2011 Seat Exeo ST oil filter

4
Service information
First service Your Official SEAT Service will place a cross on the service that your vehicle requires.
 LongLife Service
(PR no . QG1) Service dependent on time/
di
stance travelled (PR PR: QG0, QG2 or QG3)

Interval Service
A

ccording to flexible service interval display (after 2 years at the latest). Oil Change Service
Thi
s service is performed according to the service interval display (every year
or every 15 000 km/10 000 miles, whichever comes first)
Vehicle delivery documentation from the Official SEAT Service
Delivery inspection carried out:
Date:

Official SEAT Service stamp If diesel with a high sulphur content is used,
the f
uel filter and the oil
should be changed every 7500 km (5000 miles) ⇒ page 7. Your Official
SEAT Service will be able to tell you which countries have diesel with a high
sulphur content.
Before delivery, your vehicle was inspected according to factory guidelines.
This ensures that driving will be a pleasure from the very beginning.
The agent will provide you with the following information when the vehicle
is delivered: ●
Running-in
● Changing the brake fluid
● Service intervals, in particular information on what constitutes severe
oper
ating conditions ⇒ page 6 Note
● U
sing diesel fuel with a high sulphur content may significantly reduce
the useful life of the diesel particulate filter.
● If LongLife engine oil is not used, the service dependent on time/dis-
t

ance travelled then applies. In this case, an oil change service will have to
be carried out every 15 000 km (10 000 miles) or every year. Ð

6
SEAT maintenance programme
SEAT maintenance programme
Service intervals Gener al information To ensure that you have each service carried out on time and that none are
f

orgotten, there is a reminder sticker on the driver side door pillar and a re-
minder will also be shown via the service interval display on the instrument
panel.
The service intervals quoted are for vehicles used under normal operating
conditions.
However, if the vehicle is used in adverse conditions, it may require work
before the next established service interval or even between service inter-
vals.
Adverse conditions include:
● the use of fuel with a high sulphur content
● frequent short journeys
● leaving the engine idling for long periods of time (as occurs with taxis)
● driving on dusty roads or in dusty areas
● frequently using the vehicle for towing
● mainly driving in the city, in heavy traffic where it is necessary to contin-
uou
sly brake and start, and
● using the vehicle mainly in the winter This particularly affects:
●
the air filter
● the timing belt
● the engine oil and
● the diesel particulate filter
In some c
ountries diesel fuel has a high sulphur content; in these cases the
fuel filter and the oil should be changed every 7500 km (5000 miles)
⇒  page 7. Your Official SEAT Service will be able to tell you which coun-
tries have diesel with a high sulphur content.
The service advisor at your Official SEAT Service will advise you on the need
to carry out additional work on your vehicle, taking into account the usage
conditions of the vehicle.
A list of the work to be carried out at the SEAT services is given on the fol-
lowing pages. These services are valid at the time of printing and can be
subject to further modifications for technical reasons. Your Official SEAT
Service always has the latest available information and will be able to tell
you if your vehicle requires any other additional inspections established by
law.
The cost of the SEAT service may vary, depending on the vehicle type,
equipment fitted, additional work and statutory inspections. Your Official
SEAT Service will tell you how much the SEAT service will cost (labour and
parts). Ð

7
SEAT maintenance programme
Intervals Service
Service type
LongLife Service (PR no . QG1) Service dependent on time/
di
stance travelled (PR PR: QG0, QG2 or QG3)
Oil change service a)
See ⇒
 page 7, LongLife Service According to the service interval display
(ev ery year or
every 15 000 km/10 000 miles) b)c)
Interval service a) According to flexible service
int
erval display
(maximum after 2 years) b) Every 2 years or
ev
ery 30 000 km (20 000 miles) b)c)
Inspection service a)
First service after 3 years or at 60 000 km (40 000 miles) c)
, and then ev
ery 2 years/60 000 km (40 000 miles)
Changing the brake fluid First change after 3 years, then ev
ery 2 years (we recommend using only genuine SEAT brake fluid) a)
Under certain circumstances different services can be carried out at the same time (Oil Change and Interval Services in combination with the Inspection Service).
b) If diesel with a high sulphur content is used, the f
uel filter and the oil should be changed every 7500 km (5000 miles) . Your Official SEAT Service will be able to tell you which countries have
diesel with a high sulphur content.
c) Whichever comes first.
Please see the oil specifications given in the Instruction Manual.
In ⇒ p
age 8, General Service Programme you will find the work corre-
sponding to each service.
LongLife Service
Thanks to the technology used at SEAT, with the LongLife Service, an Inter-
val Service only has to be carried out when it is necessary.
The length of the service intervals is also determined by factors such as
conditions under which the vehicle is used and personal driving style.
If LongLife engine oil is not used, the service dependent on time/distance
travelled then applies. In this case, an oil change service will have to be
carried out every 15 000 km (10 000 miles) or every year. This also applies
if you reprogram the vehicle to the service dependent on time/distance trav-
elled Note
In addition to the Inspection and Interval Services, additional work should
be c
arried out according to the time/distance travelled ⇒ page 10.Ð

8
General Service Programme
General Service Programme
Oil change service Operations to be carried out on your vehicle
● Check the thickness of brake pads and the condition of front and rear
br
ake discs.
● Change the engine oil and replace the oil filter. 1)
● The date of the next service is entered on the service sticker which is at-
t

ached to the driver side door pillar
● The service interval display is reset Ð
Interval service Operations to be performed on your vehicle:
● Check the battery.
● Check the depth of the tyre tread (incl. the spare wheel), that tread wear
i

s even, check the age and pressure of the tyres. Where applicable, adjust
the tyre pressure monitor.
● Brake system inspected for leaks and damage.
● Check the brake fluid level and wear of pads. ●
Chec
k the thickness of brake pads and the condition of front and rear
brake discs.
●Check the correct operation of the front and rear lighting, the turn sig-
n

als, the hazard warning lights, the daytime driving lights, the static corner-
ing lights and the automatic dipped beam control (where applicable) and
the horn.
● Check if the windscreen is damaged.
● Check the coolant and anti-freeze liquid and top up as required.
● Inspect the engine and components of the engine compartment (from
abo
ve) for leaks and damage.
● Inspect the engine and components of the engine compartment, the
g

earbox, the transmission, the final drive (especially flanges) and the track
rod boots (from below) for leaks and damage.
● Change the engine oil and replace the oil filter 1)
.
● Power steering hydraulic system: Check the seal and the fluid level, and
if

it is part of the equipment, if required, top up with hydraulic oil (only Exeo
and Exeo ST)
● Check the expiry date of the puncture kit tyre sealant (where applicable)
and r
ecord; check whether the bottle is damaged and the level of the seal-
ant.
● Check the windscreen wipers and headlight washers (where applicable)
oper
ate correctly; check the blades, the rest position, the final position and
possible damage, and top up the washer fluid as required. £1)
If diesel with a high sulphur content is used, the fuel filter and the oil should be changed
ev

ery 7500 km (5000 miles). Your Technical Service will be able to tell you which countries
have diesel with a high sulphur content.

11
General Service Programme
Every 60 000 km (40 000 miles) ●
Change oil and oil filter for DSG ®
aut omatic gearboxes (only 6-speed
DSG ®
gearboxes).
● Change the automatic gearbox oil (only Exeo, Exeo ST and 09G gearbox
in hot
climates).
● Dust and pollen filter for the passenger compartment: Replace (only Al-
t

ea, Altea XL, Altea Freetrack, Leon and Alhambra).
● Spark plugs: Replace (except 1.8 and 2.0 TFSI engines up to 147 kW).
● Air filter: Clean casing and replace filter element (only engines codes
CDLA and CDLD and Die
sel engines in Exeo and Exeo ST).
● Fuel filter: Replace (only Exeo and Exeo ST, engine codes CAGA, CAGC,
CAHA).
● LPG evaporator: Check for traces of oil or other dirt (only engines with
L

GP) 1)
. Ð
Every 90 000 km (60 000 miles) ●
Air filter: Clean casing and replace filter element (except engines codes
CDLA and CDLD and Die
sel engines in Exeo and Exeo ST).
● Fuel filter: Replace (only Diesel engines which use fuel that complies
w

ith the EN 590 standard. In Exeo and Exeo ST, except engine codes CAGA,
CAGC, CAHA).
● Spark plugs: Replace (only 1.8 and 2.0 TFSI engines up to 147 kW). ●
LPG ev
aporator paper filter: Replace (only engines with LPG) 1)
. Ð
At 90 000 km (60 000 miles) the first time,
then ev
ery 30 000 km (20 000 miles) ●
Timing belt for camshaft: Check condition and replace if necessary (only
petr
ol engines, except 2.0 TFSI). Ð
Every 180 000 km (120 000 miles) ●
Timing belt for camshaft: Replace (only 2.0 TFSI engines in Exeo and Ex-
eo

ST). Ð
At 180 000 km (120 000 miles) the first time,
then ev
ery 30 000 km (20 000 miles) ●
Particulate filter: Check (TDI Common Rail engines). Ð
Every 210 000 km (130 000 miles) ●
Timing belt for camshaft: Replace (TDI Common Rail engines). £1)
LPG: Liquefied petroleum gas.

12
General Service Programme
● Camshaft timing belt tension roller: Replace (TDI Common Rail engines). Ð
Every 2 years ●
Dust and pollen filter for the passenger compartment: Replace.
● LPG installation filter: Replace (only engines with LPG) 1)
. Ð
Every 3 years ●
Haldex clutch: Change oil (four-wheel drive vehicles only). Ð
After 3 years the first time, then every 2
y
ears ●
Brake and clutch fluid: Replace.
● Check the gas system (LPG) (only LPG engines) 1)
. Ð
Every 4 years ●
Spark plugs: Replace (except 1.8 and 2.0 TFSI engines up to 147 kW). ●
Air fi
lter: Clean casing and replace filter element (only engines codes
CDLA and CDLD and Diesel engines in Exeo and Exeo ST).
● Replace AdBlue (Blue TDI engines with less than 15 000 km / 10 000
mi

les in 4 years). Ð
Every 6 years ●
Spark plugs: Replace (only 1.8 and 2.0 TFSI engines up to 147 kW).
● Air filter: Clean casing and replace filter element (except engines codes
CDLA and CDLD and Die
sel engines in Exeo and Exeo ST). Note
● W
e recommend that you visit a SEAT Authorised Service whenever you
require any work done on your vehicle.
● SEAT keeps its Authorised Services up-to-date on new product develop-
ments.
They have tools and highly specialised personnel who can guaran-
tee the safety and performance of your vehicle.
● Scrupulously following the General Programme for Inspection Services
at

the SEAT Authorised Services will ensure you maintain greater value for
your vehicle. Ð1)
LPG: Liquefied petroleum gas.

18
Records
Service receipts
YES NO
LongLife Service:  
Service dependent on time/distance travelled  
Oil change service  
With Inspection Service  
Interval Service
(inc ludes change of engine oil)  
With Inspection Service  
Inspection service  
(does not include change of engine oil)
Additional tasks YES NO YES NO
Dust and pollen filter  ATF
 
Air filter  HALDEX clutch (oil)
 
Fuel filter  Gas filter and hoses
 
Spark plugs  Liquid gas filter (paper
fi

lter)  
Brake fluid  Timing belt
 
DSG®: oil and filter  
Date


Km/Miles:

Invoice number

Repair recommendation:

Service carried out by:




Official SEAT Service stamp

Next service due:

Date:

Km/miles:

(whichever is first) Note
We recommend that you visit a SEAT Authorised Service whenever you re-
quir
e any work done on your vehicle. Scrupulous observation of the Serv-
ices (oil, interval, inspection) at a SEAT Authorised Service will increase the
value of your vehicle. Ð

19
Records
Service receipts
YES NO
LongLife Service:  
Service dependent on time/distance travelled  
Oil change service  
With Inspection Service  
Interval Service
(inc ludes change of engine oil)  
With Inspection Service  
Inspection service  
(does not include change of engine oil)
Additional tasks YES NO YES NO
Dust and pollen filter  ATF
 
Air filter  HALDEX clutch (oil)
 
Fuel filter  Gas filter and hoses
 
Spark plugs  Liquid gas filter (paper
fi

lter)  
Brake fluid  Timing belt
 
DSG®: oil and filter  
Date


Km/Miles:

Invoice number

Repair recommendation:

Service carried out by:




Official SEAT Service stamp

Next service due:

Date:

Km/miles:

(whichever is first) Note
We recommend that you visit a SEAT Authorised Service whenever you re-
quir
e any work done on your vehicle. Scrupulous observation of the Serv-
ices (oil, interval, inspection) at a SEAT Authorised Service will increase the
value of your vehicle. Ð