2010 YAMAHA FZR check engine

Trouble recovery
86
EJU34561
Troubleshooting
If you have any trouble with your watercraft, use the troubleshooting chart to check for the pos-
sible cause.
If you cannot find the cause, consult a Yamaha dealer.
EJU36984Troubleshooting chart
Confirm the possible cause and remedy, and then refer to the applicable page.
TROUBLE POSSIBLE CAUSE REMEDY PAGE
Engine does not
start (Starter motor
does not turn over)Yamaha Se-
curity SystemLock mode selected Select unlock mode
25
Engine shut-
off switchClip not in place Install clip
26
Fuse Burned out Replace fuse and
check wiring90
Battery Run down Recharge 76
Poor terminal con-
nectionsTighten as required
76
Terminal corroded Clean or replace 76
Starter motor Faulty Have serviced by
Yamaha dealer—
Engine does not
start (Starter motor
turns over)Throttle lever Squeezed Release 26
Fuel Empty Refill as soon as pos-
sible46
Stale or contaminat-
edHave serviced by
Yamaha dealer—
Fuel tank Water or dirt present Have serviced by
Yamaha dealer—
Spark plug Fouled or defective Have serviced by
Yamaha dealer—
Spark plug
capNot connected or
looseHave serviced by
Yamaha dealer—
Connected to wrong
cylinderHave serviced by
Yamaha dealer—
Fuel injec-
tion systemFuel pump faulty Have serviced by
Yamaha dealer—
UF2R71E0.book Page 86 Monday, July 13, 2009 11:28 AM

Trouble recovery
87
Engine runs irregu-
larly or stallsFuel Empty Refill as soon as pos-
sible46
Stale or contaminat-
edHave serviced by
Yamaha dealer—
Fuel tank Water or dirt present Have serviced by
Yamaha dealer—
Spark plug Fouled or defective Have serviced by
Yamaha dealer—
Incorrect heat range Have serviced by
Yamaha dealer—
Gap incorrect Have serviced by
Yamaha dealer—
Spark plug
capNot connected or
looseHave serviced by
Yamaha dealer—
Cracked, torn, or
damagedHave serviced by
Yamaha dealer—
Electrical wir-
ingLoose connection Have serviced by
Yamaha dealer—
Fuel injec-
tion systemFaulty or clogged in-
jectorsHave serviced by
Yamaha dealer—
Warning light or in-
dicator blinks or
comes onFuel level Empty Refill as soon as pos-
sible46
Oil pressure
warningOil pressure dropped Have serviced by
Yamaha dealer36
Engine over-
heatedJet intake clogged Clean
89
Check engine
warningFaulty sensors Have serviced by
Yamaha dealer38 TROUBLE POSSIBLE CAUSE REMEDY PAGE
UF2R71E0.book Page 87 Monday, July 13, 2009 11:28 AM

Trouble recovery
89
EJU34622
Emergency procedures EJU34634Cleaning the jet intake and impeller
WARNING
EWJ00782
Before attempting to remove weeds or de-
bris from the jet intake or impeller area,
shut the engine off and remove the clip
from the engine shut-off switch. Severe in-
jury or death could result from coming in
contact with the rotating parts of the jet
pump.
If weeds or debris gets caught in the jet intake
or impeller, cavitation can occur, causing jet
thrust to decrease even though engine speed
rises. If this condition is allowed to continue,
the engine will overheat and may seize.
NOTICE: If weeds or debris gets caught in
the jet intake, do not operate the watercraft
above trolling speed until they have been
removed.
[ECJ00653]
If there is any sign that the jet intake or impel-
ler is clogged with weeds or debris, return to
shore and check the intake and impeller. Al-ways stop the engine before beaching the wa-
tercraft.
(1) Place a suitable clean cloth or carpeting
underneath the watercraft to protect it
from abrasions and scratches. Turn the
watercraft on its side as shown. NOTICE:
Always turn the watercraft over onto
its port (left) side. When turning the
watercraft on its side, support the bow
so that the handlebars are not bent or
damaged.
[ECJ00661]
UF2R71E0.book Page 89 Monday, July 13, 2009 11:28 AM

Index
A
After removing the watercraft from the
water ..................................................... 74
B
Battery care .............................................. 76
Battery checks.......................................... 56
Battery, jumping ....................................... 90
Beaching and docking the watercraft ....... 73
Beverage holder ....................................... 44
Bilge water check ..................................... 56
Bilge water, draining................................. 49
Bilge water, draining on land .................... 49
Bilge water, draining on water .................. 50
Boarding alone ......................................... 69
Boarding and starting off from a dock ...... 72
Boarding the watercraft ............................ 68
Boarding with a passenger....................... 69
Bow eye ................................................... 41
Bow storage compartment ....................... 41
Builder’s plate............................................. 2
C
Capsized watercraft ................................. 72
Check engine warning.............................. 38
Cleaning ................................................... 79
Cleaning the watercraft ............................ 76
Cooling water pilot outlet check ............... 62
Cooling water pilot outlets ........................ 28
Craft Identification Number (CIN) ............... 1
Cruising limitations ................................... 11
D
Dual analog meter unit ............................. 34
Dual analog meter unit check................... 62
E
Emergency procedures ............................ 89
Engine break-in ........................................ 52
Engine compartment check...................... 55
Engine cover, removing and installing ..... 81
Engine idling speed check ....................... 62
Engine oil ................................................. 48
Engine oil and oil filter .............................. 84
Engine oil level check............................... 56
Engine oil requirements ........................... 48
Engine overheat warning ......................... 37
Engine serial number ................................. 1
Engine shut-off cord (lanyard) check ....... 60Engine shut-off switch .............................. 26
Engine stop switch ................................... 26
Engine unit check ..................................... 56
Enjoy your watercraft responsibly ............ 17
Equipment ................................................ 39
F
Fire extinguisher check ............................ 61
Fire extinguisher holder and cover ........... 44
Fire extinguisher holder, cover, and
band checks.......................................... 61
Flushing the cooling water passages ....... 75
Fuel .......................................................... 46
Fuel level check ....................................... 55
Fuel level meter ........................................ 36
Fuel level warning .................................... 36
Fuel requirements .................................... 46
Fuel system checks .................................. 55
Fuses, replacing ....................................... 90
G
Getting to know your watercraft ............... 63
Glossary, watercraft ................................. 19
Glove compartment .................................. 42
H
Hazard information ................................... 15
Hood check .............................................. 62
Hour meter/voltmeter ............................... 35
Hull and deck check ................................. 61
I
Identification numbers ................................ 1
Information display ................................... 35
J
Jet intake and impeller, cleaning .............. 89
Jet intake checks ...................................... 61
Jumper cables, connecting ...................... 90
L
Labels, important ........................................ 3
Labels, other .............................................. 8
Labels, warning .......................................... 4
Launching the watercraft .......................... 64
Learning to operate your watercraft ......... 63
Leaving the watercraft .............................. 65
Limitations on who may operate the
watercraft .............................................. 10
Long-term storage .................................... 79
Low RPM Mode ........................................ 32
UF2R71E0.book Page 1 Monday, July 13, 2009 11:28 AM

Index
Lubrication................................................ 79
M
Main components, location of .................. 20
Maintenance............................................. 81
Model information....................................... 2
O
Oil pressure warning ................................ 36
Operating in weeded areas ...................... 73
Operating the watercraft........................... 65
Operating the watercraft in reverse .......... 68
Operating your watercraft......................... 63
Operation requirements ........................... 12
P
Periodic maintenance chart...................... 83
Post-launch checks .................................. 62
Post-operation care .................................. 75
Pre-launch checks.................................... 55
Pre-operation check points ...................... 55
Pre-operation checklist............................. 53
Primary Identification (PRI-ID) number ...... 1
Q
Quick Shift Trim System (Q.S.T.S.) ......... 31
Quick Shift Trim System (Q.S.T.S.)
checks................................................... 58
R
Reboarding grip........................................ 40
Reboarding step ....................................... 40
Recommended equipment ....................... 14
Remote control transmitter ....................... 24
Remote control transmitter check ............ 59
Reverse system ....................................... 30
Reverse system checks ........................... 58
Riding position.......................................... 64
Rustproofing ............................................. 79
S
Safe boating rules .................................... 17
Safety equipment check ........................... 61
Seats ........................................................ 39
Speedometer............................................ 34
Start switch............................................... 26
Starting off ................................................ 71
Starting off from a trailer........................... 72
Starting the engine on water .................... 64
Steering system ....................................... 27
Steering system checks ........................... 57Stern drain plug checks ............................ 61
Stern eyes ................................................ 41
Stopping the engine ................................. 65
Stopping the watercraft ............................ 67
Storage compartment checks .................. 60
Storage compartments ............................. 41
Submerged watercraft .............................. 92
Switch checks .......................................... 60
T
Tachometer .............................................. 34
Telescopic steering system ...................... 28
Telescopic steering system checks .......... 57
Throttle lever ............................................ 27
Throttle lever checks ................................ 59
Tool kit...................................................... 81
Towing the watercraft ............................... 92
Transporting on a trailer ........................... 51
Troubleshooting ....................................... 86
Troubleshooting chart .............................. 86
Turning the watercraft .............................. 66
W
Water separator ....................................... 29
Water separator check ............................. 55
Watercraft characteristics ......................... 15
Watercraft control functions ..................... 24
Watercraft operation functions ................. 30
Watercraft operation modes ..................... 32
Watertight storage compartment .............. 44
Y
Yamaha Security System ......................... 25
Yamaha Security System settings ........... 25
UF2R71E0.book Page 2 Monday, July 13, 2009 11:28 AM