2011 VOLVO XC60 headlight bulb

08 Maintenance and specifications
Replacing bulbs
08
308* Option/accessory, for more information, see Introduction.
Introduction
All bulb specifications are listed on page 314.
The following bulbs should only be replaced by
a trained and qualified Volvo service techni-
cian:
•Dome lighting, reading lights
•Glove compartment lighting
•Footwell lighting
•Turn signals in the door mirrors
•Approach lighting in the door mirrors
•Brake/fog/taillights
•Rear parking lights
•Active Bending Lights
•LED bulbs
NOTE
For information regarding any other bulbs
not mentioned in this section, please con-
tact your Volvo retailer or a trained and
authorized Volvo service technician.
WARNING
•Active Bending Lights* – due to the high
voltage used by these headlights, these
bulbs should only be replaced by a
trained and qualified Volvo service tech-
nician.
•Turn off the lights and remove the
remote key from the ignition before
changing any bulbs.
Headlight housing
WARNING
•The engine should not be running when
changing bulbs.
•If the engine has been running just prior
to replacing bulbs in the headlight hous-
ing, please keep in mind that compo-
nents in the engine compartment will be
hot.
The entire headlight housing must be lifted out
when replacing all front bulbs.
CAUTION
Never touch the glass of bulbs with your fin-
gers. Grease and oils from your fingers
vaporize in the heat and will leave a deposit
on the reflector, which will damage it.

08 Maintenance and specifications
Replacing bulbs
08

309
NOTE
•Always switch off the ignition before
starting to replace a bulb.
•The optional Active Bending Light bulbs
contain trace amounts of mercury.
These bulbs should always be disposed
of by a trained and qualified Volvo serv-
ice technician.
Removing the headlight housing1. Switch off the ignition by briefly pressing
the START/STOP ENGINE button and
remove the remote key from the ignition
slot
1.
2. (Upper illustration under "Headlight hous-
ing")
Withdraw the headlight housing's lock-
ing pins.
Pull the headlight housing straight out.
CAUTION
When disconnecting the connector, pull on
the connector itself and not on the wiring.
3. (Lower illustration under "Headlight hous-
ing")
Unplug the wiring connector by holding
down the clip with your thumb.
Pull out the connector with the other
hand.
4. Lift out the housing and place it on a soft
surface to avoid scratching the lens.
5. Replace the defective bulb(s).
Reinserting the headlight housing
When reinserting the housing, be sure that the
long locking pin (to the left in the illustration) is
securely in place in both of its retaining clamps.
1. Plug in the connector until it clicks into
place.2. Reinstall the headlight housing and locking
pins. Check that they are correctly
inserted. The headlight housing must be
properly inserted and secured in place
before the lighting is switched on or the
remote key is inserted into the ignition slot.
3. Check that the lights function properly.
The headlight wiring must be connected and
the housing must be securely in place before
the ignition is switched on.
Removing the cover to access the
bulbs
1Does not apply to vehicles with the optional keyless drive.

08 Maintenance and specifications
Replacing bulbs
08
310
NOTE
Before starting to replace a bulb, see
page 308.
1. Open the retaining clamps by pressing
them to the sides.
2. Pull the cover straight out.
Reinstall the cover in the reverse order.
Low beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 308).
2. Remove the cover over the bulbs (see
page 309).3. Unplug the connector from the bulb.
4. Remove the bulb by pressing the holder
downward.
5. Press the new bulb into the socket until it
snaps into place. It can only be secured in
one position.
6. Put the cover back into position and rein-
stall the headlight housing.
High beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 308).
2. Remove the cover over the bulbs (see
page 309).3. Remove the bulb by turning it counter-
clockwise and pulling it straight out.
4. Remove the connector from the bulb.
5. Press the new bulb into the socket and turn
it clockwise to put it in place. It can only be
secured in one position.
6. Reinsert the bulb holder into the headlight
housing.
7. Put the cover back into position and rein-
stall the headlight housing.
Extra high beam2
1. Remove the headlight housing from the
vehicle (see page 308).
2Models with optional Active Bending Lights only.

08 Maintenance and specifications
Replacing bulbs
08

311
2. Remove the cover over the bulbs (see
page 309).
3. Disconnect the wiring connector from the
bulb holder.
4. Remove the bulb holder from the headlight
housing by pulling it straight out.
5. Insert a new bulb in the holder until it snaps
in place. It can only be inserted in one way.
6. Press the bulb holder into position in the
headlight housing.
7. Reconnect the wiring connector to the bulb
holder.
8. Put the cover back into position and rein-
stall the headlight housing.
Turn signals
1. Remove the headlight housing from the
vehicle (see page 308).
2. Remove the bulb holder by turning it coun-
terclockwise and pulling it out of the head-
light housing.
3. Pull out the holder to access the bulb.
4. Remove the burned out bulb by pressing it
in slightly and turning it counterclockwise.
5. Press the new bulb into the holder and turn
it clockwise.
6. Reinsert the bulb holder into the headlight
housing and turn it clockwise.
7. Reinstall the headlight housing.
Side marker lights
NOTE
Before starting to replace a bulb, see
page 308.
1. Remove the headlight housing from the
vehicle (see page 308).
2. Remove the bulb holder by turning it coun-
terclockwise and pulling it out of the head-
light housing.
3. Pull out the burned out bulb and install a
new one. It can only be inserted in one
position.
4. Reinsert the bulb holder into the headlight
housing and turn it clockwise.
5. Reinstall the headlight housing.

10 Index
10
351
Hill Descent Control............................ 121
warning light......................................... 78
Bulbs
cargo area lighting.............................. 313
headlights...........................308, 309, 310
introduction......................................... 308
license plate lights.............................. 313
side marker lights...............................311
specifications...................................... 314
taillight................................................ 312
C
Camera, Park Assist................................ 185
Capacity weight....................................... 280
Cargo area
changing bulbs................................... 313
steel grid............................................. 259
Cargo area cover..................................... 259
Cargo area net......................................... 260
Catalytic converter................................... 253
Cell phone, hands-free connection......... 229
Cell phone voice control.......................... 237
Central locking system, introduction......... 56
Chains...................................................... 283Check engine light..................................... 76
Child restraints
recalls and registration......................... 48
Child restraint systems.............................. 39
booster cushions.................................. 45
convertible seats.................................. 43
infant seats........................................... 41
ISOFIX/LATCH anchors........................ 46
top tether anchors................................ 47
Child safety.......................................... 37, 38
booster cushions.................................. 45
child restraint systems.......................... 39
convertible seats.................................. 43
infant seats........................................... 41
Child safety locks...................................... 52
City Safety™............................................ 162
Climate system........................................ 139
air distribution............................. 135, 141
air vents.............................................. 136
Interior Air Quality System.................. 135
introduction......................................... 134
passenger compartment filter............ 134
refrigerant........................................... 134
Clock, setting............................................. 80
Cold weather driving................................ 248
Collision warning system.................168, 169Compass in rearview mirror..................... 102
Conserving electrical current................... 247
Controls, center console.......................... 241
Convertible seats....................................... 43
Coolant............................................306, 343
Cooling system, general information....... 247
Courtesy lighting.................................. 92, 93
Crash mode............................................... 36
Cruise control..................................147, 148
adaptive.............................................. 149
Curb weight............................................. 280
Current, conserving................................. 247
D
Defroster.................................................. 139
Detachable key blade................................ 60
Dimensions.............................................. 338
Disconnecting the front passenger’s air-
bag....................................................... 26, 27
Dome lighting....................................... 92, 93
Door mirrors............................................. 100
Driver alert............................................... 175

10 Index
10
352
Driver distraction warning.......................... 13
Driving economically................................ 246
Driving in cold weather............................ 248
Driving through water..............................247
E
ECC.................................................139, 140
Economical driving.................................. 246
Electric parking brake.............................. 118
Electronic Climate Control.......137, 139, 140
air distribution table............................ 141
Interior Air Quality System.................. 140
Emergency locking retractor...................... 38
Emergency starting.................................. 110
Emergency towing...........................265, 266
Emission inspection readiness................ 301
Engine
overheating........................................... 79
specifications...................................... 340
starting................................................ 109
switching off....................................... 110
Engine compartment overview................303
Engine Drag Control (EDC)......................144Engine oil
checking............................................. 304
low pressure warning light.............. 77, 78
specifications...................................... 342
volumes.............................................. 343
Environment............................................... 12
Eyelets for anchoring loads..................... 257
F
Federal Clean Air Act............................... 300
Fluid specifications.................................. 343
Fog lights
front/rear............................................... 91
rear...................................................... 312
Four C (active chassis system)................146
Front airbags.............................................. 22
disconnecting passenger’s side air-
bag.................................................. 26, 27
Front park assist.............................. 181, 183
Front seats...........................................82, 84
Fuel filler cap........................................... 253
Fuel filler door, opening........................... 252
Fuel level warning light.............................. 77Fuel requirements............................ 250, 251
Fuel tank volume.....................................343
Fuses............................... 320, 321, 324, 327
G
Gasoline requirements............................. 251
Gas tank volume...................................... 343
Gauges...................................................... 75
Geartronic................................................ 113
Geartronic automatic transmission.. 112, 113
Generator warning light............................. 78
Glossary of tire terminology..................... 279
Grocery bag holder.................................. 257
Gross vehicle weight...............................280
H
Hazard warning flashers............................ 91
HD digital radio........................................ 212
Headlights
Active Bending Lights........................... 90
changing bulbs...........................309, 310

10 Index
10
357
Trip odometers.......................................... 80
Trips, long distance................................. 248
Turn signals............................................... 92
changing bulbs................................... 311
indicator lights...................................... 77
Two-stage booster cushion....................... 49
U
Uniform Tire Quality Grading...................282
Unlocking the tailgate................................ 67
Unlocking the vehicle..........................58, 66
Upholstery care....................................... 330
V
Vanity mirror............................................ 195
changing bulbs................................... 313
Vehicle dimensions.................................. 338
Vehicle Event Data..................................... 11
Vehicle loading................................255, 280
roof loads............................................ 258Vehicle maintenance................................ 300
performed by the owner.....................301
Vehicle weights........................................ 339
Voice control
cell phones......................................... 237
Volvo and the environment........................ 12
Volvo maintenance.................................. 300
Volvo On Call Roadside Assistance........ 348
Volvo programs.......................................348
W
Warning flashers, hazard........................... 91
Warning lights.......................... 75, 76, 77, 78
Warning symbol......................................... 79
Warning system, collision................168, 169
Warranties................................................ 300
Washer fluid..................................... 316, 343
Washers
headlight............................................... 96
windshield............................................. 95
Water, driving through............................. 247
Waxing..................................................... 329Weights.................................................... 339
Wheels.....................................................270
changing............................................. 291
storing................................................. 271
Whiplash Protection System..................... 33
Windows
power.................................................... 98
Windshield
IR coating............................................. 97
rain sensor............................................ 95
washers................................................ 96
wipers/washers..................................... 95
Windshield washer fluid................... 316, 343
Windshield wipers.................................... 315
Wiper blades
replacing tailgate wiper...................... 316
replacing windshield wipers............... 315