2011 Peugeot 508 gearbox

8
201
i
!
Practical information




Towing the vehicle
Procedure for having your vehicle towed or for towing another vehicle using a removable towing eye.


Towing your vehicle
Towing another vehicle






Access to the tools

The towing eye is installed in the boot under
the floor.
To gain access to it:


)
open the boot,

)
position the floor ver tically,

)
remove the towing eye.


)
On the front bumper, unclip the cover by
pressing at the bottom.

)
Screw the towing eye in fully.

)
Install the towing bar.

)
Switch on the hazard warning lamps on the
towed vehicle.

)
On the rear bumper, unclip the cover by
pressing at the bottom.

)
Screw the towing eye in fully.

)
Install the towing bar.

)
Switch on the hazard warning lamps on the
towed vehicle.

When towing with all four wheels on the
ground, always use a towing bar.
When towing with only two wheels on
the ground, always use professional
lifting equipment.
When towing with the engine off, there
is no longer any braking or steering
assistance.

)
Place the gear lever in neutral
(position N
on the electronic gear
control gearbox or automatic
gearbox).
Failure to obser ve this special
condition could result in damage
to cer tain braking components and
the absence of braking assistance
the next time the engine is started.

9
217
!
Checks






Manual gearbox

The gearbox does not require any
maintenance (no oil change).
Refer to the Maintenance and Warranty
Guide for the details of the level
checking interval for this component.







6-speed electronic gearbox
system
The gearbox does not require any
maintenance (no oil change).
Refer to the Maintenance and
Warranty Guide for details of the
checking interval for this component.







Automatic gearbox

The gearbox does not require any
maintenance (no oil change).

Refer to the Maintenance and
Warranty Guide for details of the
level checking inter val for this
component. Brake wear depends on the style
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It may be necessary to
have the condition of the brakes checked, even
between vehicle services.
Unless there is a leak in the system, a drop in
the brake fluid level indicates that the brake
pads are worn.
















Brake pads

For information on checking brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.


Brake disc wear

Manual parking brake

If a loss of effectiveness of this
system is noticed, the parking brake
must be checked, even between
two ser vices.
Checking this system must be done by a
PEUGEOT dealer or a qualified workshop.






















Electric parking brake

This system does not require any
routine servicing. However, in the
event of a problem, have the system
checked by a PEUGEOT dealer or a
qualified workshop.
For more information, see "Driving - Electric
parking brake - § Operating faults".
















Only use products recommended by
PEUGEOT or products of equivalent
quality and specification.
In order to optimise the operation
of units as impor tant as the braking
system, PEUGEOT selects and offers
very specific products.
To avoid damaging the electrical units,
the use of a high pressure washer
in the engine compar tment is strictly
prohibited
.

218
Technical data


ENGINES AND GEARBOXES



Petrol engines


1.6 litre VTi

120 hp



1.6 litre THP

15 6 hp



Gearboxes

Electronic gear control
(6 -speed)
Manual
(6 -speed)
Automatic
(6 -speed)

Model codes

8D5FH8/P - 8E5FH8/P
8D5FS8/P - 8E5FS8/P
8D5FV8 - 8E5FV8
8D5FNA - 8E5FNA
8 D5 F VA - 8 E5 F VA
Cubic capacity (cc)
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
Max power: EU standard (kW)
85
88
11 0
115
Max power engine speed (rpm)
6 000
6 000
Max torque: EU standard (Nm)
160
240
Max torque engine speed (rpm)
4 250
1 400
Fuel
Unleaded
Unleaded
Catalytic conver ter
yes
yes

OIL CAPACITIES (in litres)



Engine (with filter replacement)
4.25
4.25

10
219
Technical data


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


1.6 litre VTi

1
20 hp



1.6 litre THP

15 6 hp



Gearbox
es

Electronic gear control
(6 -speed)
Manual
(6 -speed)
Automatic
(6 -speed)

Model codes

8D5FH8/P - 8E5FH8/P
8D5FS8/P - 8E5FS8/P
8D5FV8 - 8E5FV8
8D5FNA - 8E5FNA
8D5FVA - 8E5FVA

Outline

Saloon
SW
Saloon
SW
Saloon
SW


- Unladen weight
1 390
1 410
1 400
1 420
1 410
1 430


- Kerb weight *

1 465
1 485
1 475
1 495
1 485
1 505


- Gross vehicle weight (GV W)
1 945
2 055
1 995
2 080
2 015
2 080


- Gross train weight (GTW)
on a 12 % gradient
3 245
3 355
3 495
3 580
3 515
3 580


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 400
1 300
1 600
1 500
1 600
1 500


- Braked trailer ** (with load transfer within the
GTW limit)
1 575
1 600
1 775
1 800
1 775
1 800


- Unbraked trailer
730
74 0
735
74 5
74 0
750


- Recommended nose weight
75
75

*
The kerb weight is equal to the unladen weight + driver (75 kg).

**
The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

220
Technical data

* The kerb weight is equal to the unladen weight + driver (75 kg).

** The weight of the braked trailer can be increased, within the GTW limit, if the GV W of the towing vehicle is reduced by an equal amount; warning,
towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

WEIGHTS AND TOWED LOADS (In kg)



Petrol engine


1.6 litre THP
160 hp



Gearbox

Manual
(6 -speed)

Model code


-

Outine

Saloon
SW


- Unladen weight
-
-


- Kerb weight *

-
-


- Gross vehicle weight (GV W)
-
-


- Gross train weight (GTW)
on a 12 % gradient
-
-


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
-
-


- Braked trailer ** (with load transfer within the
GTW limit)
-
-


- Unbraked trailer
-
-


- Recommended nose weight
-
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned must be reduced by 10 % for
each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the per formance of the vehicle to protect the engine; if the ambient temperature is above 37 °C,
limit the towed load.

10
221
Technical data


ENGINES AND GEARBOXES



Diesel engine


1.6 litre HDi

110 h p



Gearbox
es

Manual
(5 -speed)
Electronic gear control
(6 -speed)

Model codes

8D9HL0 - 8E9HL0
8D9HR8/PS - 8E9HR8/PS

Outline

Saloon
SW
Saloon
SW
Cubic capacity (cc)
1 560
1 560
Bore x stroke (mm)
75 x 88.3
75 x 88,3
Max power: EU standard (kW)
82
82
Max power engine speed (rpm)
3 600
3 600
Max torque: EU standard (Nm)
240
270
Max torque engine speed (rpm)
1 750
1 750
Fuel

Diesel
Catalytic conver ter

yes
Particle emission filter

yes

OIL CAPACITIES (in litres)



Engine (with filter replacement)
3.25

222
Technical data


ENGINES AND GEARBOXES



Diesel engines


2.0 litre HDi
14 0 hp



2.0 litre HDi
163 hp



2.0 litre HDi




Gearboxes

Manual
(6 -speed)
Automatic
(6 -speed)
-

Model codes

8DRHR8 - 8ERHR8
8DRHF8 - 8ERHF8
8DRHHA - 8ERHHA
8DRHDA - 8ERHDA
-

Outline

Saloon
SW
Saloon
SW
Saloon
SW
Cubic capacity (cc)
1 997
1 997
-
Bore x stroke (mm)
85 x 88
85 x 88
-
Max power: EU standard (kW)
10 0
103
10 0
120
-
Max power engine speed (rpm)
4 000

3 750
-
Max torque: EU standard (Nm)
320
340
-
Max torque engine speed (rpm)
2 000
2 000
-
Fuel

Diesel
Catalytic conver ter

yes
Particle emission filter
yes
no

OIL CAPACITIES (in litres)






Engine (with filter replacement)
5.25
5
-

10
223
Technical data


ENGINES AND GEARBOXES



Diesel
engine


2.2 litre HDi
204 hp



Gearbox

Automatic
(6 -speed)

Model codes


8D4HLA - 8E4HLA

Outline

Saloon
SW
Cubic capacity (cc)

2 179
Bore x stroke (mm)

85 x 96
Max power: EU standard (kW)
15 0
Max power engine speed (rpm)
3 500
Max torque: EU standard (Nm)
450
Max torque engine speed (rpm)
2 000
Fuel

Diesel
Catalytic conver ter

yes
Particle emissions filter

yes

OIL
CAPACITIES (in litres)



Engine (with filter replacement)
5.25