2012.5 Peugeot RCZ gearbox

186

Table of fuses over the battery



Fuse N°



Rating


Functions



F1



-

Not used.


F2



5 A

Dual function brake switch.


F3



5 A

Battery charge unit.


F4



25 A

ABS/ESC electrovalves.


F5



-

Not used.


F6



15 A

Automatic gearbox. All work on the other types of fuses (midi-fuses and maxi-fuses)
must only be done by a PEUGEOT dealer or a qualifi ed workshop.

8/
PRACTICAL INFORMATION
TOWING A VEHICLE

TOWING EYE

This is stored in the boot under the fl oor.
For access to it:


)
open the boot,

)
raise the fl oor using the strap,

)
secure it in the vertical position beyond the stops, located on the
sides of the boot,

)
remove the towing eye from the storage box.



GENERAL RECOMMENDATIONS

Observe the legislation in force in your country.
Ensure that the weight of the towing vehicle is higher than that of
the towed vehicle.
The person at the wheel of the towed vehicle must have a valid
driving licence.
When towing a vehicle with all four wheels on the ground, always
use an approved towing bar; rope and straps are prohibited.
When towing a vehicle with the engine off, there is no longer any
power assistance for braking or steering.
In the following cases, you must always call on a professional
recovery service:


- vehicle broken down on a motorway or fast road,

- 4 wheel drive vehicle,

- when it is not possible to put the gearbox into neutral, unlock
the steering, or release the parking brake,

- towing with only two wheels on the ground,

- where there is no approved towing bar available...

188

TOWING YOUR VEHICLE



)
On the front bumper, unclip the cover by pressing at the bottom.

)
Screw the towing eye in fully.

)
Install the towing bar.

)
Place the gear lever in neutral (position N
on the automatic
gearbox).
Failure to observe this instruction could result in damage to certain
components (braking, transmission...) and the absence of braking
assistance the next time the engine is started.

)
Unlock the steering by turning the ignition key one notch and
release the parking brake.

)
Switch on the hazard warning lamps on both vehicles.

)
Move off gently and drive slowly and for a short distance only.



TOWING ANOTHER VEHICLE



)
On the rear bumper, unclip the cover by pressing at the bottom.

)
Screw the towing eye in fully.

)
Install the towing bar.

)
Switch on the hazard warning lamps on both vehicles.

)
Move off gently and drive slowly and for a short distance only.

9/
TECHNICAL DATA

Engines


1.6 litre THP
150 hp



1.6 litre THP 156 hp



1.6 litre THP
163 hp



1.6 litre THP
200 hp



Gearboxes

Automatic
(6-speed)
Manual
(6-speed)
Automatic
(6-speed)
Automatic
(6-speed)
Manual
(6-speed)

Model codes:

4J...


5FE-J



5FV-8



5FV-A



5FM-J



5FU-8


Cubic capacity (cc)
1 598
1 598
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
77 x 85.8
77 x 85.8
Max power: EU standard (kW) *
110
115
120
147
Max power engine speed (rpm)
6 050
6 000
6 000
5 500
Max torque: EU standard (Nm)
240
240
240
275
Max torque engine speed (rpm)
1 400
1 400
1 400
1 700
Fuel
Unleaded
Unleaded
Unleaded
Unleaded
Catalytic converter
Ye s
Yes
Yes
Yes

Oil capacities (in litres)

Engine (with fi lter replacement)
4.25
4.25
4.25
4.25
4.25
PETROL ENGINES AND GEARBOXES


*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).

196
*

The weight of the braked trailer can be increased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced by the same
amount; warning: towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.
Engines


1.6 litre THP
150
hp



1.6 litre THP 156 hp



1.6 litre THP
163 hp



1.6 litre THP
200 hp



Gearboxes


Automatic



Manual



Auto.



Automatic



Manual



Model codes: 4J...


5FE-J



5FV-8



5FV-A



5FM-J



5FU-8


- Unladen weight
1 297
1 275
1 297
1 297
1 297
- Kerb weight
1 372
1 350
1 372
1 372
1 372
- Payload
463
465
463
463
483
- Gross vehicle weight (GVW)
1 760
1 740
1 760
1 760
1 780
- Gross train weight (GVW)

on a 12% gradient

2 260
2 240
2 260
2 260
2 280
- Braked trailer (within GTW limit)
on a 10% or 12% gradient

500
500
500
500
500
- Braked trailer * (with load transfer within GTW limit)
650
650
650
650
650
- Unbraked trailer
500
500
500
500
500
- Recommended nose weight
65
65
65
65
65
The GTW and towed load values indicated apply up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for
every additional 1000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; when the ambient temperature is
higher than 37 °C, limit the towed weight.
PETROL WEIGHTS AND TOWED LOADS (IN KG)

9/
TECHNICAL DATA

Engine



2.0 litre HDi 163 hp



Gearbox

Manual
(6-speed)

Model codes:

4J...


RHH-8


Cubic capacity (cc)

1 997
Bore x stroke (mm)

85 x 88
Max power: EU standard (kW) *
120
Max power engine speed (rpm)
3 750
Max torque: EU standard (Nm)
340
Max torque engine speed (rpm)
2 000
Fuel

Diesel
Catalytic converter

Yes
Particle emission fi lter

Yes

OIL CAPACITIES (in litres)

Engine (with fi lter replacement)
-
DIESEL ENGINE AND GEARBOX


*
The maximum power quoted is the type approved value obtained on a test bed, under the conditions defi ned in European legislation
(directive 1999/99/CE).

198
*

The weight of the braked trailer can be increased, within the GTW limit, on condition that the GVW of the towing vehicle is reduced by the same
amount; warning: towing with a lightly loaded towing vehicle may have an adverse effect on its road holding.
Diesel engine



2.0 litre HDi 163 hp



Gearbox



Manual



Model codes: 4J...



RHH-8


- Unladen weight

1 370
- Kerb weight

1 445
- Payload

455
- Gross vehicle weight (GVW)
1 825
- Gross train weight (GTW)

on a 12% gradient

2 325
- Braked trailer (within GTW limit)
on a 10% or 12% gradient

500
- Braked trailer * (with load transfer within GTW limit)
650
- Unbraked trailer

500
- Recommended nose weight
65
The GTW and towed load values indicated apply up to a maximum altitude of 1000 metres; the towed load mentioned must be reduced by 10 % for
every additional 1000 metres.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; when the ambient temperature is
higher than 37 °C, limit the towed weight.

322
ALPHABETICAL INDEX
Date (setting) ......................... 45, 47, 49
Daytime running lamps ...... 93, 174, 175
Deactivating the passenger airbag ...115
Deadlocking ....................................... 53
Defrosting .......................................... 78
Dials and gauges ............................... 22
Diesel additive level ......................... 153
Dimensions ...................................... 199
Dipped beam ..................... 90, 174, 175
Dipstick ...................................... 33, 152
Directional lighting ..................... 97, 174
Direction
indicators .............. 102, 174, 176, 179
Doors ................................................. 61
Doors emergency control .................. 63
Door pockets ..................................... 82
Driving economically ......................... 20
Driving positions (storing) .................. 68D/
Filling with fuel ......................... 146, 147
Fitting a wheel ................................. 165
Fittings, boot ...................................... 88
Flashing indicators........................... 102
Front seats................................... 65, 66
Fuel............................................ 20, 147
Fuel consumption .............................. 20
Fuel fi ller fl ap ................................... 146
Fuel gauge......................................... 22
Fuel tank .......................................... 146
Fusebox, dashboard ........................ 182
Fuses ............................................... 180F/H/
G.P.S. ...................................... 216, 255
Gearbox, automatic ................. 132, 155
Gearbox, manual ............. 130, 131, 155
Gear lever, automatic gearbox ........ 132
Gear lever, manual gearbox ............ 130
Gear shift indicator .......................... 131
Glove box .......................................... 83
Guidance ................................. 216, 255
Guide-me-home........................... 94, 95
EBA (Emergency
braking assistance) ....................... 105
Eco-driving ........................................ 20
Economy mode................................ 170
Electric window controls .................... 59
Electronic brake force distribution
(EBFD) .......................................... 105
Electronic engine immobiliser .... 55, 127
Electronic stability control (ESC) ..... 106
E/
Emergency
braking system .............................. 105
Emergency call ................ 103, 202, 203
Emergency warning lamps .............. 102
Energy economy mode.................... 170
Engine, Diesel ......... 147, 150, 151, 197
Engine, petrol .................. 147, 149, 195
Engine compartment ............... 149, 150
Engine compartment
fusebox ......................................... 184
Engine oil level indicator ............ 33, 152
Engines.................................... 195, 197
Environment .......... 20, 55, 78, 135, 153
Equipment settings .......... 24, 42, 46, 48
ESC/ASR ......................................... 106E/
G/
Halogen headlamps......................... 173
Hands-free kit .................. 233, 272, 313
Hazard warning lamps ..................... 102
Headlamp adjustment........................ 96
Headlamps, directional .............. 97, 174
Headlamp wash ................................. 99
Headlamp wash reservoir ................ 153
Head rests, rear ................................. 73
Heated seats ..................................... 67
Heating .............................................. 76
Height and reach adjustment,
steering wheel ................................. 69
Hill start assist ................................. 129
Horn ................................................. 103
Identifi cation plates .......................... 200
Ignition ............................................. 127I/