2012 Abarth 500 engine

118
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
Engine compartment control unit
fig. 40 e 41
A second control unit is located on the
right side of the engine compartment, next
to the battery; to access it press device I,
release tabs Mand remove cover L.
The ID number of the electrical compo-
nent corresponding to each fuse can be
found on the back of the cover.
If you need to wash the en-
gine compartment, take care
not to directly hit the engine
compartment control unit
with the water jet.
fig. 40
fig. 41F0S113Ab
F0S114Ab

119
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
F12
F13
F31
F32
F36
F37
F38
F43
F47
F48
F49
F50
F51
F537.5
7.5
5
7.5
10
5
20
15
20
20
5
7.5
7.5
5
F08
F09
F10
F11
F14
F15
F16
F17
F18
F1830
15
15
10
15
20
7.5
10
7.5
7.5
FUSE TABLE
Fuse box on dashboard - fig. 39FUSE AMPERE
Supply of right low beam
Supply of left low beam and headlamp direction adjustment control unit
Engine compartment shunt control unit switch
Lights of front and rear ceiling lights, trunk and door courtesy lights
Diagnostic socket, car radio, climate control system, EOBD
Stop lights switch, instrument panel node
Door central locking
Windshield/Rear windshield washer pump
Driver side power window
Passenger side power window
Backlighting switches, electric mirrors
Air bag node
Car radio switch, convergence, climate control system, stop lights, clutch
Instrument panel node
Engine compartment control unit - fig. 41FUSE AMPERE
Climate control system fan
Spare
Buzzers
Engine control system (secondary loads)
Main headlights
Sunroof motor
+15 Engine control unit, relay coil T20
Engine control unit
Spare
Engine control unit, relay T09 coil

120
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
20
20
20
30
50
30
30
20
20
30
30
30
50
30 T02
T03
T05
T06
T07
T08
T09
T10
T14
T17
T19
T20
T30
T31F19
F20
F21
F22
F22
F23
F24
F30
F84
F85
F877.5
30
15
15
20
20
7.5
15
10
15
7.5
Engine compartment control unit - fig. 41FUSE AMPERE
Conditioner compressor
Heated rear window, mirror demisters
Fuel pump
Ignition coil
Engine control unit
Braking system (control unit, valves)
+15 Braking system, electrical driving, yaw sensor
Fog headlights
Spare
Front socket (with or without cigar lighter plug)
+15 for backing lights, T02, T05, T14 and T19 relay coils
Engine compartment control unit - fig. 41RELÉ AMPERE
Main headlights
Buzzers
Conditioner compressor
One-speed engine cooling fan - Low speed engine cooling fan
High-speed engine cooling fan
Climate control system fan
Engine control system (main relay)
Spare
Fog headlights
Fuel pump
Demisting
Spare
Spare
Front socket (with or without cigar lighter plug)

122
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE
CAR
IN AN
EMERGENCY
TOWING THE CAR
The tow ring provided with the car is
housed in the tool box under the boot
mat.
FASTENING THE TOW
RING fig. 42-43
Proceed as follows:
❒release the cap A(only present in the
rear section Fig. 43);
❒take the tow hook Bfrom its seat in
the tool support;
❒tighten the ring on the rear or front
threaded pin.
Before beginning the tow,
turn the ignition key to MAR
and then to STOP, without extract-
ing it If the key is extracted, the steer-
ing wheel lock will be automatically
activated, thus preventing steering
WARNING
Because of the vehicle con-
formation, it cannot be
loaded onto railway carriages and
transported.
WARNING
The power brakes and the
electrical power steering will
not work while the car is being towed.
More effort on the brake pedal and
steering wheel will therefore be re-
quired. Do not use wires for towing.
Do not jerk. Make sure not to dam-
age parts in contact with the car
while towing. Respect the specific
rules of the Highway Code when tow-
ing the car specifically in relation to
the towing device and the behaviour
to maintain on the road.
Do not start the engine while towing
the car.
WARNING
fig. 42

F0S115Abfig. 43

F0S116Ab

30 60 90 120 150 180
●●●●● ●
●●●●● ●
●●●●● ●
●●
●
●●●●● ●
●●●●● ●
●●
●●●●● ●
●●●
●●●●● ●
●●●●● ●
126
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Thousands of kilometres
Check rear disk brake pad conditions and wear
Replace the air filter cartridge
Top up fluids (engine coolant,
brakes, windscreen washer, battery, etc.)
Check the conditions of the distribution control toothed belt
Replace the distribution control toothed belt (*)
Replace the spark plugs (❍)
Check engine control system operation
(through diagnosis socket)
Check the mechanical gearbox oil level
Change engine oil and replace oil filter (or every 24 months)
Change brake fluid (or every 24 months)
Change the pollen filter (or anyway every year)
Check emissions at the exhaust
(*) Regardless of the km covered, the timing belt shall be replaced every 4 years for particularly demanding use (cold climates,
driving in the city, idling for a long time) or in any case every 5 years
If the car is mainly used for driving in the city, and in any case with an annual mileage of below 10,000 km, change
engine oil and filter every 12 months.
(❍) In order to ensure correct efficiency and avoid damaging the engine, it is necessary to:
- exclusively use certified spark plugs specific for the 1.4 TB BZ Abarth engines. All candles to be fitted must be
of the same type and same manufacturer (see recommendations reported in the “Engine” paragraph);
- strictly respect the candles’ Scheduled Maintenance Plan;
- it is recommended to apply to Abarth Dealership.

127
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
DEMANDING
USE OF THE CAR
Should prevailing use of the car be under
one of the following specially heavy con-
ditions:
❒dusty roads;
❒short distances (less than 7-8 km) re-
peated and with external tempera-
tures below zero;
❒frequently idling engines or long dis-
tance low speed driving or in case of
a long term inactivity;
❒in cities;
perform the following inspections more
frequently than shown on the Service
Schedule:
❒check front/rear disc brake pad con-
dition and wear;
❒check cleanness of bonnet and boot
locks and lever cleanness and lubrica-
tion;
❒visually inspect the conditions of: en-
gine, gearbox, transmission, pipes and
hoses (exhaust - fuel - brakes), rubber
parts (boots, sleeves, bushes, etc.);
❒inspect the battery charge and fluid
level (electrolyte) (refer to the para-
graph “Battery - Inspection of the bat-
tery charge and of the electrolyte lev-
el” in this chapter);
❒visual check on various drive belt con-
ditions;
❒check and if necessary replace the
pollen filter; in particular it shall be re-
placed if a decrease in the air flow in-
to the passenger comportment is de-
tected;
❒check air cleaner and replace, if re-
quired.
REGULAR
INSPECTIONS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions;
❒operation of lights (headlights, direc-
tion indicators, hazard lights, etc.);
❒operation of the windscreen wiper/
washer system, position and wear of
the windscreen and rear window
wiper blades;
Every 3,000 km check the following and
top-up, if required: engine oil level.
You are recommended to use PETRONAS
LUBRICANTSproducts, designed and
produced specifically for Abarth cars (see
table “Capacities” in section “Technical
specifications”).

128
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
CHECKING FLUID
LEVELS
A.Engine oil filler
B.Engine oil level dispstick
C.Engine coolant
D.Windscreen washer fluid
E.Brake fluid
F.Battery
fig. 1 Never smoke while working
in the engine compartment.
there might be flammable gases and
vapours, with fire hazards.
WARNING
When topping up, pay atten-
tion not to confuse the vari-
ous types of fluids: they are all
reciprocally incompatible and
may severely damage your car.
B
A
D
CE
F
F0S117Ab

129
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
YOUR CAR
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Engine oil consumption
The maximum engine oil consumption is
usually 400 grams every 1000 km.
When the car is new, the engine needs
to run in, therefore the engine oil con-
sumption can only be considered stabilised
after the first 5,000 ÷ 6,000 km.
IMPORTANT The oil consumption de-
pends on driving style and the conditions
under which the car is used.
IMPORTANT After adding or changing
the oil, let the engine turn over for a few
seconds and wait a few minutes after turn-
ing it off before you check the level. ENGINE OIL fig.1
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
The oil level shall be included between the
MIN and MAX marks on the dipstick B.
The range between the MIN and MAX
levels corresponds to approximately 1
litre of oil.
If the oil level is near or even under the
MIN line, add oil through the filler Ato
reach the MAX line.
Oil level shall never exceed the MAX line.
Proceed very carefully inside
the engine compartment
when the engine is hot: risk of burns.
Remember that the fan may start up
if the engine is hot: risk of injury. Pay
attention to scarves, ties and other
loose fitting garments: they might get
caught by moving components.
WARNING
Don’t add any oil having dif-
ferent characteristics from
those of the existing engine oil.
The exhausted engine oil and
the replaced oil filter contain
substances that may be dan-
gerous for the environment. It
is advisable to have oil and filters
changed by a Abarth Dealership where
they will be disposed of according to
the law.