2011 FORD TRANSIT fuel filter

Off-road operation
Inspect frequently, service as
required– Inspect steering linkage, ball joints and U-joints;
lubricate if equipped with grease fittings
– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km) or
6 months– Change engine oil and filter
– Inspect wheels and related components for abnormal
noise, wear, looseness or drag
– Rotate tires, inspect tires for wear and measure tread
depth
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except 6R80 and
TorqShifttransmissions)
– Replace front wheel bearing grease/grease seals if
non-sealed bearings are used (2WD vehicles)
Every 50,000 miles (80,000 km)– Change manual transmission fluid
– Change rear axle fluid (E-450 and F-450/550 only)
Every 60,000 miles (96,000 km)– Change transfer case fluid (4WD vehicles)
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change interval– If ran exclusively on E85, fill the fuel tank full with
regular unleaded fuel
Scheduled Maintenance
284
2011 Transit Connect(tst)
Owners Guide, 2nd Printing
USA(fus)

EXCEPTIONS
In addition, there are several exceptions to the Normal Schedule. They
are listed below:
Normal vehicle axle maintenance
❑Rear axles and power take-off (PTO) units containing synthetic fluid and light duty trucks equipped with Ford-design axles
are lubricated for life. These fluids are not to be checked or changed unless a leak is suspected, service is required or the
axle assembly has been submerged in water. The axle and PTO fluids should be changed anytime the axle and PTO have
been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open throttle for
extended periods above 45 mph (72 km/h), non-synthetic rear axle fluids should be changed every 3,000 miles
(4,800 km) or 3 months, whichever occurs first. The 3,000 mile (4,800 km) fluid change interval may be waived if the
axle was filled with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number F1TZ-19580-B or
equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles (refer to
Maintenance product and specificationsin theMaintenance and Specificationschapter for details). The axle fluid should be
changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑Change rear axle fluid every 100,000 miles (160,000 km). Rear axle fluid change may be waived if the axle was filled
with 75W140 synthetic gear fluid meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add
four ounces (118 mL) of additive friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles. The axle fluid should be changed anytime the axle has been submerged in water.
E–450 and F–450/550 axle maintenance
❑Change rear axle fluid every 100,000 miles (160,000 km) under normal driving conditions. For vehicles operated at or
near maximum Gross Vehicle Weights, the rear axle fluid should be changed every 50,000 miles (80,000 km). In addition,
this 50,000 mile (80,000 km) schedule should be observed when the vehicles are operated under the Special Operating
Conditions.
California fuel filter replacement
❑If the vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this
maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful
life. Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified
intervals and to record all vehicle service.
Class A Motorhome
❑Change brake fluid every two years
Scheduled Maintenance
287
2011 Transit Connect(tst)
Owners Guide, 2nd Printing
USA(fus)

Four-Wheel Drive vehicles
preparing to drive your
vehicle .....................................174
Fuel ............................................239
calculating fuel economy .......243
cap ...........................................241
capacity ...................................257
choosing the right fuel ...........242
detergent in fuel .....................243
filling your vehicle with
fuel ...........................239, 241, 244
filter, specifications ........238, 256
fuel pump shut-off switch .....186
improving fuel economy ........243
octane rating ...........242, 259–260
quality ......................................242
running out of fuel .................243
safety information relating to
automotive fuels .....................239
Fuel pump shut-off switch .......186
Fuses ..........................................187
G
Gas cap (see Fuel cap) ............241
Gas mileage (see Fuel
economy) ...................................243
Gauges .........................................19
H
Hazard flashers .........................186
Headlamps ...................................43
aiming ........................................45
bulb specifications ....................48
daytime running lights .............44
flash to pass ..............................44
high beam .................................44
replacing bulbs .........................50
turning on and off ....................43Heating
heating and air conditioning
system .......................................38
Hood ..........................................226
I
Ignition .......................163, 259–260
Infant seats (see Safety
seats) .........................................116
Inspection/maintenance (I/M)
testing ........................................248
Instrument panel
cleaning ...................................220
cluster ........................................14
lighting up panel and
interior .......................................45
J
Jack ............................................195
positioning ...............................195
storage .....................................195
Jump-starting your vehicle ......203
K
Keys .............................................75
positions of the ignition .........163
L
Lamps
bulb replacement
specifications chart ..................48
daytime running light ...............44
headlamps .................................43
headlamps, flash to pass ..........44
instrument panel, dimming .....45
interior lamps .....................47–48
replacing bulbs .........................50
Index
292
2011 Transit Connect(tst)
Owners Guide, 2nd Printing
USA(fus)