2012 Abarth Punto maintenance schedule

191
KNOWING
YOUR VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
F0U174Abfig. 170
IMPORTANT Brake fluid absorbs moisture. For this
reason, if the vehicle is mainly used in areas with a high
degree of atmospheric humidity, the fluid should be
replaced at more frequent intervals than specified in the
“Scheduled servicing plan”.
BRAKE FLUID fig. 170
Undo the cap A and check that the liquid contained in
the reservoir is at the maximum level.
Fluid level in the reservoir must not exceed the MAX
mark.
Use the brake fluid shown in the “Fluids and lubricants”
table (see “Technical Specifications”).
Note Carefully clean the cap of the reservoir A and the
surrounding surface.
Take great care that impurities do not enter the
reservoir when the cap is opened.
For topping up always use a funnel with integrated filter
that has a mesh inferior or equal to 0.12 mm.
Prevent brake fluid which is highly
corrosive from coming into contact with
painted parts. Should this occur,
immediately wash with water.
Brake fluid is poisonous and highly
corrosive. In the event of accidental
contact, immediately wash the affected parts
with water and neutral soap. Then rinse
thoroughly. If swallowed call a doctor
immediately.
WARNING
183-204 PUNTO Abarth GB 1ed 8-02-2012 13:25 Pagina 191

193
KNOWING
YOUR VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
BATTERY
The car is fitted with a low-maintenance battery: no
top-ups with distilled water are needed in standard
conditions of use.
INSPECTING THE CHARGE AND THE
ELECTROLYTE LEVEL
The operations must be carried out as described in this
Owner Handbook only by skilled personnel. Any top-up
operations must be carried out by skilled personnel and
by an Abarth Dealership.
Battery liquid is poisonous and corrosive.
Avoid contact with the skin and eyes.
Keep naked flames or possible sources of sparks
away from the battery: risk of explosion or fire.
WARNING
Using the battery when the fluid is too
low can damage it irreparably and
generate a risk of explosion.
WARNING
CHANGING THE BATTERY
If required, replace the battery with a genuine spare part
with the same specifications.
If a battery with different specifications is fitted, the
service intervals given in the “Scheduled Servicing
Programme” in this chapter will no longer be valid.
Follow the battery manufacturer’s instructions for
maintenance.
Incorrect installation of electric and
electronic devices may cause severe
damage to your car. Contact an Abarth
Ford Dealership if you want to install accessories
(alarms, mobile phone, etc.): they will suggest the
most suitable devices and advise you if a higher
capacity battery needs to be installed.
183-204 PUNTO Abarth GB 1ed 8-02-2012 13:25 Pagina 193

197
RUBBER HOSES
As far as the brake system and fuel rubber hoses are
concerned, follow the “Scheduled Servicing Programme”
in this chapter carefully.
Ozone, high temperatures and prolonged lack of fluid in
the system may cause hardening and cracking of the
hoses, with possible leaks.
Careful inspections are therefore necessary.
KNOWING
YOUR VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
WINDSCREEN WIPER
BLADES
Periodically clean the rubber part using special products;
TUTELA PROFESSIONAL SC 35 is recommended.
Replace the blades if the rubber edge is deformed or
worn. In any case, it is advisable to replace them
approximately once a year.
A few simple precautions can reduce the possibility of
damage to the blades:
❒make sure that the rubber part is not stuck to the
windscreen at sub-zero temperatures. Use a de-icing
product to release it if required;
❒remove any snow from the glass: in addition to
protecting the blades, this prevents effort from the
motor and overheating;
❒do not operate the windscreen wipers on dry glass.
Driving with worn wiper blades is a
serious hazard, because visibility is
reduced in bad weather.
WARNING
183-204 PUNTO Abarth GB 1ed 8-02-2012 13:25 Pagina 197

217
KNOWING
YOUR VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
SAE 5W-40 grade totally synthetic lubricant.SELENIA
ABARTH 5W-40
Approval Abarth 0102According to
Scheduled Servicing
Programme
FLUIDS AND LUBRICANTS
SPECIFICATIONS AND PRESCRIBED PRODUCTS
UseQuality Specifications of fluids and lubricants Genuine fluids Replacement
intervalfor correct car operation and lubricants
Engine
lubricants
The use of lubricants with specifications inferior to ACEA C3 and SAE gr\
ade other than 5W-40 could cause damage
to the engine not covered by the warranty.
205-220 GPUNTO EVO Abarth GB 2ed 8-11-2010 14:44 Pagina 217

264
KNOWING
YOUR VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS AND MESSAGES
IN AN
EMERGENCY
MAINTENANCE AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
Radio transmitters and mobilephones (important notes) ........ 106
Raising th e car ............................... 178
Rear fog lig hts ................................ 59
– bulb replace ment .................... 166
Rear light clusters – bulb replace ment .................... 165
Rear seats ....................................... 32
– cleaning ..................................... 203
– headrests .................................. 33
Rear window washer – activating ................................... 53
– checking levels
and topping up ............................ 190
– nozzles ...................................... 199
Rear window wiper – blade replacement .................. 198
– nozzles ...................................... 199
– operation .................................. 53
Reconfigurable multifunction displa y ........................................... 16
– control buttons ....................... 17
– display funct ions ...................... 20
– setup menu .............................. 18
– standard s creen ....................... 16
Refuelling – fuel ............................................. 107 – technical specifications
(fluid quantity an
d type) ............ 216
Regular checks .............................. 186
Remote cont rol ............................ 6
– additional remote controls .... 8
– battery replacement ............... 7
– remote door opening/
closing ............................................ 6
– tailgate op ening ....................... 6
Rev coun ter ................................... 14
Reverse lights – bulb replace ment .................... 166
Reverse lights – bulb replace ment .................... 166
Right hand drive version ............. 257
Roof bar atta chments................... 83
Roof rack/ski ra ck (setup) .......... 83
Roof rack/ski rack bars (capabilit y) ..................................... 83
Rubber tubes (maintenance) ...... 197
Safety .............................................. 109
Saving fue l ....................................... 135
SBR system...................................... 111
Scheduled se rvicing plan ...... 184-185
Scrappage ....................................... 255Seat belt preten
sioners ............... 111
– load limiters ............................. 112
Seat belt s ......................................... 109
– carrying children safely
(child seats) ................................. 115
– general warnings ..................... 112
– load limiters ............................. 112
– maintenance ............................. 114
– pretensioners .......................... 111
– SBR system................................ 111
– using the seat belts ................. 109
Servicing and care ......................... 183
– checking fluid levels ................ 187
– heavy-duty use of the car ..... 186
– regular checks ......................... 186
– scheduled servicing ................ 183
– scheduled servicing
plan ........................................ 184-185
Side bags ......................................... 126
– front si de bags ......................... 127
– general info rmation ................ 129
– window bags ............................ 127
Snow cha ins ................................... 139
Socket ............................................. 67
Spark plugs (type) .......................... 207
Speedometer ................................. 14
Start&Stop ...................................... 99
259-266 PUNTO Abarth GB 1ed 24-02-2012 10:08 Pagina 264