2011 VOLVO V60 headlamp

08 Maintenance and service
Wiper blades and washer fluid
08
320
NOTE
The wiper blades are different lengths. The
blade on the driver's side is longer than the
blade on the passenger side.
CleaningFor cleaning wiper blades and windscreen, see
page 336 and onwards.
IMPORTANT
Check the wiper blades regularly.
Neglected maintenance shortens the serv-
ice life of the wiper blades.
Filling washer fluid
The windscreen and headlamp washers share
a common reservoir.
IMPORTANT
Add washer antifreeze during the winter so
that the fluid does not freeze in the pump,
reservoir and hoses.
For capacities, see page 352.
ProCarManuals.com

08 Maintenance and service
Fuses
08

* Option/accessory, for more information, see Introduction.327
General fuses, engine compartmentOn the inside of the cover there are tweezers
that facilitate the procedure for the removal
and fitting of fuses.
Positions (see preceding illustration)Engine compartment, upper
Engine compartment, front
Engine compartment, lower
These fuses are all located in the engine com-
partment box. The fuses in (C) are located
under (A).
•Fuses 1-7 and 42-44 are of the "Midi Fuse"
type and must only be replaced by a work-
shop
1.
•Fuses 8-15 and 34 are of the "JCASE" type
and should be replaced by a workshop1.
•Fuses 16-33 and 35-41 are of the "Mini
Fuse" type.
FunctionA
Primary fuse for the cen-
tral electronic module
(CEM) with fuse box B
under the glovebox
A
50
Primary fuse for the cen-
tral electronic module
(CEM) with fuse box B
under the glovebox50
Primary fuse for central
electrical unit in cargo
area
A
60
Primary fuse for central
electrical unit in passenger
compartment with fuse
box A under the glove-
box
A
60
Primary fuse for central
electrical unit in passenger
compartment with fuse
box A under the glove-
box
A
60
--
FunctionA
PTC element air pre-
heater*A100
Headlamp washers*20
Windscreen wipers30
Parking heater*25
Ventilation fanA40
--
ABS pump40
ABS valves20
--
Headlamp levelling*
(Xenon, Active Xenon)10
Primary fuse for the cen-
tral electronic module
(CEM) with fuse box B
under the glovebox20
ABS5
1An authorised Volvo workshop is recommended.
ProCarManuals.com

08 Maintenance and service
Fuses
08
328* Option/accessory, for more information, see Introduction.
FunctionA
Speed related power
steering*5
Engine control module,
Transmission control
module, Airbags10
Heated washer nozzles*10
Relay coil, relay, vacuum
pump (5-cyl. petrol and
2.0T)5
Headlamp control5
--
--
--
Internal relay coils5
Auxiliary lamps*20
Horn15
FunctionA
Relay coil, main relay,
engine management sys-
tem
Engine control module (5,
6-cyl. petrol)10
Transmission control
module15
Compressor A/C15
Relay coil, relay, compres-
sor A/C
Relay coils in central elec-
trical unit in engine com-
partment cold zone Start/
Stop5
Actuator solenoid, starter
motorA30
Ignition coils (4-cyl. pet-
rol), Glow control module
(diesel)10
Ignition coils (5, 6-cyl. pet-
rol)20
FunctionA
Engine control module
(petrol)10
Engine control module
(diesel)15
Valves (1.6 l petrol)
Mass air flow sensor
(DRIVe), Control valve, fuel
flow (DRIVe)10
Mass air flow sensor (5-
cyl. diesel), Control valves
(5-cyl. diesel), Injectors (5,
6-cyl. petrol), Engine con-
trol module (6-cyl.)15
Engine valves, Engine
control module (6-cyl.)
Solenoids, cam profile (6-
cyl.) Actuator motors,
intake manifold (6-cyl.)
Mass air flow sensor (4-
cyl. 2.0 l petrol)
Coolant pump (DRIVe)10
ProCarManuals.com

08 Maintenance and service
Car care
08
336
Washing the car
Wash the car as soon as it becomes dirty.
Wash the car in a car wash with oil separator.
Use car shampoo.
•Remove bird droppings from the paintwork
as soon as possible. Bird droppings con-
tain chemicals that affect and discolour
paintwork very quickly. An authorised
Volvo workshop is recommended for the
removal of any discoloration.
•Hose down the underbody.
•Rinse the entire car to remove loose dirt.
Do not spray directly onto the locks.
•Wash using a sponge, car shampoo and
plenty of lukewarm water.
•Clean the wiper blades with a lukewarm
soap solution or car shampoo.
•Use cold degreasing agent on very dirty
surfaces.
•Dry the car using a clean, soft chamois or
a water scraper.
WARNING
Always have the engine cleaned by a work-
shop. There is a risk of fire if the engine is
hot.
IMPORTANT
Dirty headlamps have impaired functional-
ity. Clean them regularly, when refuelling for
example.
NOTE
Outside lighting such as headlamps, fog
lamps and rear lamps may temporarily have
condensation on the inside of the lens. This
is normal, all exterior lighting is designed to
withstand this. Condensation is normally
vented out of the lamp housing when the
lamp has been switched on for a time.
Cleaning the wiper bladesAsphalt, dust and salt residue on wiper blades,
as well as insects, ice etc. on the windscreen,
impair the service life of wiper blades.
For cleaning:

Set the wiper blades in service position,
see page 319.
NOTE
Wash the wiper blades and windscreen reg-
ularly with lukewarm soap solution or car
shampoo.
Do not use any strong solvents.
Automatic car washesAn automatic car wash is a simple and quick
way of washing the car, but it cannot reach
everywhere. Handwashing the car is recom-
mended for achieving optimum results.
NOTE
During the first few months a new car must
only be handwashed. This is because the
paintwork is more sensitive when it is new.
High-pressure washingWhen using high-pressure washing, use
sweeping movements and make sure that the
nozzle does not come closer than 30 cm to the
surface of the car (the distance applies to all
exterior parts). Do not spray directly onto the
locks.
Testing the brakes
WARNING
Always test the brakes after washing the
car, including the parking brake, to ensure
that moisture and corrosion do not attack
the brake linings and reduce braking per-
formance.
Lightly depress the brake pedal now and then
when driving long distances in rain or slush.
The heat from the friction causes the brake lin-
ProCarManuals.com

09 Specifications
Fluids and lubricants 09
352
Other fluids and lubricants
Manual gearboxVolume (litres)Prescribed transmission fluid
MMT61.7BOT 350M3M661.9
Automatic gearboxVolume (litres)Prescribed transmission fluid
MPS67.3BOT 341
TF-80SC7.0AW1
FluidSystemVolume (litres)Prescribed grade
Coolant2.0T and T510.5
Coolant recommended by Volvo mixed with 50% waterA, see the packaging.T6, D3 and D58.9
T3 and T4, Manual9.2
T4, Automatic9.8
Brake fluidBrake system0.4DOT 4+
Power steering
fluidPower steering–WSS M2C204-A2 or equivalent product.
Washer fluidCars with headlamp wash-
ing5.4Use a washer antifreeze recommended by Volvo, mixed with water.
Cars without headlamp
washing4.0
ProCarManuals.com

10 Alphabetical Index
10
376
A
ACC – Adaptive cruise control................. 171
Active Bending Lights (ABL)...................... 90
Active chassis – FOUR-C........................166
Active Xenon headlamps........................... 90
Adapting driving characteristics.............. 166
Adaptive cruise control............................ 171
fault tracing......................................... 178
radar sensor........................................ 177
Adaptive cruise control fault tracing........ 178
Additional heater (Diesel)......................... 161
Adjusting headlamp pattern...................... 94
halogen headlamp................................ 95
Adjusting the steering wheel...................... 88
Airbag
activating/deactivating, PACOS........... 24
driver's and front passenger side......... 22
key switch off........................................ 24
AIRBAG ..................................................... 22
Airbag system ........................................... 21
Air conditioning........................................ 155
general................................................ 148
Air conditioning, AC................................. 155Air distribution.................................. 150, 156
Air quality system IAQS .......................... 155
Air vents................................................... 150
Alarm.......................................................... 67
alarm indicator...................................... 67
alarm signals......................................... 67
arming................................................... 67
checking the alarm............................... 51
deactivating.......................................... 67
deactivating a triggered alarm.............. 67
reduced alarm level.............................. 68
temporary disarming of the alarm........ 68
testing the alarm system...................... 68
Alcolock................................................... 109
Allergy and asthma inducing sub-
stances.................................................... 149
All-wheel drive, AWD............................... 128
All Wheel Drive (AWD).............................. 128
Approach light, duration............................ 94
Audio
settings....................................... 222, 223
surround.....................................216, 223
audio system .......................................... 218Audio system........................................... 216
functions............................................. 222
overview.............................................. 218
Audio volume .......................................... 219
phone.................................................. 250
phone/media player............................ 250
ring signal, phone............................... 250
Auto
climate control settings...................... 154
Automatic car washes.............................336
Automatic gearbox.................................. 116
manual gear positions (Geartronic)..... 117
towing and recovery........................... 284
trailer................................................... 279
Automatic locking...................................... 62
Automatic relocking................................... 61
Auxiliary heater........................................ 161
AUX input......................................... 218, 236
AWD, All-wheel drive............................... 128
B
Backrest..................................................... 83
front seat, lowering............................... 83
Backrest rear seat, lowering...................... 86
ProCarManuals.com

10 Alphabetical Index
10
378
Clean Zone Interior Package (CZIP)........ 149
Climate control........................................ 148
general................................................ 148
sensors............................................... 148
Clock, setting............................................. 79
CO
2 emissions ........................................ 354
Collision..................................................... 32
Collision warning.............................188, 189
Collision warning system
radar sensor........................ 177, 184, 189
Collision Warning with Auto Brake*......... 188
Colour code, paint................................... 340
Combined instrument panel.................... 140
Comfort inside the passenger compart-
ment......................................................... 211
Compass................................................. 106
calibration........................................... 106
Condensation in headlamps.................... 336
controls
centre console ...........................219, 259
Controls
centre console.................................... 142
Cooling system........................................ 266
Corner Traction Control .......................... 164Crash, see Collision................................... 32
Cruise control.......................................... 167
CZIP (Clear Zone Interior Package)......... 149D
DAB Radio............................................... 229
Deadlocks.................................................. 64
deactivation.......................................... 64
temporary deactivation......................... 64
Defroster.................................................. 155
Diesel.......................................................271
Diesel particle filter..................................272
Dipstick, electronic.................................. 309
Direction indicators.................................... 92
Disengaging the gear selector inhibitor. . . 119
Display lighting.......................................... 89
Distance Alert.......................................... 181
Dolby Surround Pro Logic II.................... 216
Door mirrors............................................. 103
Driveable punctured tyres........................ 298
Driver Alert Control.................................. 195
Driver Alert System.................................. 195Driving...................................................... 266
cooling system.................................... 266
with the tailgate open.........................267
with trailer........................................... 278
Driving in water........................................ 266
Driving with a trailer
towball load........................................ 347
towing capacity..................................347
DSTC, see also Stability control system.. 164
DVD ......................................................... 232
E
ECC, electronic climate control...............151
Economical driving.................................. 266
ECO pressure.......................................... 295
Eco Start/Stop DRIVe.............................. 122
Electrical socket......................................213
cargo area........................................... 274
front seat............................................. 213
Electric parking brake.............................. 131
low battery voltage.............................131
releasing automatically....................... 132
releasing manually.............................. 132
ProCarManuals.com

10 Alphabetical Index
10
380
Geartronic................................................ 117
Glass
laminated/reinforced........................... 101
Global opening........................................ 149
Glovebox................................................. 212
locking.................................................. 62
Gross vehicle weight...............................347
H
Hazard warning flashers............................ 92
Headlamp levelling.................................... 89
Headlamp pattern, adjusting..................... 94
Headlamp pattern adjustment
Active Bending Lights .......................... 94
Headlamps............................................... 313
Head restraint
centre seat, rear.................................... 85
lowering.......................................... 85, 87
Heated washer nozzles.............................. 99
Heating.................................................... 154
rearview and door mirrors.................. 104
rear window........................................ 104
seats...................................................153Heat-reflecting windscreen...................... 101
High engine temperature......................... 278
High-pressure headlamp washing............. 99
HomeLink
Ÿ .............................................. 134
Home safe lighting..................................... 94
Hoot........................................................... 88
Horn........................................................... 88
I
IAQS – Interior Air Quality System........... 149
IC – Inflatable Curtain................................ 28
Ignition keys............................................... 81
Immobiliser................................................ 49
Indicator lamps, PCC................................ 51
Inflatable curtain........................................ 28
Information and warning symbols............. 76
Information button, PCC...................... 50, 51
Information displays.................................. 75
Infotainment system ...............................216
basic functions ..................................219
menus ................................................ 259
overview ............................................. 218source buttons ................................... 218
voice control....................................... 255
Inlaid mats............................................... 212
Instrument lighting, see Lighting................ 89
Instrument overview
left-hand drive....................................... 72
right-hand drive.................................... 74
Instruments and controls........................... 72
Interior lighting, see Lighting..................... 92
Interior rearview mirror............................. 104
automatic dimming............................. 105
Intermittent wiping..................................... 98
iPodŸ, connection................................... 236
K
Kerb weight.............................................. 347
Key............................................................. 48
Key blade................................................... 52
Keyless drive...................................... 57, 113
Keyless start (keyless drive)............... 57, 113
Keypad in the steering
wheel.................................88, 142, 167, 220
Key positions............................................. 81
ProCarManuals.com