2011 LINCOLN NAVIGATOR rear

Miles (x 1,000)* 82.5 90 97.5 105 112.5 120 127.5 135 142.5 150
Kilometers (x 1,000)* 132 144 156 168 180 192 204 216 228 240
Months* 66 72 78 84 90 96 102 108 114 120
Change engine oil and filter• •••••••••
Rotate tires, inspect tire wear and measure tread depth.
Vehicles with dual rear wheels should only rotate if
unusual wear is observed.• •••••••••
Inspect wheels and related components for abnormal
noise, wear, looseness or drag• •••••••••
Perform multi-point inspection (recommended)• •••••••••
Inspect automatic transmission fluid level (if equipped
with dipstick); consult dealer for requirements.•••••
Inspect brake pads, shoes, rotors, drums, brake linings,
hoses and parking brake•••••
Inspect engine cooling system concentration and hoses•••••
Inspect exhaust system and heat shields•••••
Inspect front axle and U-joints; lubricate if equipped
with grease fittings (4WD vehicles)•••••
Inspect half-shaft boots (if equipped)•••••
Inspect steering linkage, ball joints, suspension, tie-rod
ends, driveshaft and U-joints; lubricate if equipped with
grease fittings•••••
Torque rear U-bolts (Transit Connect)•••••
Inspect cabin air filter (if equipped)•••••
* Whichever comes first
Scheduled Maintenance Guide
350
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Every 15,000 miles
(24,000 km)Replace cabin air filter (if equipped)
Every 30,000 miles
(48,000 km)Replace climate-controlled seat filter (if equipped)
Replace engine air filter
Replace fuel filter (Ranger)
Every 37,500 miles
(60,000 km)Inspect valve clearances; adjust as necessary
(Transit Connect CNG vehicles)
Every 60,000 miles
(96,000 km)Change automatic transmission fluid and filter on
5–speed TorqShifttransmission; consult dealer for
requirements.
Replace front wheel bearing grease/grease seal if
non-sealed bearings are used (2WD vehicles)
Every 105,000 miles
(168,000 km)Change engine coolant
1
Change manual transmission fluid (except Escape)
Change rear axle fluid (Dana axles)
Replace spark plugs
Inspect accessory drive belt(s)
2
Every 150,000 miles
(240,000 km)Change automatic transmission fluid and filter
(except 5–speed TorqShifttransmission) (filter
not required on 6F35, 6F50, DPS6 and AWF-21
transmissions); consult dealer for requirements.
Change front axle fluid (4WD vehicles)
Change manual transmission fluid (Escape)
Change rear axle fluid (RWD vehicles)
Change transfer case fluid (4WD vehicles)
Replace accessory drive belt(s) if not replaced
within the last 100,000 miles (160,000 km)
Replace front wheel bearings and seals if
non-sealed bearings are used (2WD vehicles)
1Initial replacement at 105,000 miles (160,000 km) or 72 months; every
45,000 miles (72,000 km) or 36 months thereafter
2Perform a follow-up inspection at 120,000 miles (192,000 km)
Scheduled Maintenance Guide
351
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently, service as
required– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km)– Inspect wheels and related components for abnormal
noise, wear, looseness or drag
– Rotate tires, inspect tires for wear and measure tread
depth
Every 5,000 miles (8,000 km) or
6 months– Change engine oil and filter
– Inspect and lubricate U-joints
Every 15,000 miles (24,000 km)– Replace fuel filter (Ranger)
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except 6R80 and
TorqShifttransmissions)
– Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 50,000 miles (80,000 km)– Change manual transmission fluid
– Change rear axle lubricant (E-450 and F-450/550
only)
Every 60,000 miles (96,000 km)– Change transfer case fluid (4WD vehicles)
Scheduled Maintenance Guide
357
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Off-road operation
Inspect frequently, service as
required– Inspect steering linkage, ball joints and U-joints;
lubricate if equipped with grease fittings
– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km) or
6 months– Change engine oil and filter
– Inspect wheels and related components for abnormal
noise, wear, looseness or drag
– Rotate tires, inspect tires for wear and measure tread
depth
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except 6R80 and
TorqShifttransmissions)
– Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 50,000 miles (80,000 km)– Change manual transmission fluid
– Change rear axle lubricant (E-450 and F-450/550
only)
Every 60,000 miles (96,000 km)– Change transfer case fluid (4WD vehicles)
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change– If ran exclusively on E85, fill the fuel tank full with
regular unleaded fuel.
Scheduled Maintenance Guide
358
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

EXCEPTIONS
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
Normal vehicle axle maintenance
❑Rear axles and power take-off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design
axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is re-
quired or the axle assembly has been submerged in water. The axle and PTO lubricant should be changed anytime the axle
and PTO have been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open
throttle for extended periods above 45 mph (72 km/h), non-synthetic rear axle lubricants should be replaced every
3,000 miles (4,800 km) or 3 months, whichever occurs first. The 3,000 mile (4,800 km) lubricant change interval may
be waived if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part
number F1TZ-19580-B or equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-
Lok rear axles (refer to
Maintenance product and specificationsin theMaintenance and Specificationschapter for details).
The axle lubricant should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑Replace rear axle lubricant every 100,000 miles (160,000 km). Rear axle lubricant change may be waived if the axle
was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or
equivalent. Add four ounces (118 mL) of additive friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of
Traction-Lok rear axles. The axle lubricant should be changed anytime the axle has been submerged in water.
E–450 and F–450/550 axle maintenance
❑Replace rear axle lubricant every 100,000 miles (160,000 km) under normal driving conditions on all E–450 and
F–450/550 applications. For E–450 and F–450/550 vehicles operated at or near maximum Gross Vehicle Weights, the
rear axle lubricant should be replaced every 50,000 miles (80,000 km). In addition, this 50,000 mile (80,000 km)
schedule should be observed when the vehicles are operated under the Special Operating Conditions.
California fuel filter replacement
❑If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this main-
tenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life.
Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified inter-
vals and to record all vehicle service.
Class A Motorhome
❑Every two years - Change brake fluid
Scheduled Maintenance Guide
361
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

A
ABS (see Brakes) .....................224
Accessory delay ..........................74
AdvanceTrac ..............................226
Air cleaner filter ...............325, 330
Air suspension ...........................232
description ..............................232
Airbag supplemental
restraint system ........152, 156, 158
and child safety seats ............154
description ..............152, 156, 158
disposal ....................................161
driver airbag ............154, 157, 159
indicator light .................156, 161
operation .................154, 157, 159
passenger airbag .....154, 157, 159
side airbag ...............................156
Antifreeze
(see Engine coolant) ................305
Anti-lock brake system
(see Brakes) ..............................224
Anti-theft system ..............114, 118
arming the system ..................118
disarming a triggered
system .....................................119
Audio system (see Radio) .........30
Automatic transmission
driving an automatic
overdrive .................................235
fluid, adding ............................325
fluid, checking ........................325
fluid, refill capacities ..............331
fluid, specification ..................331
Auxiliary input jack
(Line in) ......................................36
Auxiliary power point .................71Axle
lubricant specifications ..........331
refill capacities ........................331
B
Battery .......................................303
acid, treating emergencies .....303
jumping a disabled
battery .....................................274
maintenance-free ....................303
replacement, specifications ...330
servicing ..................................303
Belt-Minder.............................148
Booster seats .............................177
Brakes ........................................223
anti-lock ...................................224
anti-lock brake system
(ABS) warning light ...............224
fluid, checking and adding ....324
fluid, refill capacities ..............331
fluid, specifications .................331
lubricant specifications ..........331
parking ....................................225
shift interlock ..........................233
Bulbs ............................................60
C
Capacities for refilling fluids ....331
Car2UHome Automation
System .........................................84
Cargo cover .................................95
Cargo management system ........95
Cell phone use ..............................9
Changing a tire .........................264
Child safety seats ......................166
in front seat ............................167
in rear seat ..............................167
Index
364
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

J
Jack ............................................264
positioning ...............................264
storage .....................................264
Jump-starting your vehicle ......274
K
Keyless entry system
autolock ...................................103
keypad .....................................113
locking and unlocking
doors ........................................114
programming entry code .......113
Keys .....................................97, 116
positions of the ignition .........217
L
Lamps
autolamp system .......................55
bulb replacement
specifications chart ..................60
daytime running light ...............56
fog lamps ...................................55
headlamps .................................55
headlamps, flash to pass ..........56
interior lamps ...............58–59, 61
replacing bulbs .........................64
LATCH anchors .........................170
Liftgate ................................90, 109
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........224
Load limits .................................202
Loading instructions .................209
Locks
autolock ...................................103
childproof ................................107
doors ........................................103Lubricant specifications ...........331
Lug nuts ....................................272
Lumbar support, seats .............123
M
Message center ...........................20
english/metric button ...............25
system check button ................25
warning messages .....................26
Mirrors ...................................75–76
automatic dimming rearview
mirror ........................................75
fold away ...................................76
heated ........................................77
programmable memory ..........110
signal .........................................77
Moon roof ....................................83
Motorcraftparts ..............294, 330
MyKey ..........................................98
N
Navigation system .......................47
O
Octane rating ............................315
Oil (see Engine oil) ..................300
P
Parental MyKey
programming ...............................98
Parking brake ............................225
Parts
(see Motorcraftparts) ...........330
Pedals (see Power adjustable
foot pedals) .................................78
Index
367
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)

Power adjustable foot pedals .....78
Power deployable running
boards ..........................................78
Power distribution box
(see Fuses) .......................257, 260
Power door locks ......................103
Power liftgate ..............................90
Power mirrors .............................76
Power point .................................71
Power steering ..........................231
fluid, checking and adding ....324
fluid, refill capacity ................331
fluid, specifications .................331
Power Windows ...........................73
Preparing to drive your
vehicle ........................................233
R
Radio ............................................30
Rear heated seats .....................135
Rear-view camera system .........241
Recommendations for
attaching safety restraints for
children ......................................164
Relays ........................................256
Remote entry system .......107–108
illuminated entry ....................112
locking/unlocking
doors ................................108–109
opening the trunk ...................109
panic alarm .............................110
replacement/additional
transmitters .............................111
replacing the batteries ...........111
Reverse sensing system ...........238Roadside assistance ..................253
Roll stability control .................226
S
Safety Belt Maintenance ..........180
Safety belts
(see Safety restraints) ....138, 140,
142–143, 145
Safety Canopy ...................156, 158
Safety defects, reporting ..........286
Safety restraints ...............138, 140,
142–143, 145
Belt-Minder...........................148
extension assembly ................147
for adults .........................142–143
for children .............................162
safety belt maintenance .........180
warning light and chime ........147
Safety restraints - LATCH
anchors ......................................170
Safety seats for children ..........166
Safety Compliance
Certification Label ....................335
Satellite Radio Information ........44
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............348
What Maintenance Schedule
Should You Follow? ................346
Seats ..........................................120
child safety seats ....................166
cleaning ...................................293
climate control ........................127
heated ......................................135
memory seat ...................110, 125
Index
368
2011 Navigator(nav)
Owners Guide, 1st Printing
USA(fus)