___ C_ h_ e_c _k _i _ n _g ~ a_n _d_ f_il _l_in _ g _________________________________________ _
Closing the engine hood
- Pull the hood down until the pressure from the strut is
reduced.
- Let the hood
drop down and latch in place . Do not try to
push it shut;
it may fail to engage=> &.
& WARNING
A hood that is not completely latched could fly up and block your
view while driving.
• When you close the engine hood, check it to make sure the
safety catch has properly engaged. The hood should be flush with
the surrounding vehicle body parts.
• If you notice while driving that the hood is not secured prop
erly, stop at once and close it. •
Working in the engine compartment
Be especially careful whenever you work in the engine
compartment!
Whenever you must perform any work in the engine compartment,
for example checking and filling different fluids, there is a risk of
injury, burns and accidents. To prevent personal injury always
observe the following WARNINGS. The engine compartment of any
vehicle is a hazardous area!~
&
& WARNING
To help avoid injury, before you check anything under the hood :
• Turn off the engine.
• Remove the ignition key.
• Set the parking brake fully.
& WARNING (continued)
• Move selector lever of automatic transmission to "P" (Park);
put manual transmission in Neutral.
• Always let the engine cool down. Hot components will burn
skin on contact.
• To reduce the risk of being burned, never open the hood if you
see or hear steam or coolant escaping from the engine compart
ment. Wait until no steam or coolant can be seen or heard before
carefully opening the hood.
• Keep children away from the engine compartment.
• Never spill fluids on hot engine components. They can cause a
fire.
• Never touch the radiator fan. The auxiliary electric fan is
temperature controlled and can switch on suddenly.
• Never open the coolant reservoir cap when the engine is still
warm. The coolant system is pressurized and hot coolant could
spray out!
• Protect your face, hands and arm from steam or hot engine
coolant by placing a thick rag over the cap when you open the
coolant reservoir.
• If work on the fuel system or the electrical system is necessary:
-Always disconnect the battery .
- Never smoke or work near heaters or open flames. Fluids in
the engine compartment could start a fire.
- Keep an approved fire extinguisher immediately available.
• To avoid electrical shock and personal injury while the engine is
running or being started, never touch:
- Ignition cables
- Other components of the high voltage electronic ignition
system.
• If you must perform a check or repair with the engine running: .,_
___________________________________________ C..:__ h:..:.e ..:.c :..:. k.:.... i..:....n :..::g~ a:..:.n..:.... d::.:....: f..:. i.:..:ll :.:.i.:...:n ~g !...._.....Jfflll
& W ARNING (co ntinued )
-First, fully appl y the parking brake , move sele ctor lev er of
automatic tran smission to "P" (Park ); put manual transmis
sion in Neutral.
- Always use extreme caution to prev ent clothing , jewelry, or
long hair from getting caught in the radiator fan , V-belt s or
other moving p art s, or from contacting hot part s. Tie back hair
before starting , and do not wea r clothing that will h ang or
droop into the engine.
• Minimize expo sure to emission and chemical hazards~& .
& WARNING
California Proposition 65 Warning:
• Engine exh aust, some of its constituents , and certain vehicle
c omponents contain or emit ch e mical s known to the State of Cali
fornia to cause can cer and birth defects and rep roductive harm . In
addition , certain fluids contained in vehicle s and certain product s
of component wear contain or emit chem icals known to the State
of California to cau se cancer and birth defect s or other reproduc
tive harm.
• Battery posts, terminal s and related acce ssories contain lead
and lead compounds, chemicals known to the State of California
to cause cancer and reproductive harms . Wash hand s after
handling .
0 Note
When adding fluids, always make sure that they are pou red into the
proper co ntainer or filler opening, otherwise serio us damage to
vehicle systems w ill occur.
Vehicle OP-eration
ffi For the sake of the environment
To detect lea ks i n time, inspect the veh icle floor pan from unde rneath
reg ularly. If yo u see spots from oil or other vehicle fluids, have your
veh icle inspected
b y an au thori zed Au di dea le r. •
Engine compartment
A pp lies to vehicles : w it h 2.0 l t urbo. 4 -cyl ind er en gi ne
2.0 Liter, 4-cylinder turbo gasoline engine
(200 hp)
The se are the most importan t it ems that you can c hec k.
Fig . 16 1 Engi ne c om part men t: 2 .0 I , 4 -c yli nder t urbo
© Coolant expansion tank (-L ) ... ................. .
@ Windshield washer container (W ) .... .... .. .. .. .. .
® Engine oil dipst ick (orange) . ... .. .... .... ... ... . .
Vehicle care Do-it-yourselt service 235
243 231 ~
iTechnical data
___ C_h_ e_c _k _i_n -=g :a,__ a_n_ d_ f_ i_ l _li _n _,g;._ __________________________________________ _
©
®
© Engine oil filler cap ('1:'=:?:)
Brake fluid reservoir ( )
Batte ry .... ...... .. .. .. .... ... ... ... .... ... .. .
& WARNING
232
237
238
Before you check anything in the engine compartment , alway s
read and h eed all WARNINGS =>
& in "Work ing in the engine
compartment" on
page 226. •
Applies to vehicle s: with 2.0 l TOI, 4 -cylinder diesel -eng ine
2.0 liter , 4-cylinder turbo diesel engine
(140 hp)
These are the most important items that you can che ck.
Fi g. 1 62 Engine comp artmen t: 2 .0 l, 4 -cyli nder tu rbo
(D Coolant expansion tank (J- ) ... . .. .... .. ... . .. .. .
@ Windshield washer container (~ ) .. .. ... .... .. ... .
235
243
®
©
®
© Engine oil dipstick (orange) ... .. ..... ... ... .... . .
Engine oil filler cap
('1:'=:?:) .................. .. .. . .
Brake fluid reservoi r ( ) ....... ...... ... .. .. .. . .
B atte ry .... . .. .... .. .... ... . .. .. . ... ... .. .. . .
& WARNING
231
232
237
238
Before you check anything in the engine compartment , alway s
r ead and heed all WARNINGS=>
& in "Work ing in the eng ine
compartment " on
page 226 . •
Engine oil
Engine oil specifications
The engine oil used in your Audi needs the right kind of oil.
The engine in your Audi is a sophisticated powe rp lant t hat was buil t
to exacting spec ifications . Th is engine needs the r ight kind of engine
oil that meets specifications regarding quality and viscosity so that it
can run smoo thly a nd reliably . Choosing the right o il and chang ing oi l
w ith in the time and mileage intervals printed in your vehicle 's
W arranty
& Mainte nance booklet ma tters a lot more today than i t did
years ago. Audi has developed a special quality standard for eng ine oil
t ha t wi ll help assure tha t your veh icle's engi ne will get t he lubri cat io n
it needs for proper operation .
Modern engine lu brication has take n a quantum leap in the last few
years . Many synt het ic oils available today provide be tte r engine lub ri
cation that can outlast tradit ional petro leum-based oi ls, making
t hem a smart choi ce fo r use througho ut the life of your Aud i.
Whether you use synthetic or petroleum-based engine oil, the oil that
you use mus t conform to A udi's oil quality standard VW 5 02 00 (veh i
cles wit h gasoline eng ine) and VW 507 00 (vehicle with diese l
eng ine) to help keep your ve hicle's engine runn ing smooth ly and help ..,
___ C_ h_ e_c _k _i _ n _g ~ a_n _d_ f_il _l_in _ g _________________________________________ _
Under some circumstances the engine oil should even be changed
more frequently. Change oil more often if you drive mostly short
distances, operate the vehicle in dusty areas or mostly under stop
and-go traff ic conditions, or when you use your vehicle where temper
atures stay below freezing point for long periods .
Detergent additives in the oil will make fresh oil look dark after the
engine has been run ning for a short time . This is normal and is not a
reason to change the oil more often than recommended .
Damage or malfunctions due to lack of maintenance
It is essentia l that you change your oi l at the recommended intervals
using only engine oil that complies with Audi oi l standard VW 502 00
(vehicles with gasoline engine) or VW 507 00 (vehicles with diesel
engine). Your Limited New Vehicle Warranty does not cover damage
or malfunctions due to failure to follow recommended maintenance
and use requirements as set forth in the Audi Owner's Manua l and
Warranty
& Maintenance booklet. Your dealer will have to deny
warranty coverage unless you present to the dealer proof in the form
of Service or Repair Orders that all scheduled maintenance was
performed in a timely manner .•
Engine oil consumption
The engine in your vehicle depends on an adequate
amount of oil to lubricate and cool all of its moving parts.
In order to provide effective lubrication and cooling of internal
engine components, all internal combustion engines consume a
certain amount of o il. Oil consumpt ion varies from engine to engine
and may change significant ly over the life of the eng ine. Typically,
engines with a specified break- in period (see~
page 197) consume
more oi l during the break-in period than they cons ume after oil
consumption has stabilized.
Under normal cond itions, the rate of oil consumpt ion depends on the
quality and vis cosity of the oil, the RPM (revol utions pe r minute) at
which the engine is operated, the ambient temperature and road
conditions. Further factors are the amount of oi l dilution from water condensation or fuel residue and the ox
idation level of the o il. As any
eng ine is subject to wear as mileage builds up, the oil consumption
may increase over time until replacement of worn components may
become necessary.
With all these variab les coming into play, no standard rate of oil
consumption can be established or specified. There is no alternative
to regular and frequent checking of the oil level , see
Note .
If the yellow engine oil level warning symbol in the instrument
cl uster .... lights up, you should check the oil level as soon as possible
with the oil dipstick~ page 231. Top off the o il at your earliest
convenience ~
page 232.
& WARNING
Before you check anything in the engine compartment, always
read and heed all WARNINGS~
& in "Work ing in the engine
compartment" on
page 226.
0 Note
Driving with an insufficient oil level is likely to cause severe damage
to the engine .
[ i ] Tips
• The oil pressure warning display 't::r. is not an indicator of the oil
level. Do not rely on it. Instead, check the oil level in your engine at
regular intervals, preferably each time you refuel, and alway s
before going on a long trip.
• If you have the impression your eng ine consumes excessive
amounts of oi l, we recommend that you consu lt your authorized Audi
dea ler to have the cause of your concern properly diagnosed. Keep in
mind that the accurate measurement of oil consumption requires
great care and may take some time . Your authorized Audi dea le r has
instructions about how to measure oil consumption accurately. •
Checking and filling --------------------=------=:;______,.J
Checking the engine oil level
Fig. 163 Dipstick
(Version A): O il level
rang es
Fig. 164 Dipstick
(Version B) : Oil level
ranges
Before you check anything in the engine compartment,
always r ead and h eed all WARNINGS ~ & in "Working in
the engine compartment" on
page 226.
D ete rmining oil l ev e l
- Park your vehicle so that it is horizontally level.
- While at operating state temperature, briefly let the
engine run at idle and then shut it off.
- Wait approx . two minutes.
Vehicle OP-eration
-Pull out the oil dipstick. Wipe off the oil dipstick with a
clean cloth, and slide it back in as far as it will go.
- Pull it back out and read off the oil level~ fig. 163 or
~ fig. 164. Top off the engine oil, if applicable
~ page 232 .
Oil level w ithin range @
- Do not add oil.
Oil level within range®
- You can add oil. A~erwards, the oil level should be within
range @.
Oil level within range ©
-You must add oil. A~erwards, the oil level should be
within range @.
The oil level needs to be checked at regular intervals. The best times
to do this are whenever you refuel and prior to long trips.
Depending on the way the vehicle is driven and the operating condi
tions, oil consumption can be up to 1/2 quart per 600 miles (0.5 liter
per 2,000 km). Consumption may be higher within the first 3,000
miles (5,000 km). •
Vehicle care Do-it-yourselt service iTechnical data
--~C:!:h ~e~ c:.! k~ i~ n ~g~ a~n~ d~ f~il ~l~in ~ g ~ ----------------------------------------
Adding engine oil 9=:7,
Fig . 16 5 Engine
c om partment : Oil filler
c ap loc atio n
Befo re you ch eck anyt hing i n th e eng ine compart ment,
always read and heed all WARNINGS => & in "W orking in
t h e en gine compar tm ent" on
pag e 22 6.
- Stopp ing the e ngine.
- Unscrew the cap
- C arefully top off wit h the app ropriate oil i n 0.5 liter doses .
- Ch eck the oil lev el agai n afte r two minutes=>
pag e 231.
- To p of f t he oil ag ain, if neces sa ry .
- Screw the cap back on t he fi lling ho le a nd slide the oil
d ip st ic k i n as far as it will go.
& WARNING
• While topping off, the oil must not come in contact with hot
engine part s -fire hazard!
• The oil filler cap must be properly secured to prevent oil from
being sprayed on the hot engine and exhaust sy stem when the
engine is running -fire hazard!
& WA RNING (contin u ed )
• If your skin has come in contact with the engine oil , you must
subsequently cleanse it thoroughly .
0 Note
• The oi l level mus t not be above rang e@ -danger of converter or
eng ine damage! Contact a qualified workshop to draw off oil, if
nece ssary.
• Audi does not recommend the use of oil additives. They may
damage the engine and adversely affect your New Vehicle Limited
Warranty.
W For the sake of the environment
• Under no c ircumstances can the o il come in contact with the
sew age netwo rk o r the soil.
• Observe and follow legal regulations when dispos ing of empty oil
conta iners. •
Changing the eng ine oil
W e recommend th at have your oi l chan ged by an autho
ri zed A udi de aler or a quali fied service station.
Before you check anything in the engine compar tment, always read
and heed all WARNINGS :::,
& in "Working in the engine compart
ment" on
page 226 .
The eng ine oil must be changed according to the intervals specified in
your Warran ty
& M ainte nanc e bo oklet. This is very im po rta nt bec ause
the lub ricating properties of oil d imin ish gradually during normal
vehicle use .
Under some circumstances t he e ngine o il should be changed more
frequently. C hange o il more often if you drive most ly short dista nces,
operate the vehicle in dusty a reas or under p redo minan tly s to p-an d-
Checking and filling --------------~--!'WI
go traffic co ndi tio ns, or have yo ur ve hicle where temperat ures remain _.,
b el ow free zin g f or ext en ded p erio ds.
De terg en t addi tives i n the o il w ill make fr esh oil look dark af ter the
engine has been ru nning for a s hort time . T his is norma l an d is not a
re ason t o change the oil more oft en than r eco mme nde d.
Because of the p roblem of proper disposal, a long w ith the spec ia l
tool s and neces sar y experti se require d, we s tro ngl y rec ommend t hat
yo u have your o il cha nged by an a uth orized
Audi dealer o r a qua lified
service stat io n.
If you choose to change your oil yourself , plea se no te the followi ng
im po rtant i nformation:
& WARNING
To reduce the risk of personal injury if you must change the engine
oil in your vehicle yourself :
• Wear eye protection.
• To reduce the risk of burns from hot engine oil, let the engine
cool down to the touch .
• When removing the oil drain plug with your fingers, stay as far
away as possible. Always keep your forearm parallel to the ground
to help prevent hot oil from running down your arm.
• Drain the oil into a container designed for this purpose, one
large enough to hold at least the total amount of oil in your
engine .
• Engine oil is poisonous. Keep it well out of the reach of chil·
dren.
• Continuous contact with used engine oil is harmful to your
skin. Always protect your skin by washing oil off thoroughly with
soap and water.
Safety first
0 Note
Never m ix o il addi tives w it h your e ngi ne oil. These additives can
dama ge your engine and adverse ly affect yo ur Audi New Vehicle
Li mi ted Warr anty .
c£> For the sake of the environment
• B efore changi ng y our oil, firs t mak e sure you know w he re you ca n
prope rly dispose of the used oil.
• Alw ays dis pose of used eng ine oil prope rly. Do n ot du mp i t on
garden soi l, wooded areas, into open st reams or down sewage drains.
• Recy cle used engine o il by taking it to a used e ngine oil collectio n
facility in your area, o r contact a serv ice stat ion .•
A pp lies to ve hicles : w it h d iese l e ng in e
Important information for vehicles with
diesel engine when adding or changing
engine oil
On v eh ic le s wit h a di ese l en gin e alway s us e engin e oil t hat
co nfo rms t o Audi oi l sp ecifi ca tion VW 5 07 00 w hen
addin g or changing engine oil.
Vehicles with diese l engines require an d must always use special
eng ine oi l that con forms to Audi o il sp ecifica tion
VW 507 00 .
Never use any othe r kind of eng ine o il in your vehicle , not eve n to top
o ff t he o il level.
A t th e t ime o f pr inting , we a re aware that Castro[ ® produces engine
oil that confo rms to Au di oil s peci fica tion VW 507 0 0. T his oi l may
no t ye t be available throughou t North Ame rica . Ot her oil m anufac·
t u rers may offer eng ine oi l t h at con forms to A udi oi l sp ecification
VW 50 7 00 at this t ime or some f uture date . ..,
Vehicle care Technical data
IJIII Checking and filling
-------=:---- =------------------------------------
Please be sure to consu lt with your aut horized Aud i dea ler for infor
m ation and availabili ty of the proper engine oil fo r yo ur vehicle's
diesel engine and fo r the latest technical informat ion .
Beca use t his spec ia l engine o il may not be avai lab le when need it, we
s tr ong ly recommend t hat yo u alw ays car ry with yo u extr a qu art (liter)
of oil that conforms to A ud i oil specificat ion VW 507 00, in case you
have to top off o il wh ile on the road.
& WARNING
Failure to use engine oil for your diesel engine that expressly
conforms to Audi oil specification VW 507 00 can cause engine
failure on the highway that can cau se a cra sh and serious per sonal
injury.
• Never use any amount of engine oil in the diesel engine that
does not conform to Audi oil specification VW 507 00 .
• Always carry with you an extra quart (liter ) of engine oil that
conforms to Audi oil specification VW 507 00
in case you must top
off the oil while on the road .
& WARNING
Improperly stored items can become airborne missiles, flying
through the vehicle causing serious personal injury in the event of
hard braking or an accident. To help reduce the risk of serious
personal injury:
• Always store extra quart (liter ) of engine oil for your diesel
engine in its original oil container that is securely closed in the
luggage compartment. Make sure the container is securely stored
and mounted.
0 Note
• If you use engine oil that does not express ly co nform to A udi o il
spe cifica tion VW 507 00, very ser ious and ve ry expens ive da mage to
your vehicle's eng ine will occ ur. Eng ine damage caused by using the wrong engine oil
is not covered by your New Vehicle Lim ited
W arran ty.
• Not all comme rcia lly available oils conform to t his very rigid Audi
oil qua lity stand ard eve n th ough they may be sy nth et ic -b as ed and
have the same v iscosity .•
Engine cooling system
Coolant
The engine coo lant per forms t wo functions: i t keeps the
engin e fro m ove rhea ting and i t pro tec ts th e engine from
f ree zin g in t he win ter .
The cooling system is sealed and genera lly requ ires little attention.
Th e cooling system has been filled at the factory wit h a permanent
coo lant which does not need to be c hanged. The coolant cons ists of a
mixt ure of water an d the manufacturer's glyco l-basedcoolant ad di
tive G12 ++ a ntifree ze with a nticorros ion addit ives (50% fo r USA
mode ls; 60% for Canadian models). This mixture both ass ures the
nece ssary frost protec tion and p rotects meta l components in the
eng ine's cooling system from corrosion and scaling. It also raises the
boiling poin t of the co olant.
Do not red uce the co ncent ration of the coolant in the summer by
add ing p la in water.
The proportion of coolant additive must be at
least 50 % but not more than 60%
to ma inta in an tifreeze protectio n
and coo ling efficiency. If the coolant frost protect ion is too low, t he
coo lant co uld free ze and damage t he veh icle h eating and eng ine
coo ling system.
F or ye ar-round drivi ng, an tifr ee ze is add ed at t he fa ctory for tempe r
atures dow n to:
• - 31°F( -35°C)USA
• -40 °F ( -40 °C) Canada .