2010 Seat Leon 5D service

If and when253
Safety First
Operating Instructions
Practical Tips
Technical Specifications
You will also find instructions for operating the compressor.
WARNING
•Do not attempt to repair a puncture with the sealing compound if the
tyre has been damaged by driving the vehicle after the tyre has lost its air.•Always observe warnings and follow instructions concerning
compressor and sealing compound carefully.•Do not drive faster than 80 km/h, avoid heavy acceleration, hard
braking and fast cornering.•Tyres which have been repaired with sealing compound are only suit-
able for temporary use over a short period. Therefore, please drive carefully
to the next available specialised workshop.For the sake of the environment
If you have to dispose of a sealant can, go to a specialised waste ser vice or to
a SEAT Technical Service, where the product can be recycled in an appropriate
waste container.
Note
•If sealant should leak out, leave it to dry. This way you can pull it off like a
piece of foil.•Observe the expiry date stated on the sealing compound can. Have the
sealing compound exchanged by a specialised workshop.•Seek professional assistance if the repair of a tyre puncture is not
possible with the sealing compound.
Preparation work
Certain steps must be taken before repairing a tyre.– If you have a flat tyre or puncture, park the vehicle as far away from the flow of traffic as possible.
–Apply the handbrake firmly.
– Engage first gear , or put the selector lever to position P.
–All passengers should leave the vehicle. They should wait in a
safe area (for instance behind the roadside crash barrier).
– Check whether a repair is possibl e using the Tyre Mobility System
“General information and safety notes.”
– Unscrew inflation cap from the affected wheel.
– Take the tyre repair kit out of the luggage compartment.
WARNING
Put the hazard warning lights on and place the warning triangle in position.
This is for your own safety and also warns other road users.
Caution
Take special care if you have to repair a tyre on a slope.
Note
Please observe legal requirements when doing so.
Leon_EN.book Seite 253 Mittwoch, 1. September 2010 6:16 18

If and when
256•If you replace a fuse with higher-rating fuse, you could cause damage to
another location in the electrical system.•Always keep some spare fuses in the vehicle. These are available from
SEAT dealers.•In addition to the fuses listed in the following tables, there are other fuses
which must be replaced by the Technical Service Workshop.
Leon_EN.book Seite 256 Mittwoch, 1. September 2010 6:16 18

Description of specifications
276If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with a
wheelbase of less than 1 metre), at least 4% of the actual trailer weight is a
legal stipulation for a drawbar load.
WARNING
•For safet y reas ons , d o not excee d the 8 0 k m/h limit . Th is is als o valid in
countries where higher speeds are permitted.•Never exceed the maximum trailer weights or the drawbar load. If the
permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
WheelsTyre pressure, snow chains, wheel boltsTyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. Do not
reduce the slightly raised pressures of warm tyres ⇒.
Snow chains
Snow chains may be fitted only to the front wheels.
Consult the chapter “wheels” of this manual.
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel bolts
s ho uld b e che cke d as s o on as p ossible wit h a to rqu e w re nch ⇒. The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
•Check the tyre pressure at least once per month. Checking the tyre
pressure is very important. If the tyre pressure is too high or too low, there
is an increased danger of accidents, particularly at high speeds.•If the torque of the wheel bolts is too low, they could loosen while the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads can be damaged.Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.
Leon_EN.book Seite 276 Mittwoch, 1. September 2010 6:16 18

Technical Specifications277
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Technical SpecificationsChecking fluid levelsFrom time to time, the levels of the different fluids in the
vehicle must be checked. Never fill with incorrect fluids,
otherwise serious damage to the engine may be caused.
Coolant expansion tank
Windscreen washer fluid reservoir
Engine oil filler cap
Engine oil dipstick
Brake fluid reservoir
Vehicle battery (underneath the cover)
The checking and refilling of service fluids are carried out on the components
mentioned above. These operations are described in the ⇒page 221. Overview
You will find further explanations, instructions and restrictions on the tech-
nical specifications as of
⇒page 273.
Fig. 186 Diagram for the
location of the various
elements
A1A2A3A4A5A6
Leon_EN.book Seite 277 Mittwoch, 1. September 2010 6:16 18

Index
300Oil properties . . . . . . . . . . . . . . . . . . . . . . . . 225
Specifications . . . . . . . . . . . . . . . . . . . . . . . 224
Topping up . . . . . . . . . . . . . . . . . . . . . . . . . . 226
Engine oil dipstick . . . . . . . . . . . . . . . . . . . . . . . 225
Engine oil pressure Warning lamp . . . . . . . . . . . . . . . . . . . . . 66, 87
Environment . . . . . . . . . . . . . . . . . . . . . . . . . . . 195 Environmental friendliness . . . . . . . . . . . . 197
Environmental tip Avoiding pollution . . . . . . . . . . . . . . . . . . . . 215
Environmentally friendly driving . . . . . . . . . . . 195
ESP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88, 187 See also Electronic Stability Programme . . 161
Example of menu use Program a speed limit warning . . . . . . . . . . 69
To activate and deactivate the speed limit warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Example of the use of the menus Open the Configuration menu with the MFI lever68
Open the Configuration menu with the steering wheel controls . . . . . . . . . . . . . . . . . . . . . . 69
Examples of menu use Open the main menu . . . . . . . . . . . . . . . . . . 68
Open the winter tyres menu . . . . . . . . . . . . . 69
To close the winter tyres menu . . . . . . . . . . . 69
Exhaust gas purification system . . . . . . . . . . . 194
Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 206
FFabric trim cleaning . . . . . . . . . . . . . . . . . . . . . 210
Fastening rings . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Fire extinguisher . . . . . . . . . . . . . . . . . . . . . . . . 145
First aid kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Flexible service interval display . . . . . . . . . . . . . 62
Floor mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Fog lights with cornering function . . . . . . . . . . 122
Fold down the backrest . . . . . . . . . . . . . . . . . . 140
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Front drink holders . . . . . . . . . . . . . . . . . . . . . . 142
Front interior light Switching off . . . . . . . . . . . . . . . . . . . . . . . . 125
Switching on . . . . . . . . . . . . . . . . . . . . . . . . 125
Front passenger airbag deactivation . . . . . . . . . 44
Front reading lights . . . . . . . . . . . . . . . . . . . . . . 126
Front seat adjustment Lumbar support . . . . . . . . . . . . . . . . . . . . . . 138
Fuel Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 219
Fuel level Indicator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Fuel reserve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 Warning message . . . . . . . . . . . . . . . . . . . . . 67 Fuel Tank
Opening the fuel tank flap . . . . . . . . . . . . . 214
Fuel tank See Fuel reserve . . . . . . . . . . . . . . . . . . . . . . 82
Fuel: save . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
GG 12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Gear shift pattern . . . . . . . . . . . . . . . . . . . . . . . 170
General overview of the engine compartment 277
Glove compartment . . . . . . . . . . . . . . . . . . . . . 141
Glow plug system . . . . . . . . . . . . . . . . . . . . . . . 164 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
GRA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 181HHandbrake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176 Warning lamp . . . . . . . . . . . . . . . . . . . . 86, 176
Hazard warning lights . . . . . . . . . . . . . . . . . . . . 122
HBA . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185
Head restraints Adjusting . . . . . . . . . . . . . . . . . . . . . . . 136, 137
Adjustment of the head restraint angle . . . 137
Removing . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Headlight flashers . . . . . . . . . . . . . . . . . . . . . . . 124
Headlight range control . . . . . . . . . . . . . . . . . . 121
Leon_EN.book Seite 300 Mittwoch, 1. September 2010 6:16 18

Index
304Tightening torque of wheel bolts . . . . . . . . . . . 276
Tilting sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . 52
Tow starting
Comments . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing a trailer . . . . . . . . . . . . . . . . . . . . . . . . . 275
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . 200
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 201
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Traction control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 89
Trailer Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . 199
Trailer turn signals Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 124
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 275
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124 Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 83
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 124
Tyre Mobility System (Tyre repair kit) . . . . . . . . 252
Tyre Mobility-System (Tyre repair kit) . . . . . . . 247
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 237 Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Tyre pressure monitoring . . . . . . . . . . . . . . . . . 238
Tyre pressure warning lamp . . . . . . . . . . . . . . . . 85
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 276 Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . . 247, 252
Tyres and wheels
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 242
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 239
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . 240
Tyres with directional tread pattern . . . . . . . . . 237
UUnderbody protection . . . . . . . . . . . . . . . . . . . . 208
Unlocking and locking Personalisation . . . . . . . . . . . . . . . . . . . . . . 102VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . 234
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 274
Vehicle identification data . . . . . . . . . . . . . . . . 274
Vehicle identification number . . . . . . . . . . . . . 274
Vehicle modifications . . . . . . . . . . . . . . . . . . . . 212
Vehicle paintworkMaintenance . . . . . . . . . . . . . . . . . . . . . . . . 205
Products for vehicle maintenance . . . . . . . 203
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245
Vehicle washing . . . . . . . . . . . . . . . . . . . . . . . . 204
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Volumetric sensor* Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Deactivation . . . . . . . . . . . . . . . . . . . . . . . . 108
WWarning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Warning messages in the display . . . . . . . . . . . 66
Warning reportsRed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 80
Yellow . . . . . . . . . . . . . . . . . . . . . . . . . . . 66, 81
Warning symbols . . . . . . . . . . . . . . . . . . . . . . . . 80
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 145
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . 230
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . 204
Washing the vehicle . . . . . . . . . . . . . . . . . . . . . 204
Washing with high pressure cleaners . . . . . . . 205
Water Warning message . . . . . . . . . . . . . . . . . . . . . 67
Water in the windscreen washer tank . . . . . . . 230
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 240
Wearing suitable shoes . . . . . . . . . . . . . . . . . . . 16
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . 249, 276 Tightening torque . . . . . . . . . . . . . . . . . . . . 243
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . . 248
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . 237, 276
Why assume the correct sitting position? . . . . . 30
Why should head restraints be correctly adjusted? 13
Why wear seat belts? . . . . . . . . . . . . . . . 19, 21, 30
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Windscreen interval wipe . . . . . . . . . . . . . . . . . 128
Leon_EN.book Seite 304 Mittwoch, 1. September 2010 6:16 18

SEAT S.A. is permanently concerned about continuous development of its types and models. For this reason we ask you to understand, that
at any given time, changes regarding shape, equipment and technique may take place on the car delivered. For this reason no rig ht at all
may derive based on the data, drawings and descriptions in this current handbook.
All texts, illustrations and standards in this handbook are based on the status of information at the time of printing. Except for error or omis-
sion, the information included in the current handbook is valid as of the date of closing print.
Re-printing, copying or translating, whether total or partial is not allowed unless SEAT allows it in written form.
SEAT reserves all rights in accordance with the "Copyright" Act.
All rights on changes are reserved.
This paper has been manufactured using bleached non-chlorine cellulose.
© SEAT S.A. - Reprint: 15.09.10
Vehicle data
1.
2.
3.
4.
5.
1.Vehicle identification number
2
.Identification numbers
Type/Model/Engine
Gearbox/Finishes
3
.Identification letters
Engine/Gearbox/Paintwork
Equipment
4
.Identification codes of variable equipment
5
.Consumption (l/100 km) / CO2Emissions (g/km) urban
Consumption (l/100 km) / CO
2Emissions (g/km) motorway
Consumption (l/100 km) / CO
2Emissions (g/km) mixed
Note
• We recommend that you visit an Authorised SEAT Service Centre when-
ever you require any work done on your vehicle.
• SEAT regularly communicates to its Authorised Service Centres new
product developments. They have tools and highly specialized person-
nel who can guarantee the safety and performance of your vehicle.
• Scrupulously following the General Programme for Inspection
Services in Authorised SEAT Service Centres will ensure you maintain
greater value for your vehicle.
Portada PM_interior.qxd:Interior Manual TOLEDO 26/7/10 15:57 Página 3