2011 Lancia Musa brake fluid

173
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MANUTENZIONEE CURA
3
12
45
L0D0488mfig. 5 - 1.6 Multijet versions
1 Engine coolant - 2 Engine oil - 3 Brake fluid - 4 Battery - 5 Windscreen/rear
window washer/wiper
fig. 6 -1.4 8V versions
(for versions/markets, where provided)L0D0258m
ENGINE OIL fig. 6-7-8-9-10
Checking engine oil level
Check the oil level a few minutes
(about 5) after the engine has
stopped, with the car parked on level
ground.
The oil level shall be included be-
tween the MINandMAXmarks on
the dipstick . The range between the
MINandMAXlevels corresponds to
approximately 1 litre of oil.

176
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
BRAKE FLUID fig. 14
Release cap: check that the liquid
contained in the tank is at the maxi-
mum level.
Fluid level in the reservoir must not
exceed the MAXmark.
Use the brake fluid shown in the
“Fluids and lubricants” table (see
“Technical Specifications”).
NOTE Carefully clean the cap of
reservoir A and the surrounding sur-
face.
When opening the cap, make sure
that no dirt gets into the reservoir.
For topping up always use a funnel
with built-in filter (mesh smaller than
or equal to 0.12 mm).
IMPORTANT Brake fluid is hygro-
scopic (i.e. it absorbs moisture). For
this reason, if the car is mainly used
in areas with a high degree of atmos-
pheric humidity, the fluid should be
replaced at more frequent intervals
than specified in the “Service sched-
ule”.
fig. 14L0D0213m
Do not travel with the
windscreen washing reser-
voir empty: the action of the wind-
screen washer is essential for im-
proving visibility.
WARNING
Some commercial addi-
tives for windscreen wash-
ing are flammable. The engine
compartment contains hot parts
which could start a fire if they
come into contact.
WARNINGWINDSCREEN/REAR WINDOW
WASHER FLUID fig. 13
To add fluid, lift the cap Aand pour
in a mixture of water and TUTELA
PROFESSIONAL SC35fluid in the
following proportions:
❒30% of TUTELA PROFESSIONAL
SC35and 70% water in summer.
❒50% of TUTELA PROFESSIONAL
SC35and 50% water in summer.
UseTUTELA PROFESSIONAL SC35
neat at temperatures lower than 20°C.
Check level through the reservoir.
fig. 13L0D0212m

177
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
Prevent brake fluid which
is highly corrosive from
coming into contact with
painted parts. Should this
occur, immediately wash with wa-
ter.
Brake fluid is poisonous
and highly corrosive. In
the case of accidental contact, wash
the parts with water and mild soap
and rinse with plenty of water.
Call a doctor immediately if swal-
lowed.
WARNING
Symbolπon the contain
indicates a synthetic brake
fluid, which is different from a
mineral fluid. Use of a mineral
type fluid will damage the special
rubber seals of the braking system
beyond repair.
WARNING
FUEL FILTER
(green filter)
DRAINING CONDENSATION
(Multijet versions)
The presence of water in
the feeding circuit may
cause severe damage to the injec-
tion system and irregular engine
operation. If the warning lights c
on the cluster lights up or a mes-
sage appears on the reconfigurable
multifunctional display (some ver-
sions), contact a Lancia Dealership
to have the system bled. Water may
have been introduced in the tank if
this appears immediately after re-
fuelling: in this case, stop the en-
gine immediately and contact a
Lancia Dealership.
WARNING
CHECKING CHARGE
AND ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner’s Handbook
only by specialised personnel.
Topping must be carried out by spe-
cialised personnel at a Lancia Dealer-
ship.
Battery liquid is poisonous
and corrosive. Avoid con-
tact with the skin and eyes. Keep
naked flames and sources of
sparks away from the battery: risk
of explosion and fire.
WARNING
BATTERY
The battery is of the low maintenance
type and the electrolyte does not need
to be topped up with distilled water in
normal conditions of use.

180
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICA-
TIONS
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN
EMERGENZA
MAINTENANCE
AND CARE
❒a tyre will age even if it is not used
much. Cracks in the tread and on
the sidewalls are a sign of ageing.
Have the tyres checked by spe-
cialised personnel if they have been
fitted for longer than 6 years. Re-
member to check the spare wheel
very carefully;
❒In case of replacement, always fit
new tyres, avoiding those with an
unknown origin.
❒If a tyre is replaced, also change the
inflation valve.
❒to allow even wear between the
front and rear tyres, it is advisable
to change them over every 10-15
thousand kilometres, keeping them
on the same side of the car so as not
to reverse the direction of rotation.
Remember that the road
holding qualities of your
car also depends on the correct in-
flation pressure of the tyres.
WARNING
Excessively low pressure
will cause overheating of
the tyre and may cause severe tyre
damage.
WARNING
Do not exchange the tyres
from the left to the right of
the car and vice versa.
WARNING
Do not repaint alloy wheel
rims at temperatures
higher than 150°C. The mechani-
cal features of the wheels could be
compromised.
WARNING
RUBBER HOSES
Carefully follow the information con-
tained in the “Service schedule” in
this section for maintenance of brake
system and fuel feed rubber hoses.
Ozone, high temperatures and pro-
longed lack of fluid in the system may
cause hardening and cracking of the
hoses, with possible leaks. Careful in-
spections are therefore necessary.

TECHNICAL SPECIFICATIONS
IDENTIFICATION DATA .................................. 188
ENGINE CODES -
BODYWORK VERSIONS.................................. 190
ENGINE........................................................... 191
FUEL FEED .................................................... 192
TRANSMISSION .............................................. 192
BRAKES........................................................... 193
SUSPENSIONS ................................................. 193
STEERING SYSTEM ........................................ 193
WHEELS .......................................................... 194
DIMENSIONS ................................................... 198
PERFORMANCE.............................................. 199
WEIGHTS........................................................ 200
CAPACITIES .................................................... 201
FLUIDS AND LUBRICANTS ............................ 202
FUEL CONSUMPTION.................................... 204
CO
2EMISSIONS ............................................... 205
187
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS

1.6 Multijet 1.416V1.48V(▲)1.3 Multijet
CAPACITIES
Fuel tank:
including a reserve of:
Fuel tank: including a reserve of:
Engine cooling
system:
Engine sump:
Engine sump and filter:
Engine sump:
Engine sump and filter:
Gearbox/differential
casing:
Hydraulic brake circuit:
Windscreen/rear window
washer fluid reservoir:
(▲) Engine version for some versions/markets only
(❐) When the vehicle is used under particularly harsh climate conditions, we recommend using a mix of 60% PARAFLUUPand 40%
demineralised water.
kg
–
–
–
–
–
–
–
3.74
4.0
1.6
–
–Recommended fuels
Genuine products
Unleaded petrol with no less
than 95 R.O.N.
(EN 228 Specification)
Diesel fuel for motor vehicles
(EN590 specifications)
50% mixture of demineralized
water and PARAFLU
UP(❐)
SELENIA K P.E.
SELENIA WR P.E.
TUTELA CAR
TECHNYX
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC35 litres
47
5 - 7
–
–
4.5
2.4
2.6
–
–
1.65
0.45
1.5kg
–
–
–
–
–
2.1
2,25
–
–
1.5
–
–litres
47
5 - 7
–
–
4.5
2.5
2.7
–
–
1.65
0.45
1.5kg
–
–
–
–
–
2.2
2.35
–
–
1.5
–
–litres
–
–
47
5 - 7
6.0
–
–
2.85
3.0
1.98
0.45
1.5kg
–
–
–
–
–
–
–
2.54
2.65
1.8
–
–litres
–
–
47
5 - 7
7.8
–
–
4.4
4.7
–
0.45
1.5
201
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS

Use
(●)IMPORTANT Do not use fluids with different specifications for topping up or mixing.
(❐) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60% mixture of PARAFLUUPand
demineralised water.
Fluid and lubricant features
for correct car operation
All synthetic lubricant
SAE 75W-85 grade. Exceeding API GL-4 PLUS,
FIAT 9.55550 MIL-L- 2105 D LEV specifications.
Classification FIAT 9.55550-MX3
Molybdenum disulphide grease for high temperatures.
Consistency NLGI 1-2
Classification FIAT 9.55580
Polyeura base synthetic grease for high temperatures.
Consistency NLGI 2
Classification FIAT 9.55580
Specific grease for low-friction coefficient
CV joints. Consistency NLGI 0-1
Classification FIAT 9.55580
Synthetic fluid, F.M.V.S.S. n.116, DOT 4, ISO 4925,
SAE J-1704, CUNA NC 956-01
Classification FIAT 9.55597
Red protective with antifreeze action, based on inhibited
monoethylene glycol with organic formula based on
O.A.T, that passes CUNA NO 956-16, ASTM D 3306
specifications
Classification FIAT 9.55523
Additive for diesel fuel, protecting Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11
Classification FIAT 9.55522Genuine fluids and
lubricants
TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA ALL STAR
Contractual Technical
Reference N° F702.G07
TUTELA STAR 325
Contractual Technical
Reference N° F301.D03
TUTELA STAR 700
Contractual Technical
Reference N° F701.C07
TUTELA TOP 4
Contractual Technical
Reference N° F001.A93
PA R A F L U
UP(●)
Contractual Technical
Reference N° F101.M01
TUTELA DIESEL ARTContractual Technical
Reference N° F601.L06
TUTELA
PROFESSIONAL SC35
Contractual Technical
Reference N° F201.D02Applications
Gearbox and differentials
(mechanical)
CV joint
wheel side
CV joints on differential
side subject
to high temperatures
(1.4
16Vversions)
CV joints
differential side
Hydraulic
brake and clutch
Cooling circuit. Percentage
of use 50% to -35° C.
Do not mix with product
of different type
(❐)
To be mixed with fuel oil
(25 cc per 10 litres)
To be used diluted or
undiluted in wind-
screen/rear window wash-
er/wiper systems Motion transmission
lubricants and
grease
Brake liquid
Radiator
protection
Windscreen/
rear window
washer fluid
203
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS
Additive for
diesel fuel

212
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND
CONTROLS
SAFETY
STARTING
AND DRIVING
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICA-
TIONS
INDEX
ABS (System) ........................ 85
Accessories purchased by the
owner .................................. 88
Air vents ............................... 48
Ashtray (smoker's kit) .......... 75
Automatic dual-zone climate
system.................................. 52
Battery
. - checking battery charge and
liquid level (electrolyte) ..... 177
- jump starting ..................... 137
- replacement ...................... 178
Bodywork
- maintenance ..................... 182
- version codes .................... 190
Bonnet .................................. 82
Boot ...................................... 80
Boot extension ....................... 80
Brake fluid level .................... 176
Brake lights
- bulb replacement ............. 153Brakes
- fluid level ......................... 176
- handbrake ........................ 116
- technical data ................. 193
Bulb (replacement) ............... 147
Capacities ............................. 201
Car maintenance and care ..... 165
- scheduled maintenance plan 167
Car parked ............................ 116
Car radio
- setup ................................ 87
Carrying children safely ........ 101
Ceiling light ........................... 69
Changing a wheel .................. 142
Checking fluid levels ............. 171
Child lock ............................ 19
Cigar lighter (smoker's kit) .... 75
Clutch ................................... 192
CO
2emissions ....................... 205
Control buttons display .........22-25
Cruise Control ....................... 67Dashboard ........................... 8
Dashboard and controls ........ 7
Dimensions .......................... 198
Dipped beam headlights
- bulb replacement ............. 151
- controls ............................ 62
Direction indicators ............... 63
Direction indicators
- bulb replacement ............. 152
- controls ............................ 63
Dualdrive
(electric power steering) ...... 89
Engine compartment ............. 171
Engine coolant gauge ............ 22
Engine cooling system fluid
level ................................... 174
Engine oil level ..................... 173
Engine oil
- level check ........................ 173
- technical specifications ..... 202
INDEX