2010 VOLVO S80 battery

06 Maintenance and specifications
Battery
06

233
•Never disconnect the battery when the
engine is running, or when the key is in the
ignition. This could damage the vehicle's
electrical system.
•The battery should be disconnected from
the vehicle when a battery charger is used
directly on the battery.
•To help keep the battery in good condition,
the vehicle should be driven for at least 15
minutes a week or connected to a charger
with an automatic charging function.
•If the battery is fully discharged a number
of times, this may shorten its service life.
Keeping the battery fully charged helps
prolong its service life.
•The service life of a battery is affected by
factors such as driving conditions and cli-
mate. Extreme cold may also further
decrease the battery’s starting capacity.
•Because the battery’s starting capacity
decreases with time, it may be necessary
to recharge it if the vehicle is not driven for
an extended period of time or if the vehicle
is usually only driven short distances.
•
CAUTION
•Always use distilled or deionized water
(battery water).
•Never fill above the level mark in the cell.
Changing
WARNING
Connect and disconnect the positive and
negative cables in the correct sequence.
RemovalSwitch off the ignition and wait at least
5 minutes before disconnecting the battery so

06 Maintenance and specifications
Battery
06
234
that all information in the vehicle's electrical
system can be stored in the control modules.
Open the clips on the front cover and
remove the cover.
Release the rubber moulding so that the
rear cover is free.
Remove the rear cover by pulling it away.
Detach the black negative cable.
Detach the red positive cable
Detach the ventilation hose from the
battery
Loosen the screw holding the battery
clamp.
Move the battery to the side and lift it up.
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related acces-
sories contain lead and lead compounds,
chemicals known to the state of California
to cause cancer and reproductive harm.
Wash hands after handling.
Installation1. Lower the battery into the battery box.
G021771
2. Move the battery inward and to the side
until it reaches the rear edge of the box.
3. Screw in the battery with the screw in the
clamp.
4. Connect the ventilation hose.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).
8. Reinstall the cold section moulding. (See
Removal).
9. Reinstall the front cover and secure it with
the clips. (See Removal).

06 Maintenance and specifications
Wheels and tires
06
260
•Stage 1: The hole is sealed by pumping
sealing compound into the tire. The car is
then driven a short distance to distribute
the sealing compound in the tire.
NOTE
Do not remove any foreign objects (nails,
etc.) from the tire before using the sealing
system.
•Stage 2: The tire’s inflation pressure is
checked and adjusted if necessary.
WARNING
•Never leave the tire sealing system
unattended when it is operating.
•Keep the tire sealing system away from
children.
•Be sure the vehicle is parked safely off
the road and away from moving traffic.
•Apply the parking brake.
Stage 1: Sealing the hole1. Open the cover on the tire sealing kit.
2. Peel off the speed limit sticker and affix it
to the steering wheel hub where it will be
clearly visible to the driver.3. Ensure that the on/off switch is in posi-
tion 0 (the 0 side of the switch should be
pressed down).
WARNING
Contact with the sealing compound may
cause skin irritation. If contact occurs, wash
the affected area immediately with soap and
water.
4. Unscrew the orange cover over the bottle
holder and unscrew the cap on the bottle
of sealing compound.
NOTE
Do not break the seal on the bottle. This
occurs automatically when the bottle is
screwed into the holder.
5. Screw the bottle into the bottle holder.
WARNING
The bottle is equipped with a catch to keep
it securely in place and help prevent sealing
compound leakage. Once in place, the bot-
tle cannot be unscrewed. This must be done
by a trained and qualified Volvo service
technician.
6. Remove the valve cap from the tire’s infla-
tion valve and screw the tire sealing sys-
tem’s hose connector onto the valve as
tightly as possible by hand.
7. Connect the electrical wire to the nearest
12-volt socket in the vehicle.
8. Start the vehicle’s engine.
WARNING
The vehicle´s engine should be running
when the tire sealing system is used to avoid
battery drain. Therefore, be sure the vehicle
is parked in a well ventilated place, or out-
doors, before using the system.
9. Start the tire sealing system’s compressor
by pressing the on/off switch to position I.

06 Maintenance and specifications
Wheels and tires
06
262
WARNING
If heavy vibrations, unsteady steering
behavior, or noises should occur while driv-
ing, reduce speed and park the vehicle in a
safe place. Recheck the tire for bumps,
cracks, or other visible damage, and
recheck its inflation pressure. If the pressure
is below 19 psi (1.3 bar), do not continue
driving. Have the vehicle towed to a trained
and qualified Volvo service technician.
Stage 2: Checking inflation pressure1. Connect the tire sealing system as descri-
bed in stage 1.
2. Refer to the inflation pressure tablesfor the
correct inflation pressure. If the tire needs
to be inflated, start the tire sealing system’s
compressor. If necessary, release air from
the tire by turning the air release knob
counterclockwise.
CAUTION
The compressor should not be used for
more than 10 minutes at a time to avoid
overheating.
WARNING
If you interrupt your trip for more than 1
hour, check the inflation pressure in the
damaged tire again before continuing.
Replacing the sealing compound
container
The sealing compound container must be
replaced if:
•the tire sealing system has been used to
repair a tire
•the container’s expiration date has passed
(see the date on decal).
NOTE
•After use, the sealing compound bottle,
the hose, and certain other system
components must be replaced. Please
consult your Volvo retailer for replace-
ment parts.
•If the sealing compound bottle’s expi-
ration date has passed, please take it to
a Volvo retailer or a recycling station
that can properly dispose of harmful
substances.
Inflating tires
The tire sealing system can be used to inflate
the tires. To do so:
1. Park the car in a safe place.
2. The compressor should be switched off.
Ensure that the on/off switch is in position
0 (the 0 side of the switch should be
pressed down).
3. Take out the electrical wire and hose.
4. Remove the valve cap from the tire’s infla-
tion valve and screw the hose connector
onto the valve as tightly as possible by
hand.
5. Connect the electrical wire to the nearest
12-volt socket in the vehicle.
6. Start the vehicle’s engine.
WARNING
•The vehicle’s engine should be running
when the tire sealing system is used to
avoid battery drain. Therefore, be sure
the vehicle is parked in a well ventilated
place, or outdoors, before using the sys-
tem.
•Children should never be left unattended
in the vehicle when the engine is running.

06 Maintenance and specifications
Specifications
06
279 Electrical system
General information12 volt system with a voltage-regulated alter-
nator. Single pole system in which the chassis
and engine block are used as conductors. The
negative terminal is connected to the chassis.
Performance, battery
Engine3.2
6-cyl./3.0TV8
Voltage (V)1212
Cold start
capacity (A)520-700600-8
00
Reserve capacity
(min)100-135120-1
60
WARNING
PROPOSITION 65 WARNING!
Battery posts, terminals, and related acces-
sories contain lead and lead compounds,
chemicals known to the state of California
to cause cancer and reproductive harm.
Wash hands after handling.
CAUTION
If the battery is replaced, replace it with a
battery of the same cold start capacity and
reserve capacity as the original (see the
decal on the battery).

07 Index
07
282
1, 2, 3 ...
12-volt sockets........................................ 191
A
ABS (anti-lock brake system).................. 114
Accessory installation warning.................. 10
Active chassis system.............................158
Active yaw control................................... 156
Adaptive cruise control.................... 167, 169
Airbags
disconnecting the front passenger’s
side.................................................24, 25
front...................................................... 20
inflatable curtain................................... 30
side impact........................................... 28
Air conditioning........................................ 130
Air distribution.......................................... 127
Air distribution table................................. 132
Air vents................................................... 128
All Wheel Drive......................................... 113
Anti-freeze.......................................198, 220Anti-lock brake system............................ 114
warning light......................................... 74
Anti-lock Brake System (ABS)................. 114
Approach lighting................................54, 95
Audio system
audio functions................................... 134
CD player/changer.............................. 144
HD digital radio................................... 138
overview.............................................. 133
radio functions.................................... 135
Sirius satellite radio............................141
sound settings.................................... 134
steering wheel keypad........................ 133
USB/iPodŸ connector........................ 136
Auto-dim rearview mirror......................... 101
Automatic locking retractor....................... 35
Automatic transmission
Geartronic................................... 111, 112
general description.....................111, 112
oil........................................................ 278
shiftlock override................................ 112
Axle weight.............................................. 252
B
Battery
changing............................................. 233
maintenance...............................232, 233
remote key, replacing........................... 57
specifications...................................... 279
warning symbols................................. 232
Black box.............................................9, 214
Blind Spot Information System
(BLIS)....................................... 185, 186, 187
Bluetooth cell phone connection............. 147
Booster cushions....................................... 42
Brake lights................................................ 92
Brake system
checking fluid level............................. 220
emergency brake assistance.............. 115
fluid..................................................... 278
general information............................. 114
warning light......................................... 76
Bulbs
footwell lighting................................... 227
headlights...........................222, 223, 224
introduction......................................... 222
license plate lights.............................. 227
side marker lights...............................225

07 Index
07
287
Refueling..........................................200, 201
fuel filler cap....................................... 202
fuel filler door...................................... 202
fuel tank volume.................................278
Registering child restraints........................ 45
Remote key................................................ 52
approach lighting.................................. 54
immobilizer.....................................52, 53
key blade........................................ 52, 57
key memory.......................................... 52
locking the vehicle................................ 54
Personal Car Communicator..........54, 55
replacing the battery............................. 57
unlocking the vehicle............................ 54
Remote key/PCC
common functions................................ 54
Reporting safety defects............................ 15
Roadside Assistance............................... 280
Roof loads............................................... 206
S
S80 Executive
analogue clock..................................... 78
front seat lumbar support..................... 87
front seat massage function................. 87glasses................................................ 192
moving the front passenger's seat....... 88
refrigerator.......................................... 192
Safety, occupant........................................ 14
Safety defects, reporting........................... 15
Seat belt
reminder................................................ 17
Seat belts
Automatic locking retractor/Emergency
locking retractor.................................... 35
buckling................................................ 16
maintenance......................................... 16
pretensioners........................................ 16
reminder................................................ 16
reminder warning light.......................... 76
securing child restraint sys-
tems.......................................... 38, 40, 42
unbuckling............................................ 16
use during pregnancy........................... 18
using.....................................................16
Seats, front....................................82, 83, 87
Side door mirrors..................................... 100
Side impact airbags................................... 28
Side marker lights, changing bulbs......... 225
Sirius satellite radio.................................. 141
Snow chains............................................ 254Snow tires................................................ 254
Sound settings, audio system................. 134
Spare tire................................................. 255
Speed-dependent steering...................... 158
Spin control............................................. 156
SRS............................................................ 19
Stability system....................................... 156
indicator light........................................ 75
Starting the engine..................................107
with keyless drive............................... 107
Starting the vehicle
after a crash (crash mode)....................33
Start inhibitor (immobilizer)..................52, 53
Steering wheel
adjusting............................................... 89
horn....................................................... 89
keypad.................................. 89, 122, 133
Stone chips, touching up......................... 269
Storage spaces........................................ 189
Studded tires........................................... 254
Sunroof (moonroof).................................. 102
Sun shade.................................................. 99
Supplemental restraint system.................. 19
warning light......................................... 76