2011 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS check engine

Body
•Wash vehicle thoroughly to remove dirt, grease, oil, tar or mud from
exterior surfaces, rear-wheel housing and underside of front fenders.
See theCleaningchapter for more information.
•Periodically wash vehicles stored in exposed locations.
•Touch-up raw or primed metal to prevent rust.
•Cover chrome and stainless steel parts with a thick coat of auto wax
to prevent discoloration. Re-wax as necessary when the vehicle is
washed. See theCleaningchapter for more information.
•Lubricate all hood, door and trunk lid hinges, and latches with a light
grade oil. See theCleaningchapter for more information.
•Cover interior trim to prevent fading.
•Keep all rubber parts free from oil and solvents.
Engine
•The engine oil and filter should be changed prior to storage, as used
engine oil contain contaminates that may cause engine damage.
•Start the engine every 15 days. Run at fast idle until it reaches normal
operating temperature.
•With your foot on the brake, shift through all the gears while the
engine is running.
Fuel system
•Fill the fuel tank with high-quality fuel until the first automatic shutoff
of the fuel pump nozzle.
Note:During extended periods of vehicle storage (30 days or more),
fuel may deteriorate due to oxidation. Add MotorcraftGas Stabilizer or
equivalent meeting Ford material specification ESE-M99C112-A to the
vehicle fuel system whenever actual or expected storage periods exceed
30 days. Follow the instructions on the additive label. The vehicle should
then be operated at idle speed to circulate the additive throughout the
fuel system.
Cooling system
•Protect against freezing temperatures.
•When removing vehicle from storage, check coolant fluid level.
Confirm there are no cooling system leaks, and fluid is at the
recommended level.
Maintenance and Specifications
122
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

ENGINE DATA
Engine 6.8L V10 engine
Cubic inches 415
Required fuel Minimum 87 octane
Firing order 1-6-5-10-2-7-3-8-4-9
Ignition system Coil on plug
Spark plug gap 0.039-0.043 inch (1.00-1.10mm)
Compression ratio 9.2:1
IDENTIFYING YOUR VEHICLE
Certification label for incomplete vehicles
On completed derivations of incomplete vehicles, the certification label is
affixed at a location determined by a subsequent stage manufacturer of the
completed vehicle. In these cases the completed vehicle is manufactured in
two or more stages by two or more separate manufacturers.
Vehicle Identification Number
The vehicle identification number is located near the cowl to the right of
the air filter.
If you ever find it necessary to communicate with Ford Motor Company
about your vehicle, always include the VIN in your communication.
The Vehicle Identification Number (VIN) contains the following
information:
1. World manufacturer identifier
2. Brake system / Gross Vehicle
Weight Rating (GVWR) / Restraint
Devices and their location
3. Make, vehicle line, series, body
type
4. Engine type
5. Check digit
6. Model year
7. Assembly plant
8. Production sequence number
Maintenance and Specifications
128
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

Owner checks and services
Certain basic maintenance checks and inspections should be performed
by the owner or a service technician at the intervals indicated. Service
information and supporting specifications are provided in this owner’s
guide.
Any adverse condition should be brought to the attention of your dealer
or qualified service technician as soon as possible for the proper service
advice. The owner maintenance service checks are generally not covered
by warranties so you may be charged for labor, parts or fluids used.
Engine oil/coolant change intervals
Engine oil6 months or 7,500 miles (12,000 km)
(whichever comes first)
Engine coolant, initial
change6 years or 105,000 miles (168,000 km)
(whichever comes first)
Engine coolant, after
initial changeEvery 3 years or 45,000 miles (72,000 km)
Check every month
Engine oil level
Function of all interior and exterior lights
Tires for wear and proper pressure, including spare
Windshield washer fluid level
Check every six months
Battery connections; clean if necessary
Body and door drain holes for obstructions; clean if necessary
Cooling system fluid level and coolant strength
Door weatherstrips for wear; lubricate if necessary
Hinges/latches/outside locks for proper operation; lubricate if necessary
Parking brake for proper operation
Safety belts and seat latches for wear and function
Safety warning lamps (brake, ABS, airbag, safety belt) for operation
Washer spray/wiper operation; clean or replace blades as necessary
Scheduled Maintenance Guide
136
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

Multi-point inspection
In order to keep your vehicle running right, it is important to have the
systems on your vehicle checked regularly. This can help identify
potential issues and prevent major problems. Ford Motor Company
recommends the following multi-point inspection be performed at every
scheduled maintenance interval to help ensure your vehicle keeps
running great.
Multi-point inspection – Recommended each visit
Accessory drive belt(s) Half-shaft dust boots (if equipped)
Battery performance Horn operation
Clutch operation (if equipped) Radiator, cooler, heater and A/C hoses
Engine air filter Suspension components for leaks and
damage
Exhaust system Steering and linkage
Exterior lamps and hazard
warning system operationTires for wear and proper pressure,
including spare
Fluid levels*; fill if necessary Windshield for cracks, chips or pits
For oil and fluid leaks Washer spray and wiper operation
*Brake, coolant recovery reservoir, manual and automatic transmission
(with an underhood dipstick), power steering (if equipped) and
window washer
Be sure to ask your dealership service advisor or technician about the
multi-point vehicle inspection. It’s a comprehensive way to perform a
thorough inspection of your vehicle. It’s your checklist that gives you
immediate feedback on the overall condition of your vehicle. You’ll know
what’s been checked, what’s okay, as well as those things that may
require future or immediate attention. The multi-point vehicle inspection
is one more way to keep your vehicle running great!
Scheduled Maintenance Guide
137
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

A
ABS (see Brakes) .......................55
Air cleaner filter .......120–121, 124
Ambulance packages ....................5
Antifreeze
(see Engine coolant) ..................98
Anti-lock brake system
(see Brakes) ..........................55–56
Automatic transmission
driving an automatic
overdrive ...................................59
fluid, adding ............................117
fluid, checking ........................117
fluid, refill capacities ..............125
fluid, specification ..................125
Axle
lubricant specifications ..........125
refill capacities ........................125
B
Battery .........................................96
acid, treating emergencies .......96
jumping a disabled battery ......79
maintenance-free ......................96
replacement, specifications ...124
servicing ....................................96
Brakes ....................................54–55
anti-lock ...............................55–56
anti-lock brake system (ABS)
warning light .............................56
fluid, checking and
adding ..............................115, 117
fluid, refill capacities ..............125
fluid, specifications .................125
lubricant specifications ..........125
shift interlock ............................58Bulbs ............................................21
C
Capacities for refilling fluids ....125
Cell phone use ..............................7
Changing a tire ...........................73
Cleaning your vehicle
engine compartment ................90
wheels ........................................90
Coolant
checking and adding ................98
refill capacities ................101, 125
specifications ..........................125
Cruise control
(see Speed control) ....................23
Customer Assistance ..................63
Ford Extended Service
Plan ..................................130, 133
Getting assistance outside the
U.S. and Canada .......................86
Getting roadside assistance .....63
Getting the service you
need ...........................................83
Ordering additional owner’s
literature ...................................88
Utilizing the
Mediation/Arbitration
Program .....................................86
D
Daytime running lamps
(see Lamps) ................................20
Dipstick
automatic transmission
fluid ..........................................117
engine oil ...................................93
Driving under special
conditions ....................................62
through water ...........................62
Index
153
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

E
Electronic message center .........16
Emergencies, roadside
jump-starting ............................79
Emergency Flashers ...................64
Emission control system ..........111
Engine ........................................128
cleaning .....................................90
coolant .......................................98
fail-safe cooling .......................102
idle speed control .....................96
lubrication specifications .......125
refill capacities ........................125
service points ......................92–93
Engine oil ....................................93
checking and adding ................93
dipstick ......................................93
filter, specifications ..........95, 124
recommendations .....................95
refill capacities ........................125
specifications ..........................125
Event data recording ....................5
Exhaust fumes ............................54
F
Fail safe cooling ........................102
Fluid capacities .........................125
Fuel ............................................104
calculating fuel economy .......108
capacity ...................................125
choosing the right fuel ...........106
detergent in fuel .....................107
filling your vehicle with
fuel ...................................104, 108
filter, specifications ........104, 124
improving fuel economy ........108
octane rating ...................107, 128quality ......................................107
running out of fuel .................107
safety information relating to
automotive fuels .....................104
Fuses ............................................65
G
Gas mileage
(see Fuel economy) .................108
Gauges .........................................13
H
Hazard flashers ...........................64
Headlamps ...................................20
daytime running lights .............20
flash to pass ..............................21
high beam .................................20
turning on and off ....................20
I
Ignition .................................51, 128
Inspection/maintenance (I/M)
testing ........................................112
Instrument panel
cluster ........................................10
lighting up panel and
interior .......................................21
J
Jump-starting your vehicle ........79
K
Keys
positions of the ignition ...........51
Index
154
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)

L
Lamps
daytime running light ...............20
headlamps .................................20
headlamps, flash to pass ..........21
instrument panel, dimming .....21
Lights, warning and indicator ....10
anti-lock brakes (ABS) ............56
Loading instructions ...................47
Load limits ...................................42
Lubricant specifications ...........125
Lug nuts ......................................78
M
Message center ...........................16
english/metric button ...............18
system check button ................18
warning messages .....................18
Motorcraftparts ......................124
O
Octane rating ............................107
Oil (see Engine oil) ....................93
P
Parking brake ..............................57
Parts
(see Motorcraftparts) ...........124
Power distribution box
(see Fuses) .................................69
Power steering
fluid, checking and adding ....114
fluid, refill capacity ................125
fluid, specifications .................125R
Relays ....................................65, 72
Roadside assistance ....................63
S
Safety defects, reporting ............89
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............139
Servicing your vehicle ................91
Spark plugs,
specifications .....................124, 128
Special notice ................................4
Specification chart,
lubricants ...................................125
Speed control ..............................23
Starting your vehicle ............51–53
jump starting ............................79
Steering wheel
tilting .........................................22
T
Tilt steering wheel ......................22
Tires .......................................25–26
alignment ..................................35
care ............................................31
changing ..............................73, 75
checking the pressure ..............30
inflating .....................................27
replacing ..............................33, 76
rotating ......................................36
safety practices .........................34
sidewall information .................37
snow tires and chains ..............41
spare tire ...................................73
terminology ...............................26
tire grades .................................26
treadwear ............................25, 32
Index
155
2011 Motorhome(mot)
Supplement, 2nd Printing
USA(fus)