2012 CHRYSLER 200 ECU

Refrigerant Recovery And Recycling
R-134a air conditioning refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealers or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, and Refrigerants.
A/C Air Filter – If Equipped
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Do not remove the A/C Air Filter while the blower is
operating or personal injury may result. The A/C Air Filter is located in the fresh air inlet behind
the glove box. Perform the following procedure to re-
place the filter:
1. Open the glove box and remove all contents.
2. Push in on the sides of the glove box and lower the
door.
3. Disconnect the glove box door dampener from the slot
on the side of the box. This is done by grasping the
dampener connector (on the outside of the box) and the
end of the connector pin (on the inside of the box) with
your thumb and forefinger and pulling outward while
lightly lifting upward on the door with your other hand.
Once disconnected, the dampener will retract under-
neath the instrument panel if you release it.
4. Pivot the glove box downward.
5. Disengage the two retaining tabs that secure the filter
cover to the HVAC housing and remove the cover.
422 MAINTAINING YOUR VEHICLE

WARNING! (Continued)
•To avoid contamination from foreign matter or
moisture, use only new brake fluid or fluid that
has been in a tightly closed container. Keep the
master cylinder reservoir cap secured at all times.
Brake fluid in a open container absorbs moisture
from the air resulting in a lower boiling point.
This may cause it to boil unexpectedly during hard
or prolonged braking, resulting in sudden brake
failure. This could result in a collision.
•Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts, causing
the brake fluid to catch fire. Brake fluid can also
damage painted and vinyl surfaces, care should be
taken to avoid its contact with these surfaces.(Continued)
WARNING! (Continued)
•Do not allow petroleum based fluid to contami-
nate the brake fluid. Brake seal components could
be damaged, causing partial or complete brake
failure. This could result in a collision.
Automatic Transmission
The automatic transmission and differential assembly are
contained within a single housing.
The fluid level in the automatic transmission should be
checked whenever the vehicle is serviced. Operation with
an improper fluid level will greatly reduce the life of the
transmission and the fluid.
7
MAINTAINING YOUR VEHICLE 435

3. Rotate bulb and connector one-quarter turn and pull
outward from assembly.
CAUTION!
Do not touch the new bulb with your fingers. Oil
contamination will severely shorten bulb life.4. Pull the bulb out of the socket and replace the bulb.
5. If the bulb comes in contact with any oily surface,
clean the bulb with rubbing alcohol.
6. Reinsert the bulb and socket assembly and rotate
clockwise one-quarter turn to secure.
7
MAINTAINING YOUR VEHICLE 451

NOTE:It is normal to hear a loud sound when the lower
tail lamp area unsnaps from the vehicle mounting
bracket during tail lamp removal. 4. Twist and remove socket from lamp.
5. Remove bulb from socket and replace.
6. Reinstall the tail lamp, fasteners, and trunk liner.
License Plate Lamp
1. Using a small screwdriver, press inward the locking
tab on the side of the lamp assembly and pull down on
the lamp assembly for removal.
2. Pull bulb from socket, replace, and reinstall the lamp
assembly into place ensuring the locking tab is secure.
454 MAINTAINING YOUR VEHICLE

About Your Brakes....................... 322
ABS (Anti-Lock Brake System) .............. 324
Adding Engine Coolant (Antifreeze) .......... 429
Adding Fuel ........................... 368
Adding Washer Fluid ..................... 425
Additives, Fuel ......................... 363
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 419
Air Conditioner Maintenance ............... 421
Air Conditioning ........................ 275
Air Conditioning Controls ................. 275
Air Conditioning Filter .................286,422
Air Conditioning Refrigerant .............421,422
Air Conditioning System .............275,279,421
Air Conditioning, Operating Tips ............ 287
Air Pressure, Tires ....................... 342
Airbag .............................. 58,67
Airbag Deployment ....................... 68
Airbag Light ................... 65,66,71,87,195
Airbag Maintenance ....................... 70 Airbag, Side
...................... 61,64,66,67
Airbag, Window (Side Curtain) ...........62,64,67
Alarm System (Security Alarm) ............18,202
Alterations/Modifications, Vehicle ............. 7
Antenna, Satellite Radio ................238,262
Anti-Lock Brake System (ABS) .............. 324
Anti-Lock Warning Light .................. 324
Anti-Theft Security Alarm (Theft Alarm) ........ 18
Antifreeze (Engine Coolant) ..............429,455
Disposal ........................... 431
Appearance Care ........................ 438
Ashtray ............................... 180
Assistance Towing ....................... 114
Auto Down Power Windows ................ 36
Auto Unlock, Doors ....................... 32
Auto Up Power Windows .................. 37
Automatic Dimming Mirror ................. 96
Automatic Door Locks ..................... 32
Automatic Oil Change Indicator ..........200,212
486 INDEX

Latches................................ 89
Hood ............................. 148
Lead Free Gasoline ...................... 360
Leaks, Fluid ............................ 89
Life of Tires ............................ 348
Light Bulbs .......................... 89,449
Lights .............................. 89,149
Airbag .................... 65,66,71,87,195
Back-Up ........................... 453
Brake Assist Warning .................. 331
Brake Warning ...................... 197
Bulb Replacement .................... 450
Daytime Running .................... 153
Electronic Stability Program (ESP) Indicator . . 331
Engine Temperature Warning ............ 196
Exterior ............................ 89
Fog ......................... 153,202,452
Headlight Switch ..................... 150
Headlights ......................... 150 Headlights On With Wipers
............. 159
High Beam Indicator .................. 207
Illuminated Entry ..................... 20
Instrument Cluster ................... 150
Interior ............................ 155
License ............................ 454
Lights On Reminder .................. 154
Low Fuel .......................... 195
Malfunction Indicator (Check Engine) ...... 205
Map Reading ....................... 155
Oil Pressure ........................ 196
Passing ............................ 153
Seat Belt Reminder ................... 195
Security Alarm (Theft Alarm) ............. 19
Theft Alarm (Security Alarm) ............ 202
Tire Pressure Monitoring (TPMS) .......204,352
Traction Control ..................... 331
Turn Signal .............. 89,152,202,452,453
Voltage ............................ 195
10
INDEX 495

PowerDeck Lid Release ..................... 38
Door Locks ......................... 32
Mirrors ............................ 98
Outlet (Auxiliary Electrical Outlet) ........ 176
Seats ............................. 136
Steering ........................ 320,321
Sunroof ........................... 173
Windows ........................... 35
Pregnant Women and Seat Belts .............. 57
Preparation for Jacking .................... 389
Pretensioners Seat Belts ........................... 52
Programmable Electronic Features ............ 219
Programming Transmitters
(Remote Keyless Entry) .................... 25
Radial Ply Tires ......................... 344
Radiator Cap (Coolant Pressure Cap) .......... 430Radio Operation
........................ 274
Radio Remote Controls .................... 272
Rear Cupholder ......................... 181
Rear Seat, Folding .................... 146,147
Rear Window Defroster ................... 186
Rear Window Features .................... 186
Rearview Mirrors ........................ 96
Recorder, Event Data ...................... 71
Recreational Towing ...................... 383
Reformulated Gasoline .................... 361
Refrigerant ............................ 422
Reminder, Seat Belt ....................... 56
Remote Control Door Locks ......................... 21
Security Alarm ....................... 18
Remote Keyless Entry (RKE) ................. 21
Remote Keyless Entry (Sedan) ............... 21
Remote Sound System (Radio) Controls ........ 272
Remote Starting System .................... 27
498 INDEX

Heated............................ 137
Lumbar Support ..................... 141
Power ............................ 136
Rear Folding ..................... 146,147
Reclining .......................... 140
Security Alarm (Theft Alarm) ................ 18
Selection of Coolant (Antifreeze) ..........429,456
Selection of Oil ......................... 416
Sentry Key (Immobilizer) ................... 15
Sentry Key Programming ................... 17
Service Assistance ....................... 477
Service Contract ......................... 479
Service Manuals ........................ 481
Setting the Clock ................ 221,224,242,251
Settings, Personal ........................ 219
Shift Lever Override ...................... 403
Short Message Service (SMS) ................ 122
Shoulder Belts ........................... 44
Side Airbag ............................. 66 Side Window Demisters (Defrosters)
.......... 286
Signals, Turn ......................... 89,453
Slippery Surfaces, Driving On ............... 316
Snow Chains (Tire Chains) ................. 350
Snow Tires ............................ 351
Spare Tire ....................... 345,346,388
Specifications Oil ............................... 416
Speed Control (Cruise Control) ...........161,201
Speedometer ........................... 194
Starting ............................... 294
Engine Fails to Start .................. 295
Starting and Operating .................... 294
Starting Procedures ...................... 294
Steering Power .......................... 320,321
Tilt Column ........................ 160
Wheel, Tilt ......................... 160
Steering Wheel Audio Controls .............. 272
500 INDEX