2012 FIAT 500 GUCCI engine

System Reset Procedure
•After an impact causing airbag deployment, the left and right turn signal lights, located in the
instrument panel cluster, will both be blinking, until the ignition is turned off.
• In order to move your vehicle to the side of the road you must follow the system reset
procedure.
Customer Action Customer Will See
1.Turn ignition OFF. (Turn Signal Switch
Must be placed in Neutral State).
2.Turn ignition ON. Left Turn Light is OFF. Right Turn Light BLINKS.
3.Turn Right Turn Signal Switch ON. Right Turn Light is ON SOLID. Left Turn Light BLINKS.
4.Turn Left Turn Signal Switch ON. Left Turn Light is ON SOLID. Right Turn Light BLINKS.
5.Turn Right Turn Signal Switch ON. Right Turn Light is ON SOLID. Left Turn Light BLINKS.
6.Turn Left Turn Signal Switch ON. Left Turn Light is ON SOLID. Right Turn Light is ON SOLID.
7.Turn Left Turn Signal Switch OFF.
(Turn Signal Switch Must be placed in
Neutral State). Left Turn Light is OFF. Right Turn Light is OFF.
8.Turn ignition OFF. System is now reset and the engine may be started.
9.Turn Hazard Flashers OFF
(Manually).
• If a reset procedure step is not completed within 45 seconds, then the turn signal lights will turn
off and the reset procedure must be performed again in order to be successful.
FREEING A STUCK VEHICLE
•If your vehicle becomes stuck in mud, sand or snow, it can often be moved by a rocking motion.
Turn your steering wheel right and left to clear the area around the front wheels.Then shift
back and forth between DRIVE/1st gear and REVERSE. Using minimal accelerator pedal
pressure to maintain the rocking motion, without spinning the wheels, is most effective.
NOTE: If your vehicle is equipped with Traction Control or Electronic Stability Control (ESC),
turn the system OFF before attempting to “rock” the vehicle.
CAUTION!
• Racing the engine or spinning the wheels may lead to transmission overheating and
failure.Allow the engine to idle with the shift lever in NEUTRAL for at least one
minute after every five rocking-motion cycles.This will minimize overheating and
reduce the risk of transmission failure during prolonged efforts to free a stuck
vehicle.
• When “rocking” a stuck vehicle by moving between DRIVE/1st and REVERSE, do not
spin the wheels faster than 15 mph (24 km/h), or drivetrain damage may result.
• Revving the engine or spinning the wheels too fast may lead to transmission
overheating and failure. It can also damage the tires. Do not spin the wheels above
30 mph (48 km/h) while in gear (no transmission shifting occurring).
WHAT TO DO IN EMERGENCIES
58

ENGINE COMPARTMENT1.4L Engine
MAINTAINING YOUR VEHICLE
61

FLUIDS AND CAPACITIES
ComponentFluid, Lubricant, or Genuine Part Capacities
Engine Coolant 1.4L with
Manual Transmission MOPAR®Antifreeze/Engine
Coolant 10 Year/150,000 Mile
Formula OAT (Organic Additive
Technology) or equivalent meeting
the requirements of Chrysler
Material Standard MS-12106. 4.6 Quarts (4.4 Liters)
Engine Coolant 1.4L with
Automatic Transmission MOPAR
®Antifreeze/Engine
Coolant 10 Year/150,000 Mile
Formula OAT (Organic Additive
Technology) or equivalent meeting
the requirements of Chrysler
Material Standard MS-12106. 5.8 Quarts (5.5 Liters)
Engine Oil with Filter 1.4L API Certified SAE 5W-30 Engine Oil, meeting the requirements of
Chrysler material standard
MS-6395. 4 Quarts (4.0 Liters)
Engine Oil Filter MOPAR
®Engine Oil Filter or
equivalent. —
Fuel Selection 1.4L 87 Octane Acceptable – 91 Octane Recommended 10.5 Gallons (40 Liters)
(Approximate)
Manual Transmission MOPAR
®C635 DDCT/MTX
Transmission Fluid —
Automatic Transmission MOPAR
®AW-1 Transmission Fluid —
Brake Master Cylinder MOPAR®DOT 3, SAE J1703 should
be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is
acceptable. Use only recommended
brake fluids or equivalent. —
Spark Plugs DCPR7E-N-10 Gap 0.040 in (1.02 mm) —
Convertible Top Rails Berulub FR 43 —
MAINTAINING YOUR VEHICLE
62

MAINTENANCE CHART
Miles:
8,000 16,000 24,000 32,000 40,000 48,000 56,000 64,000 72,000 80,000 88,000 96,000 104,000
OrMonths:6 121824303642 48 54 60 66 72 78
Or Kilometers:
13,000 26,000 39,000 52,000 65,000 78,000 91,000 104,000 117,000 130,000 143,000 156,000 169,000
Change the engine oil and filter. X(*) X(*) X(*) X(*) X X XXXXXXX
Rotate the tires, rotate at the first sign of irregular wear, even if it
occurs before scheduled maintenance. X(*)X(*)X(*)X(*)XXXXXXXXX
If using your vehicle for any of the following: dusty or off-road condi-
tions. Inspect the engine air cleaner filter; replace if necessary. X(*)
X X
Inspect the brake linings; replace if necessary. X(*) X(*) XXXX
Inspect the CV joints. X(*) X(*) XXXX
Inspect the exhaust system. X(*) X(*) XXXX
Inspect the front suspension, tie rod ends and boot seals for cracks
or leaks and all parts for damage, wear, improper looseness or end
play; replace if necessary. X(*) X(*) X
XXX
Replace the engine air cleaner filter. X(*)X X
Replace cabin filter. X(*) X(*) XXXX
Clean and lube sun roof tracks. X(*) X(*) XXXX
Check and adjust hand brake. X(*)X X
Replace the spark plugs X(*)X X
Inspect and replace PCV valve if necessary. X
Flush and replace the engine coolant at 60 months or 104,000 miles
(169,000 km) whichever comes first. X
Flush and replace the engine coolant at 104,000 miles (169,000 km)
or 60 months whichever comes first. X•
(*) The Maintenance Program covers the cost of normal service maintenance items, oil service and inspections above as well as specific normal wear
and tear items - brakes (rotors, pads, linings and drums), wiper blades, and clutch discs or modular clutch assembly (as equipped) - covered only for
3 years or 36,000 miles on the odometer. See your Warranty Information book, section 6 - Maintenance Program for full details.
• Refer to the Owner's Manual on the DVD for the complete maintenance schedule.
MAINTAINING YOUR VEHICLE
63

FUSES
Interior Fuses
•The interior fuse panel is part of the Body Control Module (BCM) and is located on the driver's
side under the instrument panel.
Cavity Vehicle Fuse
Number Mini Fuse
Description
1 F12 7.5 Amp Brown Right Low Beam
2 F32
5 Amp Tan Front and Rear Ceiling Lights Trunk
and Door Courtesy Lights
3 F53 5 Amp Tan Instrument Panel Node
4 F38 20 Amp Yellow Central Door Locking
5 F36
10 Amp Red Diagnostic Socket, Car Radio,
Climate Control System
6 F43 20 Amp Yellow Bi-Directional Washer
7 F48 20 Amp Yellow Passenger Power Window
8 F13 7.5 Amp Brown Left Low Beam, Headlamp Leveling
9 F50 7.5 Amp Brown Airbag
10 F51
5 Amp Tan Car Radio Switch, Climate Control
System, Stop Light, Clutch
11 F37
5 Amp Tan Stop Light Switch, Instrument Panel
Node
12 F49
5 Amp Tan Exterior Mirror, GPS, Electric Mirror,
Parking Sensor
13 F31 5 Amp Tan Ignition, Climate Control
14 F47 20 Amp Yellow Driver Power Window
Underhood Fuses
•A second fuse panel is located on the drivers side of the engine compartment, next to the
battery.To access the fuses, press the release tabs and remove the cover.
• The ID number of the electrical component corresponding to each fuse can be found on the
back of the cover.
Cavity Maxi Fuse Mini FuseDescription
F01 60 Amp Blue Body Controller
F02 20 Amp Yellow Audio Amplifier
F03 20 Amp Yellow Ignition Switch
F04 40 Amp Orange Anti-Lock Brake Pump
F05 70 Amp Tan Electric Power Steering
F06 20 Amp Yellow Radiator Fan - Single Speed
F06 30 Amp Green Radiator Fan - Low Speed
F07 40 Amp Orange Radiator Fan - High Speed
F08 30 Amp Green Blower Motor
F09 10 Amp RedPowertrain
F10 10 Amp RedHorn
MAINTAINING YOUR VEHICLE
65

FIAT CUSTOMER CENTER
P.O. Box 21–8004
Auburn Hills, MI 48321–8004
Phone: 1-888-242-6342
ASSISTANCE FOR THE HEARING IMPAIRED
•To assist customers who have hearing difficulties, the manufacturer has installed special TDD
(Telecommunication Devices for the Deaf ) equipment at its customer center.Any hearing or
speech impaired customer, who has access to a TDD or a conventional teletypewriter (TTY) in
the United States, can communicate with the manufacturer by dialing 1–800–380–CHRY.
Canadian residents with hearing difficulties that require assistance can use the special needs
relay service offered by Bell Canada. For TTY teletypewriter users, dial 711 and for Voice callers,
dial 1–800–855–0511 to connect with a Bell Relay Service operator.
WARNING!
Engine exhaust, some of its constituents, and certain vehicle components contain, or
emit, chemicals known to the State of California to cause cancer and birth defects, or
other reproductive harm. In addition, certain fluids contained in vehicles and certain
products of component wear contain, or emit, chemicals known to the State of
California to cause cancer and birth defects, or other reproductive harm.
PUBLICATIONS ORDERING
•If you are the first registered retail owner of your vehicle, you may obtain one free printed
copy of the Owner's Manual,Warranty Booklet or Radio Manuals on your DVD by calling
1–888–242–6342 (U.S.) or 1–800–387–1143 (Canada) or by contacting your dealer.
• Replacement User Guide kits or DVDs or, if you prefer, additional printed copies of the Owner's
Manual,Warranty Booklet or Radio Manuals may be purchased by visiting
www.techauthority.com or by calling 1–800–890–4038 (U.S.) or 1–800–387–1143 (Canada).
Visa, Master Card,American Express and Discover orders are accepted. If you prefer mailing
your order, please call the above numbers for an order form.
NOTE: A street address is required when ordering manuals (no P.O. Boxes).
CONSUMER ASSISTANCE
68

Air Conditioning..............20
Airbag ...................9
Airbag Light ................42
Anti-Lock Brake System (ABS) ......42
Arming Theft System (Security Alarm) . . . 8
Automatic Temperature Control (ATC) . . 21
Automatic Transmission Fluid Type ................62
Battery Charging System Light .........42
Jump Starting ..............53
Belts,Seat ..................9
BLUE&ME™ Hands-Free
Communication ..............29
Brake Fluid ................62
Brake System Warning Light ..............41
Bulb Replacement .............67
Changing A Flat Tire ............43
Charging System Light ...........42
Check Engine Light (Malfunction Indicator
Light) ...................42
Child Restraint ..............10
Child Restraint Tether Anchors ......10
ClimateControl ..............20
Clock Setting ...............29
Cooling System Coolant Capacity ............62
Cruise Control (Speed Control) .....18
Cruise Light ................18
Customer Assistance ...........68
Defects, Reporting .............69
Defroster,RearWindow..........20
Defroster,Windshield ...........20
Disarming,Theft System ..........8
Electronic Speed Control
(Cruise Control) .............18
Electronic Throttle Control Warning
Light ....................40
Electronic Vehicle Information Center
(EVIC)...................35
Electronics Your Vehicle's Sound System ......26Emergency, In Case of
Jacking .................43
Jump Starting ..............53
Towing .................56
Engine Compartment .............61
Fails to Start ..............25
Flooded, Starting ............25
Malfunction Indicator (Check Engine) . 42
Oil Selection ..............62
Overheating ..............42
Enhanced Accident Response Feature . . . 57
Exterior Lights ...............67
Flooded Engine Starting ..........25
Fluid Capacities ..............62
Fluids ...................62
Folding Rear Seat .............14
Freeing A Stuck Vehicle ..........58
FrontHeatedSeats ............15
Fuel Specifications ..............62
Gear Select Lever Override ........56
Hands-Free Communication -
BLUE&ME™ ...............29
Headlights High Beam ...............16
HeatedMirrors ............ 20,21
HeatedSeats ...............15
High Beam/Low Beam Select (Dimmer)
Switch ...................16
Hood Release ...............60
Instrument Cluster .............6
Indicators ................7
Ins

trument Cluster Warning Lights . . . 6,39
Intermittent Wipers (Delay Wipers) ....17
Introduction ................2
iPod
®Control ...............33
iPod®/USB/MP3Control .........34
Jack Location ...............43
JackOperation ............. 43,46
Jacking Instructions ............46
INDEX
71

Jump Starting...............53
KeyFob ...................8
Lane Change Assist ............16
LATCH (Lower Anchors and Tether for
CHildren) .................10
Lights Engine Temperature Warning ......39
Turn Signal ...............16
Warning (Instrument Cluster
Description) ...............6
Maintenance Record ...........64
Maintenance Schedule ...........63
Malfunction Indicator Light
(Check Engine) ..............42
Manual Transmission ............22
Mirrors Heated ............... 20,21
MOPAR
®Accessories ...........70
Oil Pressure Light .............42
Oil, Engine Capacity ................62
Outlet Power .................37
Overheating, Engine ............42
Placard,Tire and Loading Information . . . 66
Power Outlet (Auxiliary Electrical Outlet) . . . 37
Sunroof .................22
Preparation for Jacking ...........45
Programmable Electronic Features ....35
RearSeat,Folding .............14
RecreationalTowing ............38
Replacement Bulbs ............67
Restraints, Child ..............10
SeatBelts ..................9
Seats ...................12 Adjustment ...............12
Heated .................15
RearFolding ..............14 Setting the Clock
.............29
ShiftLeverOverride ...........56
Signals,Turn ................16
SparkPlugs ................62
Speed Control (Cruise Control) .....18
SportMode ................22
Starting ColdWeather .............25
Engine Fails to Start ...........25
Steering Tilt Column ...............14
Steering Wheel Audio Controls ......31
StoreRadioPresets ............29
Stuck, Freeing ...............58
SunRoof .................22
Supplemental Restraint System - Airbag . . 9
Theft Alarm (Security Alarm) ........8
TheftSystemArming ............8
Theft System Disarming ..........8
Tilt Steering Column ...........14
TIREFIT ..................49
Tires Air Pressure ..............66
Changing ................43
Jacking .................43
Pressure Warning Light .........40
Towing ..................38 24-Hour Towing Assistance .......39
Disabled Vehicle .............56
Recreational ..............38
Trailer Towing ...............38
Transmission Fluid ..................62
Turn Signals ................16
USBPort ................ 33,34
Washer Rear ..................18
Washers,Windshield ...........17
Wind Buffeting ..............24
Windshield Washers ............17
Windshield Wipers ............17
Wiper,Rear ................18
INDEX
72