2011 RAM CHASSIS CAB power steering

CAUTION! (Continued)• Your vehicle has been built with improved fluids
that protect the performance and durability of
your vehicle and also allow extended maintenance
intervals. Do not use chemical flushes in these
components as the chemicals can damage your
engine, transmission, power steering or air condi-
tioning. Such damage is not covered by the New
Vehicle Limited Warranty. If a flush is needed
because of component malfunction, use only the
specified fluid for the flushing procedure.
Engine Oil
Checking Oil Level
To assure proper lubrication of your vehicle’s engine, the
engine oil must be maintained at the correct level. Check
the oil level at regular intervals, such as every fuel stop. The best time to check the engine oil level is about five
minutes after a fully warmed up engine is shut off.
Checking the oil while the vehicle is on level ground will
improve the accuracy of the oil level readings. Always
maintain the oil level within the SAFE zone on the
dipstick. Adding one quart of oil when the reading is at
the bottom of the SAFE zone will result in a reading at the
top of the safe zone on these engines.
CAUTION!Overfilling or underfilling the crankcase will cause
oil aeration or loss of oil pressure. This could damage
your engine.
Change Engine Oil
The oil change indicator system will remind you that it is
time to take your vehicle in for scheduled maintenance.
Refer to “Maintenance Schedule” for further information.382 MAINTAINING YOUR VEHICLE

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission
(Five-Speed 545RFE) MOPAR  ATF+4  Automatic Transmission Fluid or equivalent licensed
ATF+4  product.
Transfer Case MOPAR  ATF+4  Automatic Transmission Fluid or equivalent licensed
ATF+4  product.
Front and Rear Axle Fluid
(4500/5500) GL-5 SAE 75W-90 Synthetic (MS-9763) or equivalent.
Brake Master Cylinder MOPAR  DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPAR  Power Steering Fluid +4, MOPAR  ATF+4  Automatic Trans-
mission Fluid or equivalent licensed ATF+4  product.424 MAINTAINING YOUR VEHICLE

Once a Month
• Check tire pressure and look for unusual wear or
damage.
• Inspect the battery and clean and tighten the terminals
as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
• Check all lights and other electrical items for correct
operation. At Each Oil Change
• Change the engine oil filter.
• Inspect the brake hoses and lines.
• Lubricate outer tie rod ends.
CAUTION!Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S 428 MAINTENANCE SCHEDULES

104,000 Miles (173,000 km) or
78 Months Maintenance
Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
104,000 miles (173 000 km).
❏ Lube the front drive shaft fitting (4x4
only).
❏ Flush and replace the engine coolant if
not done at 60 months.
❏ Flush and replace power steering fluid.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer 112,000 Miles (186,000 km) or 84 Months Maintenance Service
Schedule ❏ Change the engine oil and engine oil filter.
❏ Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
112,000 miles (186 000 km).
❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter; replace if necessary.
❏ Lube the front drive shaft fitting (4x4 only).
❏ Inspect the brake linings, replace if necessary.
❏ Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
8 M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 437

Automatic Transmission
Adding Fluid ......................... 403
Fluid and Filter Changes ................. 404
Fluid Level Check ................... 402,403
Fluid Type ........................ 402,424
Shifting ............................. 268
Special Additives ...................... 404
Axle Fluid ....................... 400,401,424
Axle Lubrication (Axle Fluid) ............ 400,401
Battery ............................... 385
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 144
Belts, Seat ............................ 38,73
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 388
B-Pillar Location ........................ 300
Brake Fluid ......................... 398,424 Brake System ........................ 292,398
Anti-Lock (ABS) ....................... 292
Fluid Check .......................... 398
Master Cylinder ....................... 398
Parking ............................. 289
Warning Light ........................ 187
Brake/Transmission Interlock ............... 267
Bulb Replacement ....................... 416
Bulbs, Light .......................... 76,415
Cab Top Clearance Lights .................. 420
Calibration, Compass ..................... 204
Capacities, Antifreeze (Engine Coolant) ........ 422
Capacities, Fluid ........................ 422
Caps, Filler
Oil (Engine) .......................... 383
Power Steering ........................ 289
Radiator (Coolant Pressure) ............... 395
Car Washes ............................ 405
10 INDEX 455

Points to Remember .................... 396
Pressure Cap ......................... 395
Radiator Cap ......................... 395
Selection of Coolant (Antifreeze) ......... 393,423
Cruise Control (Speed Control) .............. 152
Cupholders ............................ 162
Customer Assistance ..................... 445
Data Recorder, Event ...................... 59
Daytime Running Lights ................... 145
Dealer Service .......................... 380
Defroster, Rear Window ................... 171
Defroster, Windshield ................ 74,250,255
Delay (Intermittent) Wipers ................. 147
Differential, Limited-Slip .................. 284
Dipsticks
Automatic Transmission ................. 403
Power Steering ........................ 289 Disposal
Antifreeze (Engine Coolant) ............... 396
Door Locks ............................. 29
Driving
Through Flowing, Rising,
or Shallow Standing Water ............... 285
Dual Rear Wheels ..................... 316,363
Electric Rear Window Defrost ............... 171
Electrical Power Outlets ................... 157
Electronic Range Select (ERS) ............... 268
Electronic Speed Control (Cruise Control) ...... 152
Electronic Vehicle Information Center (EVIC) .... 192
Electronically Shifted Transfer Case ........... 278
Emergency Brake ........................ 289
Emergency, In Case of
Freeing Vehicle When Stuck ............... 370
Hazard Warning Flasher ................. 356
Jump Starting ......................... 366
10 INDEX 457

Fluid Level Checks
Automatic Transmission ................. 403
Brake .............................. 398
Power Steering ........................ 289
Fluids, Lubricants and Genuine Parts .......... 423
Fog Lights ....................... 142,190,418
Four Wheel Drive ....................... 274
Four-Way Hazard Flasher .................. 356
Freeing A Stuck Vehicle ................... 370
Front Axle (Differential) ................... 400
Fuel ................................. 317
Adding ............................. 322
Diesel .............................. 423
Filler Cap (Gas Cap) .................... 323
Filter ............................... 423
Gauge .............................. 179
Light ............................... 186
Octane Rating ........................ 317
Requirements ......................... 317 Tank Capacity ........................ 422
Fuses ................................ 410
Gas Cap (Fuel Filler Cap) ............... 323,378
Gasoline (Fuel) ......................... 317
Gasoline, Reformulated ................... 318
Gauges
Coolant Temperature ................... 179
Fuel ............................... 179
Oil Pressure .......................... 182
Speedometer ......................... 180
Tachometer .......................... 179
Voltmeter ............................ 186
Gear Ranges ........................... 270
General Information .................. 18,25,118
Glass Cleaning .......................... 409
Grocery Bag Retainer ..................... 170
Gross Axle Weight Rating .................. 327
Gross Vehicle Weight Rating ................ 326
10 INDEX 459

Identification Logo ..................... 383
Materials Added to ..................... 384
Pressure Gauge ....................... 182
Recommendation ...................... 383
Synthetic ............................ 384
Viscosity ............................ 383
Onboard Diagnostic System .............. 378,379
Operating Precautions .................... 378
Operator Manual (Owner’s Manual) ............ 4
Outside Rearview Mirrors .................. 82
Overdrive ............................. 272
Overdrive OFF Switch .................... 272
Overhead Console ....................... 155
Overheating, Engine ...................... 180
Owner’s Manual (Operator Manual) ......... 4,449
Panic Alarm ............................ 24
Parking Brake .......................... 289
Passing Light ........................... 146 Pedals, Adjustable ....................... 149
Personal Settings ........................ 205
Pets .................................. 71
Pets, Transporting ........................ 71
Phone, Cellular .......................... 88
Phone, Hands-Free (Uconnect™) .............. 88
Placard, Tire and Loading Information ......... 300
Power
Door Locks ........................... 30
Mirrors .............................. 84
Outlet (Auxiliary Electrical Outlet) ....... 157,160
Seats ............................... 127
Sliding Rear Window ................... 172
Steering .......................... 288,289
Windows ............................. 34
Power Steering Fluid ..................... 424
Pregnant Women and Seat Belts .............. 49
Programmable Electronic Features ............ 205464 INDEX