2010 VOLVO XC60 battery

06 Maintenance and specifications
Battery
06

245
•Never disconnect the battery when the
engine is running, or when the key is in the
ignition. This could damage the vehicle's
electrical system.
•The battery should be disconnected from
the vehicle when a battery charger is used
directly on the battery.
•To help keep the battery in good condition,
the vehicle should be driven for at least 15
minutes a week or connected to a charger
with an automatic charging function.
•If the battery is fully discharged a number
of times, this may shorten its service life.
Keeping the battery fully charged helps
prolong its service life.
•The service life of a battery is affected by
factors such as driving conditions and cli-
mate. Extreme cold may also further
decrease the battery’s starting capacity.
•Because the battery’s starting capacity
decreases with time, it may be necessary
to recharge it if the vehicle is not driven for
an extended period of time or if the vehicle
is usually only driven short distances.
•
CAUTION
•Always use distilled or deionized water
(battery water).
•Never fill above the level mark in the cell.
Changing
WARNING
Connect and disconnect the positive and
negative cables in the correct sequence.
RemovalSwitch off the ignition and wait at least
5 minutes before disconnecting the battery so

06 Maintenance and specifications
Battery
06
246
that all information in the vehicle's electrical
system can be stored in the control modules.
Open the clips on the front cover and
remove the cover.
Release the rubber moulding so that the
rear cover is free.
Remove the rear cover by pulling it away.
Detach the black negative cable.
Detach the red positive cable
Detach the ventilation hose from the
battery
Loosen the screw holding the battery
clamp.
Move the battery to the side and lift it up.
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related acces-
sories contain lead and lead compounds,
chemicals known to the state of California
to cause cancer and reproductive harm.
Wash hands after handling.
Installation1. Lower the battery into the battery box.
G021771
2. Move the battery inward and to the side
until it reaches the rear edge of the box.
3. Screw in the battery with the screw in the
clamp.
4. Connect the ventilation hose.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).
8. Reinstall the cold section moulding. (See
Removal).
9. Reinstall the front cover and secure it with
the clips. (See Removal).

06 Maintenance and specifications
Wheels and tires
06

271
WARNING
The bottle is equipped with a catch to keep
it securely in place and help prevent sealing
compound leakage. Once in place, the bot-
tle cannot be unscrewed. This must be done
by a trained and qualified Volvo service
technician.
6. Remove the valve cap from the tire’s infla-
tion valve and screw the tire sealing sys-
tem’s hose connector onto the valve as
tightly as possible by hand.
7. Connect the electrical wire to the nearest
12-volt socket in the vehicle.
8. Start the vehicle’s engine.
WARNING
The vehicle´s engine should be running
when the tire sealing system is used to avoid
battery drain. Therefore, be sure the vehicle
is parked in a well ventilated place, or out-
doors, before using the system.
9. Start the tire sealing system’s compressor
by pressing the on/off switch to position I.
WARNING
•Never stand next to the tire being inflated
when the compressor is in operation.
•If cracks, bubbles, etc. form on the tire,
switch off the compressor immediately.
•If there is visible damage to the sidewall
or the rim, the tire cannot be repaired.
The vehicle should not be driven if this
occurs. Contact a towing service or
Volvo On Call Roadside Assistance if
applicable.
NOTE
The air pressure gauge will temporarily
show an increase in pressure to approxi-
mately 88 psi (6 bar) while the sealing com-
pound is being pumped into the tire. The
pressure should return to a normal level
after approximately 30 seconds.
10. Within seven minutes, inflate the tire to
between 22—44 psi (1.8—3.0 bar). Switch
off the compressor briefly to get a clear
reading from the pressure gauge.
CAUTION
The compressor should not be used for
more than 10 minutes at a time to avoid
overheating.
WARNING
If the pressure remains below 22 psi
(1.8 bar) after approximately seven minutes,
turn off the compressor. In this case, the
hole is too large to be sealed and the vehicle
should not be driven.
11. Switch off the compressor and disconnect
the electrical wire from the 12-volt socket.
12. Unscrew the hose from the tire’s inflation
valve and reinstall the valve cap.
13. Immediately drive the vehicle for approxi-
mately 2 miles (3 km) at a maximum speed
of 50 mph (80 km/h) to distribute the seal-
ing compound in the tire.

06 Maintenance and specifications
Wheels and tires
06

273 Inflating tires
The tire sealing system can be used to inflate
the tires. To do so:
1. Park the car in a safe place.
2. The compressor should be switched off.
Ensure that the on/off switch is in position
0 (the 0 side of the switch should be
pressed down).
3. Take out the electrical wire and hose.
4. Remove the valve cap from the tire’s infla-
tion valve and screw the hose connector
onto the valve as tightly as possible by
hand.
5. Connect the electrical wire to the nearest
12-volt socket in the vehicle.
6. Start the vehicle’s engine.
WARNING
•The vehicle’s engine should be running
when the tire sealing system is used to
avoid battery drain. Therefore, be sure
the vehicle is parked in a well ventilated
place, or outdoors, before using the sys-
tem.
•Children should never be left unattended
in the vehicle when the engine is running.
7. Check the tire’s inflation pressure on the
gauge. Switch off the compressor briefly to
get a clear reading from the pressure
gauge.
8. Refer to the tire inflation tables for the cor-
rect inflation pressure. If the tire needs to
be inflated, start the tire sealing system’s
compressor (press the on/off switch to
position I). If necessary, release air from the
tire by turning the air release knob coun-
terclockwise.
CAUTION
The compressor should not be used for
more than 10 minutes at a time to avoid
overheating.
9. Turn off the compressor (press the on/off
switch to position 0) when the correct infla-
tion pressure has been reached.
10. Unscrew the hose from the tire’s inflation
valve and reinstall the valve cap.
11. Disconnect the electrical wire from the
12-volt socket.
Tire Pressure Monitoring System
(TPMS)–U.S models only
NOTE
USA – FCC ID: KR5S122780002
This device complies with part 15 of the
FCC rules. Operation is subject to the fol-
lowing conditions: (1) This device may not
cause harmful interference, and (2) this
device must accept any interference
received, including interference that may
cause undesired operation.
The tire pressure monitoring system uses sen-
sors mounted in the tire valves to check infla-
tion pressure levels. When the vehicle is mov-
ing at a speed of approximately 20 mph
(30 km/h) or faster, these sensors transmit
inflation pressure data to a receiver located in
the vehicle.
When low inflation pressure is detected, TPMS
will light up the tire pressure warning light
(
) (also referred to as a telltale) in the
instrument panel and will display one of the
following messages in the text window:
LOW
TIRE PRESS. CHECK TIRES or VERY LOW
TIRE PRESSURE.

06 Maintenance and specifications
Specifications
06
289
FluidSystemVolumeSpecification
Washer fluid6.8 US qts (6.5 liters)
4.7 US qts (4.5 liters
B)
Use a washer antifreeze recom-
mended by Volvo, mixed with
water.
Fuel tank volume3.0T/3.2 6 cyl.18.5 US gallons (70 liters)
AUnder normal driving conditions the transmission oil does not need changing during its service life. However, it may be necessary under adverse driving conditions.BModels without headlight washers
Electrical system
General information12 volt system with a voltage-regulated alter-
nator. Single pole system in which the chassis
and engine block are used as conductors. The
negative terminal is connected to the chassis.
Performance, battery
Engine3.2 6-cyl./3.0T
Voltage (V)12
Cold start capacity (A)520 – 700
Reserve capacity (min)100 – 135
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related acces-
sories contain lead and lead compounds,
chemicals known to the state of California
to cause cancer and reproductive harm.
Wash hands after handling.
CAUTION
If the battery is replaced, replace it with a
battery of the same cold start capacity and
reserve capacity as the original (see the
decal on the battery).

07 Index
07
292
1, 2, 3 ...
12-volt sockets........................................ 200
A
ABS (anti-lock brake system).................. 113
Accessory installation warning.................. 10
Active chassis system.............................158
Active yaw control................................... 156
Adaptive cruise control.................... 173, 175
Airbags
disconnecting the front passenger’s
side.................................................24, 25
front...................................................... 20
inflatable curtain................................... 30
side impact........................................... 28
Air conditioning........................................ 129
Air distribution.......................................... 127
Air distribution table................................. 131
Air vents................................................... 127
All Wheel Drive......................................... 112
Anti-freeze.......................................206, 232Anti-lock brake system............................ 113
warning light......................................... 74
Anti-lock Brake System (ABS)................. 113
Approach lighting................................56, 93
Audio system
audio functions................................... 134
CD player/changer.............................. 144
HD digital radio................................... 138
overview.............................................. 133
radio functions.................................... 135
Sirius satellite radio............................141
sound settings.................................... 134
steering wheel keypad........................ 133
USB/iPodŸ connector........................ 136
Auto-dim rearview mirror......................... 100
Automatic locking retractor....................... 36
Automatic transmission
Geartronic........................................... 111
general description.....................110, 111
oil........................................................ 288
shiftlock override................................ 111
Axle weight.............................................. 262
B
Battery
changing............................................. 245
maintenance...............................244, 245
remote key, replacing........................... 59
specifications...................................... 289
warning symbols................................. 244
Black box.............................................9, 226
Blind Spot Information System
(BLIS)....................................... 194, 195, 196
Bluetooth cell phone connection............. 147
Booster cushion, integrated...................... 47
Booster cushions....................................... 43
Brake lights................................................ 90
Brake system
checking fluid level............................. 232
emergency brake assistance.............. 114
fluid..................................................... 288
general information............................. 113
Hill Descent Control............................ 115
warning light......................................... 76
Bulbs
cargo area lighting.............................. 240
footwell lighting................................... 239
headlights...........................234, 235, 236

07 Index
07
297
Rear seats
center head restraint............................. 85
folding................................................... 84
heated................................................. 129
Rearview mirror
auto-dim function............................... 100
compass............................................. 155
Rear window defroster............................100
Recalls, child restraints.............................. 46
Refrigerant............................................... 288
Refueling..........................................208, 209
fuel filler cap....................................... 210
fuel filler door...................................... 210
fuel tank volume.................................288
Registering child restraints........................ 46
Remote key................................................ 54
approach lighting.................................. 56
immobilizer.....................................54, 55
key blade........................................ 54, 59
key memory.......................................... 54
locking the vehicle................................ 56
Personal Car Communicator..........56, 57
replacing the battery............................. 59
unlocking the vehicle............................ 56
Remote key/PCC
common functions................................ 56Reporting safety defects............................ 15
Roadside Assistance............................... 290
Rollover Protection System (ROPS).......... 33
Roll Stability Control (RSC)........................ 33
Roof loads............................................... 214
S
Safety, occupant........................................ 14
Safety defects, reporting........................... 15
Seat belt
reminder................................................ 17
Seat belts
Automatic locking retractor/Emergency
locking retractor.................................... 36
buckling................................................ 16
maintenance......................................... 16
pretensioners........................................ 16
reminder................................................ 16
reminder warning light.......................... 76
securing child restraint sys-
tems.......................................... 39, 41, 43
unbuckling............................................ 16
use during pregnancy........................... 18
using.....................................................16Seats, front.......................................... 81, 82
Side door mirrors....................................... 99
Side impact airbags................................... 28
Side marker lights, changing bulbs......... 237
Sirius satellite radio.................................. 141
Snow chains............................................ 264
Snow tires................................................ 264
Sound settings, audio system................. 134
Spare tire................................................. 265
Speed-dependent steering...................... 158
Spin control............................................. 156
SRS............................................................ 19
Stability system....................................... 156
indicator light........................................ 75
Starting the engine..................................106
with keyless drive............................... 106
Starting the vehicle
after a crash (crash mode)....................34
Start inhibitor (immobilizer)..................54, 55
Steel grid in cargo area............................ 215
Steering wheel
adjusting............................................... 87
horn....................................................... 87
keypad.................................. 87, 122, 133