2011 KIA CEED air filter

Maintenance
40
7
Replace the filter according to the
Maintenance Schedule.
If the vehicle is operated in extremely
dusty or sandy areas, replace the ele-ment more often than the usual recom-
mended intervals. (Refer to “Maintenance under severe usage conditions” in thissection.)
CAUTION
 Do not drive with the air cleaner removed; this will result in exces-sive engine wear.
 When removing the air cleaner fil- ter, be careful that dust or dirt
does not enter the air intake, ordamage may result.
 Use a KIA genuine part. Use of nongenuine parts could damage
the air flow sensor, turbochargeror engine.
ED(FL) ENG 7.QXP 10/28/2010 6:26 PM Page 40

741
Maintenance
The climate control air filter installed
behind the glove box filters the dust or
other pollutants that come into the vehi-cle from the outside through the heating
and air conditioning system. If dust or
other pollutants accumulate in the filter
over a period of time, the air flow from the
air vents may decrease, resulting in
moisture accumulation on the inside of
the windshield even when the outside
(fresh) are position is selected. If this
happens, have the climate control air fil-
ter replaced by an Authorized KIA
Dealer.The climate control air filter should bereplaced according to the maintenance
schedule. If the vehicle is operated in the
severely air-polluted cities or on dusty
rough roads for a long period, it shouldbe inspected more frequently and
replaced earlier. When you try to replace
the climate control air filter by owner
maintenance, replace it performing the
following procedure, and in this case, be
careful to avoid damaging other compo-
nents.
Filter replacement
1. With the glove box open, remove thestoppers on both sides to allow the
glove box hang freely on the hinges.
CLIMATE CONTROL AIR FILTER (IF EQUIPPED)
1LDA5047
Outside air
Recirculatedair
Climate control air filter Blower
EvaporatorcoreHeater coreOED076032
ED(FL) ENG 7.QXP 10/28/2010 6:27 PM Page 41

Maintenance
42
7
2. Open the glove box part way, reach
inside and pull out the elastic line and push the retaining clip through the hole
on the side of the glove box. Allow the
glove box to open. 3. Pull out the cover pressing the hooks
of the climate control air filter case. 4. Replace the climate control air filter.
5. Reassemble in the reverse order of
disassembly.
✽✽ NOTICE
When replacing the climate control air
filter install it properly.
Otherwise, the system may producenoise and the effectiveness of the filter
may be reduced.
OED076033OED070034OED076031
ED(FL) ENG 7.QXP 10/28/2010 6:27 PM Page 42

767
Maintenance
Description Fuse rating Protected componentECU 10A Diesel - TCM, ECU, TCU
Gasoline - ECM, PCM, ECU, PCU
ECU 3 10A ECU
ECU 2 10A ECU
ECU 1 30A Diesel - ECM, ECU,TCU
Gasoline - ECM, PCM, ECU, PCU
INJ 15A Diesel - Electrical EGR Actuator, VGT Actuator
Gasoline - Injector #1 ~ #4
SNSR 2 15A Diesel - A/Con Relay, C/Fan Relay (High/Low), Lambda Sensor, Air Heater Relay, Immobilizer
SNSR 1 10A Gasoline - A/Con Relay, C/Fan Relay (High/Low), Camshaft Position Sensor, Canister Purge Solenoid
Valve, Oil Control Valve, Oxygen Sensor Up/Down, Immobilizer
A/CON 10A A/Con Relay SNSR 10A ECU, TCU B/UP 10A Back up lamp
BATT SNSR 10A Battery Sensor
Engine compartment fuse panel (Diesel engine only)
Description Fuse rating Protected component GLOW 80A Glow, Air Heater
PTC HTR 1 50A PTC Heater 1
PTC HTR 2 50A PTC Heater 2
PTC HTR 3 50A PTC Heater 3
FUEL FILTER 30A Fuel Filter (Heater)
ED(FL) ENG 7.QXP 10/28/2010 6:28 PM Page 67

785
Maintenance
EMISSION CONTROL SYSTEM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty infor-
mation contained in the Warranty &
Maintenance booklet in your vehicle.
Your vehicle is equipped with an emis- sion control system to meet all emission
regulations. There are three emission control sys-
tems which are as follows.
(1) Crankcase emission control system
(2) Evaporative emission control system(3) Exhaust emission control system In order to assure the proper function of
the emission control systems, it is rec-
ommended that you have your vehicle
inspected and maintained by an author-
ized KIA dealer in accordance with the
maintenance schedule in this manual. Caution for the Inspection and
Maintenance Test (With Electronic
Stability Program (ESP) system)
 To prevent the vehicle from misfir-
ing during dynamometer testing,
turn the Electronic Stability
Program (ESP) system off by press-
ing the ESP switch.
 After dynamometer testing is com- pleted, turn the ESP system back on
by pressing the ESP switch again. 1. Crankcase emission control
system
The positive crankcase ventilation sys-
tem is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valveinto the induction system.
2. Evaporative emission control system
The Evaporative Emission Control
System is designed to prevent fuel
vapors from escaping into the atmos-
phere.
ED(FL) ENG 7.QXP 10/28/2010 6:30 PM Page 85

Maintenance
88
7
Diesel Particulate Filter (if equipped)
The Diesel Particulate Filter (DPF) sys-
tem removes the soot emitted from the
vehicle.
Unlike a disposable air filter, the DPF
system automatically burns (oxidizes)
and removes the accumulated soot
according to the driving condition. In
other words, the active burning by engine
control system and high exhaust gas
temperature caused by normal/high driv-
ing condition burns and removes the
accumulated soot.
However, if the vehicle continues to be
driven at low speed for long time, the
accumulated soot may not be automati-
cally removed because of low exhaust
gas temperature. In this particular case,the amount of soot is out of detection
limit, the soot oxidation process by
engine control system may not happen
and the malfunction indicator light may
blink. When the malfunction indicator light
blinks, it may stop blinking by driving the
vehicle at more than 60km/h (37 mph) orat more than second gear with 1500 ~
2000 engine rpm for a certain time (for
about 25 minutes). If the malfunction indicator light contin-
ues to be blinked in spite of the proce-
dure, please visit an authorized KIA deal-
er and then check the DPF system.
If you continue to drive with the malfunc-
tion indicator light blinking for a long
time, the DPF system can be damaged
and fuel consumption can be worsen.
CAUTION -
Diesel Fuel
(if equipped with DPF)
It is recommended to use the regu- lated automotive diesel fuel for diesel vehicle equipped with the
DPF system.
If you use diesel fuel including highsulfur (more than 50 ppm sulfur) and unspecified additives, it can
cause the DPF system to be dam- aged and white smoke can be emit-ted.
ED(FL) ENG 7.QXP 10/28/2010 6:30 PM Page 88

I3
Index
Capacities (Lubricants) ·····················································8-5 Care
Exterior care ······························································7-79
Interior care ·······························································7-84
Tire care ····································································7-49
Cargo weight ···································································5-53
Center console storage ····················································4-90
Central door lock switch ·················································4-11
Changing a tire with TPMS ············································6-18
Changing tires ···································································6-8Chains Tire chains ·································································5-42
Checking tire inflation pressure ······································7-50
Child restraint system ·····················································3-26 Tether anchor system ················································3-31
ISOFIX system ·························································3-32
Child-protector rear door lock ·······································4-13
Cigarette lighter ······························································4-93
Climate control air filter ·················································7-41
Climate control system (Automatic) ·····························4-79 Air conditioning ·······················································4-85Automatic heating and air conditioning ···················4-80
Manual heating and air conditioning ·······················4-81
Climate control system (Manual) ··································4-70 Air conditioning ·······················································4-75
Climate control air filter ··········································4-78 Heating and air conditioning·····································4-71
Clothes hanger ································································4-97
Combined instrument, see instrument cluster ················4-36
Cool box··········································································4-91Coolant ···········································································7-31
Cooling fluid, see engine coolant ··································7-31
Crankcase emission control system ·······························7-85
Cruise control system ····················································5-29
Cup holder ·····································································4-94
Curtain air bag ·······························································3-50
Dashboard, see instrument cluster ·································4-36 Dashboard illumination, see instrument panel illumination ·······················································4-38
Daytime running light ·····················································4-63
Defogging (Windshield) ················································4-87
Defroster ·········································································4-69 Outside mirror defroster ············································4-69
Rear window defroster ··············································4-69
Defrosting (Windshield) ················································4-87Dimensions ······································································8-2
Displays, see instrument cluster ····································4-36Display illumination, see instrument panel illumination ·······················································4-38
Door locks ·······································································4-10 Central door lock switch ··········································4-11
C
D
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 3

Index
4
I
Child-protector rear door lock ··································4-13
Super lock system ·····················································4-11
Drinks holders, see cup holders ·····································4-94
Driver's air bag ·······························································3-43
Driving at night ······························································5-38
Driving in flooded areas ················································5-39
Driving in the rain ·························································5-39
Economical operation ····················································5-35
Electric chromic mirror (ECM) ·····································4-32
Electric power steering ··················································4-30
Electronic stability program (ESP) ·································5-23
Emergency starting ··························································6-4 Jump starting ······························································6-4
Push starting ·······························································6-5
Emergency tailgate safety release ··································4-15
Emergency towing ·························································6-22
Emergency while driving ·················································6-2
Emission control system ················································7-85 Crankcase emission control system ·························7-85
Evaporative emission control system ······················7-85
Exhaust emission control system ·····························7-86
Engine compartment ················································2-4, 7-2
Engine coolant ·······························································7-31
Engine number ·································································8-8
Engine oil ·······································································7-30 Engine overheats ······························································6-6
Engine temperature gauge ·············································4-39
Engine will not start ·························································6-3
Evaporative emission control system ····························7-85
Exhaust emission control system ···································7-86Explanation of scheduled maintenance items ················7-27
Exterior care ···································································7-79
Exterior features ···························································4-103
Roof rack ································································4-103
Flat tire ·············································································6-7 Changing tires ····························································6-8
Jack and tools ·····························································6-7
Removing and storing the spare tire ··························6-8
Floor mat anchor(s) ·······················································4-97Fluid Automatic transaxle fluid ··········································7-35
Washer fluid ······························································7-37
Brakes/clutch fluid ···················································7-34
Folding the rear seat ························································3-9
Front fog light ·································································4-62
Front fog light bulb replacement ···································7-72
Front seat adjustment ························································3-4
Fuel filler lid ··································································4-23
Fuel filter(for diesel) ······················································7-38
Fuel gauge ······································································4-39
E
F
ED(FL) Index.qxp 6/28/2010 11:04 AM Page 4