2011 Peugeot Bipper spare wheel

8
Familiarisation

LOAD SPACE (LIGHT VAN)



1.
Stowing rings.

2.
Storage tray.

3.
Torch.

4.
Partition.

5.
Spare wheel.



108 It is advisable to immobilise the load by
fi xing it securely using the stowing rings 1
on the fl oor.

Limit the causes of excess
consumption

Spread loads throughout the vehicle; place
the heaviest items in the bottom of the boot,
as close as possible to the rear seats.
Limit the loads carried in the vehicle and
reduce wind resistance (roof bars, roof rack,
bicycle carrier, trailer...). Use a roof box in
preference.
Remove roof bars and roof racks after use.

At the end of winter, remove snow tyres and
refi t your summer tyres.



Observe the recommendations on
maintenance

Check the tyre pressures regularly, when
cold, referring to the label in the door
aperture, driver's side.
Carry out this check in particular:


- before a long journey,

- at each change of season,

- after a long period out of use.
Don't forget the spare wheel and the tyres on
any trailer or caravan.

Have your vehicle serviced regularly (engine
oil, oil fi lter, air fi lter...) and observe the
schedule of operations recommended by the
manufacturer.


When refuelling, do not continue after
the 3 rd cut-off of the nozzle to avoid any
overfl ow.

At the wheel of your new vehicle, it is only
after the fi rst 1 800 miles (3 000 kilometres)
that you will see the fuel consumption settle
down to a consistent average.

20

138
Changing a wheel
CHANGING A WHEEL

Parking the vehicle

As far as possible, park the vehicle on level,
stable and non-slippery ground.
Apply the parking brake, switch off the
ignition and engage first gear (on a hill).
It is imperative that you ensure that the
occupants get out of the vehicle and wait in
a safe location.
If possible, place a chock under the
wheel diagonally opposite the wheel to be
changed.


Tools

The tools required are stored in a tool kit
located behind the driver’s seat (Light van)
or behind the rear bench seat (Combi).


1.
Wheelbrace.

2.
Centring guide.

3.
Screwdriver.

4.
Jack with handle.

5.
Removable towing eye.
The jack and all of the tools are specific
to your vehicle. Do not use them for other
purposes.
Never go underneath the vehicle when it is
raised only by the jack; use an axle stand.


Taking out the spare wheel

The spare wheel retaining bolt is located on
the rear left part of the loading sill.


1.
Slacken the wheel retaining bolt using the
wheelbrace.

2.
Unscrew fully to unwind the winch cable.

3.
Take out the spare wheel using the
wheelbrace.

4.
Raise the cover A
.

5.
Remove the cable B
from its housing.

6.
Release the spare wheel and place it
near the wheel to be changed.

7
QUICK HEL
P
Changing a wheel

Removing a wheel




1.
Park the vehicle on level, stable and
non-slippery ground. Apply the parking
brake. Switch off the ignition and engage
first gear or reverse, depending on the
slope.

2.
Detach the wheel trim (large model)
using the wheelbrace 1
, pulling at the
valve passage hole.
Slide the screwdriver 3
into the notch on
the trim (small model) and use the tool as
a lever, pressing to unclip the trim.

3.
Slacken the wheel bolts using the
wheelbrace.
4.
Position the jack underneath the body,
in accordance with the illustration, at the
mark A
(on the sill) as close as possible
to the wheel to be changed.

5.
Extend the jack 4
until its base is in
contact with the ground. Ensure that the
centreline of the jack base is vertical in
relation to the location used.

6.
Raise the vehicle.

7.
Remove the bolts and detach the wheel.




Putting the wheel back in place



1.
Install the support on the wheel.

2.
Place the cable B
in position.

3.
Lower the cover A
.

4.
Position the wheel.

5.
Turn the wheelbrace clockwise to raise
the spare wheel completely.

14
0
Changing a wheel

Refitting a wheel


6.
Put the trim back in place, starting by
placing its notch facing the valve, and
press with the palm of your hand.

7.
Stow the tools and the wheel.

8.
Check the wheel inflation pressure
(see "Identification") and have the
balance checked. Refer to the "Identifi cation markings"
section of chapter 8 to locate the tyre label.
Have the tightening of the bolts and the
pressure of the spare wheel checked by a
PEUGEOT dealer or a qualified workshop
without delay.


1.
Put the wheel in place using the centring
guide 2
to assist you.

2.
Screw in the 3 bolts by hand and remove
the centring guide. Position the 4th bolt.

3.
Pre-tighten using the wheelbrace 1
.

4.
Fold the jack 4
and detach it.

5.
Tighten the wheel bolts using the
wheelbrace. Also, have the original wheel repaired
and refitted by a PEUGEOT dealer
or a qualified workshop as soon as
possible.

167
8
VISUAL SEARCH


Exterior



EXTERIOR (LIGHT VAN)

Right-hand side:
fuel fi ller cap, fuel tank ................... 156
fuel cut-off ...............................156-157
Load space .............................108-109
Rear doors ......................31, 33, 36-40
Opening/Closing to 180° ........... 37, 39
Rear lamps, direction indicators,
3rd brake lamp ......... 41-42, 146-147
Number plate lamps ...................... 146
Rear parking assistance .................. 72
Spare wheel, changing a wheel,
tools .....................................138-140
Towing, lifting ................................. 154
Towbar ................................... 131-132 Dimensions ................................58-59
Brakes, pads.......................... 162, 164
Hill start assist ................................. 54
Braking assistance ................. 114-115
Trajectory control .................... 115-117
Tyres, pressures ............................ 155 Accessories ............................133-134
Roof rack ....................................... 133
Key, remote control, battery ........31-33
Central locking ..................... 31, 37, 39
Opening/Closing front windows ....... 32
Confi dential card.............................. 34
Alarm ............................................... 35
Wiper blades.................................. 148
Door mirrors ..................................... 46
Side repeater ................................. 145
Front lamps, foglamps, direction
indicators ................. 41-42, 143-145
Headlamp beam height adjustment ... 42
Changing bulbs.......................143-147
Opening/Closing doors ...31, 33, 36-40
Opening the bonnet ....................... 159
Menu - autoclose ................. 37, 39, 70

Exterior



EXTERIOR (COMBI)

Accessories ............................133-134
Roof bars ....................................... 133
Key, remote control, battery ........31-33
Central locking ..................... 31, 37, 39
Opening/Closing front windows ....... 32
Confi dential card.............................. 34
Alarm ............................................... 35
Wiper blades.................................. 148
Door mirrors ..................................... 46
Side repeater ................................. 145
Front lamps, fog amps, direction
indicators ................. 41-42, 143-145
Headlamp beam height adjustment ... 42
Changing bulbs.......................143-147
Opening/Closing
doors ............................31, 33, 36-40
Child lock ......................................... 40
Rear windows .................................. 47
Opening the bonnet ....................... 159
Menu - autoclose ................. 37, 39, 70 Dimensions .................................60-63
Brakes, pads..........................162-164
Hill start assist ................................ 54
Braking assistance ................ 114-115
Trajectory control ................... 115-117
Tyres, pressures ................... 142, 155 Right-hand side:
fuel fi ller cap, fuel tank ................. 156
fuel cut-off .............................156-157
Rear fi ttings ...........................110-111
Rear doors ....................31, 33, 36-40
Opening/closing to 180° .......... 37, 39
Rear lamps, direction indicators,
3rd brake lamp ........41-42, 146-147
Number plate lamps .................... 146
Rear parking sensors .................... 72
Spare wheel, changing a wheel, tools,
temporary puncture
repair kit ..............138-140, 141-142
Towing, lifting ............................... 154
Towbar ..................................131-132