2010 Seat Leon 5D air filter

SEAT maintenance programme7
SEAT maintenance programmeService intervalsGeneral informationTo ensure that you have each service carrie d out on time and that none are
forgotten, there is a reminder sticker on the dr iver side door pillar and a
reminder will also be shown via the serv ice interval display on the instrument
panel.
The service intervals quoted are for vehicles used under normal operating
conditions .
However, if the vehicle is used in adverse conditions, it may require work
before the next established service int erval or even between service inter-
vals.
Adverse conditions include:•the use of fuel with a high sulphur content•frequent short journeys•leaving the engine idling for long periods o f time (as occurs with taxis)•driving on dusty roads or in dusty areas•frequently using the vehicle for towing•mainly driving in the city, in heavy traffic whe re it is necessary to continu-
ously brake and start, and•using the vehicle mainly in the winter
This particularly affects:•the air filter
•the timing belt•the engine oil and•the diesel particulate filter
In some countries diesel fuel has a high sulp hur content; in these cases the
fuel filter and the oil should be changed every 7 ,500 km (5,000 miles)
⇒ page 8. Your Official SEAT Service will b e able to tell you which countries
have diesel with a high sulphur content.
The service advisor at your Official SEAT Ser vice will advise you on the need
to carry out additional work on your vehicle, t aking into account the usage
conditions of the vehicle.
A list of the work to be carried out at the SEAT services is given on the
following pages. These services are valid at the time of printing and can be
subject to further modifications for technical reaso ns. Your Official SEAT
Service always has the latest available in formation and will be able to tell
you if your vehicle requires any other additio nal inspections established by
law.
The cost of the SEAT service may vary, depen ding on the vehicle type, equip-
ment fitted, additional work and statutor y inspections. Your Official SEAT
Service will tell you how much the SEAT serv ice will cost (labour and parts).
Prog Manto Ibizas-Alteas_EN.book Seite 7 Dienstag, 14. September 2010 11:40 11

General Service Programme11
additional tasks. The service advisor at you r Official SEAT Service will advise
you accordingly.Additional tasksIn addition to the Inspection Service, addit ional maintenance jobs may have
to be carried out, depending on the conditions in which your vehicle is used
and on the equipment carried. This add itional work should be carried out in
accordance with time/distance travelled to ensure your vehicle remains reli-
able. Your Service Centre will provide de tailed information about the addi-
tional work that may be necessary. This can be done independently of the
obligatory services, taking into account the no tes on the Maintenance
Programme (or the label: Next service). Y our SEAT Service Centre will be
happy to advise you and quote the prices for th is additional work. Additional
jobs completed are marked on the work shop sheet with the receipt.Every 7,500 km (5,000 miles)•Replace the fuel filter in TDI
® diesel engines that use diesel with a sulphu r
content of more than 2,000 ppm.
Every 15,000 km (10,000 miles)•Replace the rubber bearings of the engine c over (only engines with
engine codes CDLA and CDLD).•LPG installation filter
2): Replace. Only engines with LPG (engine c ode
CHGA).
Every 30,000 km (20,000 miles)•Fuel filter: Replace in diesel engine vehicle s if the fuel does not comply
with the EN 590 standard.•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Ibiza, Ibiza SC, Ibiza ST).•Gas hoses: inspect for damage: Only engin es with LPG
2) (engine code
CHGA).
•LPG filler neck and cap
2): Check condition and clean and inspect se als if
necessary. Only engines with LPG (engine cod e CHGA).
Every 60,000 km (40,000 miles)•Change oil and oil filter for DSG
® automatic gearboxes (where equipped)
- only 6-speed DSG
® gearboxes.
•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Altea, Altea XL, Altea Freetrack and Leon)•Spark plugs : Replace (except 1.8 and 2.0 TFSI engines up to 147 kW).•Air filter: Clean casing and replace filter elemen t (only engines codes
CDLA and CDLD).•LPG evaporator: Check for traces of oil or o ther dirt. Only engines with
LPG2) (engine code CHGA).
2)LPG: Liquefied petroleum gas.
Prog Manto Ibizas-Alteas_EN.book Seite 11 Dienstag, 14. September 2010 11:40 11

General Service Programme
12Every 90,000 km (60,000 miles)•Air filter: Clean casing and replace filter elemen t (except engine codes
CDLA and CDLD).•Fuel filter: Replacement (only diesel engines using fuel complying with
the DIN EN 590 standard)•Replace spark plugs – only vehicles driven o ver 90,000 km (60,000 miles)
in 6 years (only 1.8 TSI and 2.0 TSI
® engines up to 147 kW)
•LPG evaporator paper filter: Replace. Only engi nes with LPG
2) (engine
code CHGA).
At 90,000 km (60,000 miles) the first time, then every 30,000 km (20,000 miles)•Timing belt for camshaft: Check condit ion and replace if necessary (only
petrol engines, except 2.0 TFSI).At 120,000 km (80,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (only 125 kW TDI-PD e ngines).
At 150,000 km (90,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (TDI-PD engines, except 125 kW).Every 150,000 km (90,000 miles)•Timing belt for camshaft: Replace (only TDI-PD engines).At 180,000 km (120,000 miles) the first time, then every 30,000 km (20,000 miles)•Particulate filter: Check (TDI Common Rail e ngines).Every 210,000 km (130,000 miles)•Timing belt for camshaft: Replace (TDI Common Rail engines).•Camshaft timing belt tension roller: Replace (T DI Common Rail engines).Every 300,000 km (200,000 miles)•Camshaft timing belt tension roller: Replace (TDI-PD engines).
Prog Manto Ibizas-Alteas_EN.book Seite 12 Dienstag, 14. September 2010 11:40 11

General Service Programme13
Every 2 years•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Ibiza, Ibiza SC, Ibiza ST).After 3 years the first time, then every 2 years•Brake fluid: Replace.•Check the gas system (LPG). Only engines with LPG (engine code
CHGA).Every 3 years•Haldex clutch: Replace oil (four-wheel drive vehicles).Every 4 years•Dust and pollen filter for the passenger com partment: Replace. (Only
models: Altea, Altea XL, Altea Freetrack, Leo n)•Spark plugs : Replace (except 1.8 and 2.0 TFSI engines up to 147 kW).•Air filter: Clean casing and replace filter elemen t (only engines codes
CDLA and CDLD).
Every 6 years•Air filter element replaced and housing cleane d•Replace spark plugs.Note
•We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle.•SEAT keeps its Technical Services up-to-da te on new product develop-
ments. They have tools and highly specia lised personnel who can guarantee
the safety and performance of your vehicle.•Scrupulously following the General Programme for Inspection Services in
Authorised SEAT Services will ensure you m aintain greater value for your
vehicle.
Prog Manto Ibizas-Alteas_EN.book Seite 13 Dienstag, 14. September 2010 11:40 11

Records19
Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YE S NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travell ed: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 19 Dienstag, 14. September 2010 11:40 11

Records
20Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YES NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travel led: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 20 Dienstag, 14. September 2010 11:40 11

Records21
Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YE S NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travell ed: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 21 Dienstag, 14. September 2010 11:40 11

Records
22Service records
Note
We recommend that you visit an Authorised SEAT Service Centre whenever
you require any work done on your vehicle. Sc rupulously following of the
Services (oil, interval, inspection) at an Offi cial SEAT Service will increase the
value of your vehicle.
LongLife Service:
YES NO
Oil change
cc
Inspection
cc
Service dependent on time/distance travel led: YES NO
Oil change
cc
Interval
cc
Inspection
cc
Additional jobs: YES NO YES NO
Brake fluid
cc
Air cleaner
cc
Spark plugs
cc
Fuel filter
cc
Dust and
pollen filters
cc
Timing belt
cc
DSG
®: oil and filter
cc

Date
Km/Miles:
Invoice number
Repair recommendation:
Service carried out by:
Official SEAT Service stamp
Next Service to be carried out:
Date:
Km/Miles: (whichever is first)
Prog Manto Ibizas-Alteas_EN.book Seite 22 Dienstag, 14. September 2010 11:40 11