– bulb replacement ............... 186
– control ................................. 68
Dead lock (device) .................. 99
Desk/bookrest........................... 90
Dimensions ............................... 237
Dipped beam headlights
– bulb replacement ............... 186
– control ................................. 68
Dipped headlights
– bulb replacement ............... 186
– control................................... 74
Direction indicators
– bulb replacement ....... 187-189
– control ................................. 69Direction indicators
– control ................................. 69
– front bulb replacement ..... 187
– rear bulb replacement ...... 189
Door lock .................................. 81
Door pockets ........................... 86
Doors ......................................... 96
DPF (diesel particulate filter).... 124
DPF (diesel particulate filter).... 124
EBD system .............................. 108
Electric windows ...................... 103
Electrical power supply and fuel
cut off switch .......................... 82
Electrical/electronic devices
(installation) ............................ 121
Electronic alarm ....................... 10
Engine codes ............................. 228
Engine compartment
– bonnet opening/closing ..... 104
– checking the levels ............. 209
– washing.................................. 225
Engine coolant fluid
– checking the level ............... 214

279
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Number plate lights (bulb
replacement) .......................... 192
Official type approval for radio
frequency remote control .... 271
On-board instruments
(panel) ..............................14-15
– engine coolant
temperature gauge ............. 16
– engine oil gauge .................. 17
– fuel level gauge..................... 16
– multifunction display ......... 18
– rev counter ......................... 15
– speedometer........................ 15
– trip computer ..................... 29
Paintwork
– identification plate ............. 228
– maintenance ........................ 224
Bodywork version ................. 229
Parking lights
– control ......................... 69-80
Parking sensors ........................ 116Passenger compartment
air vents ................................... 46
Performance ............................. 240
Pollen filter ................................ 217
Portable navigator socket ....... 91
Power socket ........................... 89
Preparation for “Isofix”
child seat ................................. 134
Pretensioners............................. 127
Protecting
the environment..................... 124
Quick tyre repair kit
“Fix & Go automatic” ........... 176
Radio .......................................... 119
Radio frequency
remote control:
official type approval ............. 269
Radio transmitters and mobile
phones ..................................... 121
Rain sensor ............................... 73
Raising the vehicle ................... 203
Rear double swing door ......... 101Rear fog light
– bulb replacement ....... 189-191
– control ................................. 80
Rear partition ........................... 87
Rear view mirrors.................... 42
– defrosting/demisting .......... 44
– electric adjustment ............ 42
– external ................................ 42
– interior ................................. 42
Refrigerated compartment .... 84
– Speed block .......................... 96
Refuelling (quantity
and products) .................263-264
Refuelling the vehicle .............. 122
Rev counter .............................. 15
Reversing lights (bulb
replacement) .......................... 189
Rim Protector (tyres).............. 234
Rims
– reading rim markings ......... 235
Roof lights
– bulb replacement ....... 193-194
– control ................................. 76

280
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Roof rack ................................... 106
Rubber tubes (servicing) ........ 221
Safety ......................................... 125
– “Isofix” child seat ............... 134
– carrying children safely ..... 130
– seat belts .............................. 125
Saving fuel (warning light) ...... 162
S.B.R. system ............................. 126
Scheduled servicing plan ... 204-206
Scrappage (prescriptions
for handling the vehicle
at the end of its life) .............. 268
Seat belts.................................... 125
– general warnings ................ 128
– load limiters ........................ 127
– maintenance ........................ 129
– pretensioners....................... 127
Seats (positioning of child seats
on seats) ..........................133-136
Seats
– adjustment ................... 31-32
– arm rests ............................... 33
– base plastic cover ............... 37– cleaning ................................ 226
– Combi versions .................. 38
– flap on bench ...................... 36
– headrests ............................. 40
– heating .................................. 35
– Panorama versions ............ 37
– revolving base ............. 33-34
– under-seat compartment... 36
Shelf above the cab ................. 90
Side bags .................................... 139
Side lights
– control ................................. 68
– front bulb replacement ..... 185
– rear bulb replacement ...... 189
– side bulb replacement ....... 193
Ski rack........................................ 106
Sliding side door........................ 100
Sliding side window.................. 100
Snow chains .............................. 155
Speedometer............................. 15
Starting the engine ................... 143
– bump starting ...................... 170– emergency starting ............ 169
– ignition switch ..................... 12
– jump starting ....................... 169
– procedure ............................ 143
– stopping the engine ........... 144
– warming up the engine
once started ........................ 144
Starting up and driving ............ 143
Steering lock.............................. 13
Steering wheel (adjustment) .. 41
Steering
– technical specifications ...... 232
– turning circle........................ 232
Storage compartments ... 84-85
Sun visors .................................. 89
Supply (specifications) ............. 231
Suspension (specifications) .... 231
Symbols ...................................... 4
Tachograph .............................. 105
Technical specifications .......... 227
Telepass (preparation) ............ 122
Third brake light ...................... 192