2011 VOLVO V60 power steering fluid

08 Maintenance and service
Engine compartment
08
306
General
Volvo service programmeTo keep the car as safe and reliable as possi-
ble, follow the Volvo service programme as
specified in the Service and Warranty Booklet.
Volvo recommends engaging an authorised
Volvo workshop to perform the service and
maintenance work. Volvo workshops have the
personnel, special tools and service literature
to guarantee the highest quality of service.
IMPORTANT
For the Volvo warranty to apply, check and
follow the instructions in the Service and
Warranty Booklet.
Check regularlyCheck the following oils and fluids at regular
intervals, e.g. when refuelling:
•Coolant
•Engine oil
•Power steering fluid
•Washer fluid
WARNING
Bear in mind that the radiator fan may start
automatically some time after the engine
has been switched off.
Always have the engine cleaned by a work-
shop. There is a risk of fire if the engine is
hot.
Raising the car
NOTE
Volvo recommends only using the jack that
belongs to the car model in question. If a
jack is selected other than the one recom-
mended by Volvo, follow the instructions for
use supplied with the equipment
If the car is raised with a workshop jack; posi-
tion the jack against the front edge on the
engine's subframe.
Do not damage the splashguard under the
engine. Ensure that the workshop jack is posi-
tioned so that the car cannot slide off the jack.
Always use axle stands or similar.
If you raise the car using a two-pillar workshop
lift, ensure that the front and rear lift arms are
fixed under the lifting points. See preceding
illustration.
Opening and closing the bonnet
The handle for bonnet opening is always on the
left-hand side.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08

307
Turn the handle about 20-25 degrees
clockwise. You will hear when the catch
releases.
Move the catch to the left and open the
bonnet. (The catch hook is located
between the headlamp and grille, see illus-
tration.)
WARNING
Check that the bonnet locks properly when
closed.
Engine compartment, overview
The appearance of the engine compartment may
vary depending on engine variant.
Coolant expansion tank
Power steering fluid reservoir
Engine oil dipstick1
Radiator
Filler opening for engine oil
Brake and clutch fluid reservoir (left-hand
drive)
Battery
Relay and fuse box, engine compartment
Filling washer fluid
Air filter
WARNING
High voltage from the ignition system. The
voltage in the ignition system is highly dan-
gerous. The remote control key must always
be in 0 position when work is being done in
the engine compartment, see page 81.
Do not touch the spark plugs or ignition coil
when the remote control key is in II position
or when the engine is hot.
Checking the engine oil
Volvo recommends Castrol oil products.
1Engines with electronic oil level sensor have no dipstick (5-cyl. diesel).
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
312
2. Unscrew the reservoir cap and fill the fluid.
The level must be between the MIN and
MAX marks, which are located on the
inside of the reservoir.
IMPORTANT
Do not forget to refit the cap.
Power steering fluid
IMPORTANT
Keep the area around the power steering
fluid reservoir clean when checking. The
cover must not be opened.
Check the level frequently. The fluid does not
require changing. The fluid level must bebetween the MIN and MAX marks. For capaci-
ties and recommended fluid grade, see
page 352.
NOTE
If a fault should arise in the power steering
system or if the engine is switched off and
the car must be towed, it can still be steered.
ProCarManuals.com

09 Specifications
Fluids and lubricants 09
352
Other fluids and lubricants
Manual gearboxVolume (litres)Prescribed transmission fluid
MMT61.7BOT 350M3M661.9
Automatic gearboxVolume (litres)Prescribed transmission fluid
MPS67.3BOT 341
TF-80SC7.0AW1
FluidSystemVolume (litres)Prescribed grade
Coolant2.0T and T510.5
Coolant recommended by Volvo mixed with 50% waterA, see the packaging.T6, D3 and D58.9
T3 and T4, Manual9.2
T4, Automatic9.8
Brake fluidBrake system0.4DOT 4+
Power steering
fluidPower steering–WSS M2C204-A2 or equivalent product.
Washer fluidCars with headlamp wash-
ing5.4Use a washer antifreeze recommended by Volvo, mixed with water.
Cars without headlamp
washing4.0
ProCarManuals.com

10 Alphabetical Index
10
379
Emergency equipment
warning triangle.................................. 296
Emergency puncture repair..................... 299
Emissions of carbon dioxide................... 272
Engine
overheating......................................... 278
starting................................................ 113
Engine block heater
fuel-driven........................................... 158
Engine compartment
coolant................................................ 310
oil........................................................ 307
overview.............................................. 307
power steering fluid............................ 312
Engine drag control ................................164
Engine oil.........................................307, 350
adverse driving conditions.................. 350
capacities........................................... 350
filter..................................................... 307
oil grade.............................................. 350
Engine specifications............................... 349
Environmental labelling, FSC, owner's
manual.......................................................13Error messages
Driver Alert Control............................. 196
Lane Departure Warning..................... 199
see Messages and symbols............... 179
Error messages in BLIS........................... 209
Error messages in Distance Alert............ 182
Error messages in the Adaptive cruise con-
trol............................................................ 179
ETC, electronic temperature control ....... 152
Expectant mothers, seatbelt...................... 19
External dimensions................................346
F
Fan........................................................... 153
Fault tracing for the camera sensor. 186, 192
First aid equipment.................................. 296
First aid kit .............................................. 296
Fluids, capacities..................................... 352
Fluids and oils.......................................... 352
Fog lamps
rear........................................................ 91
Foot brake............................................... 129
FOUR-C – Active chassis........................166FSC, environmental labelling..................... 13
Fuel.......................................................... 270
fuel consumption................................ 354
fuel economy...................................... 295
fuel filter.............................................. 271
Fuse box.................................................. 325
glovebox............................................. 330
Fuses.......................................................325
box in cargo area................................ 333
changing............................................. 325
cold zone............................................ 334
general................................................ 325
relay/fuse box in engine compart-
ment.................................................... 326
Start/Stop........................................... 334
Fuse table
fuses in engine compartment............. 327
G
Gearbox...................................................116
automatic............................................ 116
manual................................................ 116
Gear selector inhibitor.............................118
Gear selector inhibitor, mechanical disen-
gagement................................................. 119
ProCarManuals.com