2010 Seat Ibiza ST steering wheel

Intelligent technology
162Electronic Stability Programme (ESP)*
ESP reduces the danger of skidding by braking the wheels individually.
The system uses the steering wheel angle and road speed to calculate the
changes of direction desired by the driver, and constantly compares them
with the actual behaviour of the vehicle. If the desired course is not being
maintained (for instance, if the vehicle is starting to skid), then the ESP
compensates automatically by braking the appropriate wheel.
The forces acting on the braked wheel bring the vehicle back to a stable
condition. If the vehicle tends to oversteer, the system will act on the front
wheel on the outside of the turn.
WARNING
•It must be remembered that ESP cannot defy the laws of physics. This
should be kept in mind, particularly on slippery and wet roads and when
towing a trailer.•Always adapt your driving style to suit the condition of the roads and
the traffic situation. Do not let the extra safety afforded by ESP tempt you
into taking any risks when driving, as this can cause accidents.Caution
•In order to ensure that ESP functions correctly, all four wheels must be
fitted with the same tyres. Any differences in the rolling radius of the tyres can
cause the system to reduce engine power when this is not desired.•Modifications to the vehicle (e.g. to the engine, the brake system, running
gear or any components affecting the wheels and tyres) could affect the effi-
ciency of the ABS, EDL, ESP and TCS.
Anti-lock brake system (ABS)The anti-lock brake system prevents the wheels locking during braking
⇒ page 160.Electronic differential lock (EDL)*
The electronic differential lock helps prevent the loss of trac-
tion caused if one of the driven wheels starts spinning.EDL helps the vehicle to start moving, accelerate and climb a gradient in slip-
pery conditions where this may otherwise be difficult or even impossible.
The system will control the revolutions of the drive wheels using the ABS
sensors (in case of an EDL fault the warning lamp for ABS lights up)
⇒ page 63.
At speeds of up to approximately 80 km/h, it is able to balance out differ-
ences in the speed of the driven wheels of approximately 100 rpm caused by
a slippery road surface on one side of the vehicle. It does this by braking the
wheel which has lost traction and distributing more driving force to the other
driven wheel via the differential.
To prevent the disc brake of the braking wheel from overheating, the EDL cuts
out automatically if subjected to excessive loads. The vehicle will continue to
function normally without EDL. For this reason, the driver is not informed that
the EDL has been switched off.
The EDL will switch on again automatically when the brake has cooled down.
WARNING
•When accelerating on a slippery surface, for example on ice and snow,
press the accelerator carefully. Despite EDL, the driven wheels may start to
spin. This could impair the vehicle’s stability.
IbizaST_EN.book Seite 162 Dienstag, 14. September 2010 1:31 13

Checking and refilling levels205
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Tyre ser vice life
The service life of tyres is dependent on tyre pressure, driving
style and fitting.
Wear indicators
The original tyres on your vehicle have 1.6 mm high tread wear indicators
⇒page 205, fig. 133 , running across the tread. Depending on the make,
there will be 6 to 8 of them evenly spaced around the tyre. Markings on the
tyre sidewall (for instance the letters “TWI” or other symbols) indicate the
positions of the tread wear indicators. The minimum tread depth required by
law is 1.6 mm (measured in the tread grooves next to the tread wear indica-
tors). Worn tyres must be replaced. Different figures may apply in export
countries ⇒.
Tyre pressure
Incorrect tyre pressure causes premature wear and could cause tyre blow-out.
For this reason, the tyre pressure should be checked at least once per month
⇒ page 204.
Driving style
Fast cornering, heavy acceleration and hard braking all increase tyre wear.
Changing wheels around
If the front tyres are worn considerably more than the rear ones it is advisable
to cha nge t he m ar oun d as sh own ⇒page 205, fig. 134. All the tyres will then
last for about the same time.
Wheel balance
The wheels on new vehicles are balanced. However, various factors encoun-
tered in normal driving can cause them to become unbalanced, which results
in steering vibration.
Unbalanced wheels should be rebalanced, as they otherwise cause excessive
wear on steering, suspension and tyres. A wheel must also be rebalanced
when a new tyre is fitted.
Incorrect wheel alignment
Incorrect wheel alignment causes excessive tyre wear, impairing the safety of
the vehicle. If tyres show excessive wear, you should have the wheel align-
ment checked by an Authorised Service Centre.
Fig. 133 Tyre tread wear
indicatorsFig. 134 Diagram for
changing wheels
IbizaST_EN.book Seite 205 Dienstag, 14. September 2010 1:31 13

If and when219
Safety First
Operating Instructions
Practical Tips
Technical Specifications
The individual electrical circuits are protected by fuses. The fuses are located
behind a cover at the left-hand end of the dash panel. When the steering
wheel is on the right, the fuses are on the right-hand side of the dash panel,
behind a cover.
The electric windows are protected by
circuit breakers. These reset automat-
ically after a few seconds when the overload (caused for example by frozen
windows) has been corrected.
Fuses colour code
WARNING
Never “repair” damaged fuses and never replace them with fuses with a
higher rating. Failure to comply could result in fire. This could also cause
damage to other parts of the electrical system.
Note
•If a newly replaced fuse blows again after a short time, the electrical
system must be checked by a specialised workshop as soon as possible.•If you replace a fuse with higher-rating fuse, you could cause damage to
another location in the electrical system.
•Always keep some spare fuses in the vehicle. These are available from
SEAT dealers.Fuses on left side of dash panelFuses
Colour
Amps
Beige
5
Brown
7.5
Red
10
Blue
15
Ye l l o w
20
Natural (white)
25
Green
30
Number
Consumer
Amps
1
Power steering/Engine operation
7.5
2
Diagnostics/Heater/Autoclimate/Cli-
matronic/Electric anti-dazzle mirror/Naviga-
tor/Air conditioning pressure switch/ Climate
fan/ Kisi/ AFS Control unit/Coming home
relay/Soundaktor
10
3
Petrol engine control unit/Flow meter/Diesel
engine control unit/Relay coils/Engine opera-
tion/Bi-turbo fuel control unit
5
4
ABS/ESP switch (turning sensor)/Light lever
10
5
Reverse light/Heating nozzles
10
6
Instrument panel
5
7
Rear fog light
7.5
8
Va can t
9
Headlight lever
10
10
Headlight lever/Clutch (Petrol)/Brakes (all)
5
11
Airbag control unit
5
12
Automatic gearbox/ Headlight lever
10
13
Exterior mirror control
5
IbizaST_EN.book Seite 219 Dienstag, 14. September 2010 1:31 13

If and when
220
14
Left-hand AFS headlights
15
15
Right-hand AFS headlights
15
16
Vaca n t
17
Number plate light /Dimmer /Side light indicator
light
5
18
Dimmer
5
19
Electronic control unit
5
20
Turn signals
15
21
Lights control/ Instrument panel
5
22
Electronic control unit/ Heated mirrors
5
23
Engine injection module/ Rain sensor/ Auto-
matic gear lever/ Starter relay
7.5
24
Glove compartment light/ Luggage compartment
light/ Interior light
10
25
Parking aid
5
26
Towing hook
27
Vaca n t
28
Lambda probe
10
29
Engine power supply
20
30
Petrol engine operation
10
31
Petrol engine operation/Glow plugs/Relay
coil/Bi-turbo electric fan
10
32
Engine control unit
15
33
Clutch switch power supply/ Preheating relay/
Servo sensor
5
Number
Consumer
Amps
34
Fuel control unit / Bi-turbo engine supply
15
35
12V power socket in luggage compartment
15
36
Main beam headlight, right
10
37
Main beam headlight, left/Coming Home
10
38
Electric fan motor
30
39
Vaca n t
15
40
12 Volt Input/Cigarette lighter
15
41
Heated seats control unit / Cup Holder
25
42
Horn
20
43
Panorama sunroof
30
44
Windscreen wipers
20
45
Heated rear window
30
46
Radio / VDA telephone / Bluetooth / Steering
wheel controls / DC/DC converter for Start/Stop
20
47
Climatronic/autoclimate
5
48
Locking unit
25
49
Front electric window
30
50
Rear electric windows
30
51
Automatic gearbox control unit
30
52
Alarm/Volume sensor
15
53
Electro-kinetic pump relay/bi-turbo fuel control
unit
15
54
Reverse light for automatic gearbox/ Fog light
15
55
Transformer on
15
Number
Consumer
Amps
IbizaST_EN.book Seite 220 Dienstag, 14. September 2010 1:31 13

If and when221
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Fuses below steering wheel in relay holderPTC fuses
AUX 1 Fuses
AUX 3 Fuses
Fuses in engine compartment above batteryNon-metal fuses
Some of the electrical items listed in the table are only fitted on certain
models or are optional extras.
Please note that the above list contains all data at the time of going to press,
so it is subject to modifications.
56
Rear window wiper
10
57
Dipped beam headlight (right side)
15
58
Dipped beam headlight (left side)
15
Number
Consumer
Amps
1
Supplementary electrical heating using air
40
2
Supplementary electrical heating using air
40
3
Supplementary electrical heating using air
40
Number
Consumer
Amps
1
Dipped headlight (left side)
15
2
Dipped headlight (right side)
15
3
Headlight washer pump
20
Number
Consumer
Amps
1
Trailer control unit
15
2
Trailer control unit
20
3
Trailer control unit
20
Number
Consumer
Amps
Number
Consumer
Amps
1
ABS unit
25
2
Electroblower climate heater/fan
30
3
Climate fan
5
4
ABS unit
10
5
Electronic control unit
5
6
Injection module
30
Fig. 142 Fuses in engine
compartment
IbizaST_EN.book Seite 221 Dienstag, 14. September 2010 1:31 13

If and when235
Safety First
Operating Instructions
Practical Tips
Technical Specifications
Do not pull too hard with the towing vehicle and take care to avoid jerking the
tow-rope. When towing on an unpaved road, there is always a risk of over-
loading and damaging the anchorage points.
The ignition of the vehicle being towed must be switched on to prevent the
steering wheel from locking and also to allow the use of the turn signals,
horn, windscreen wipers and washers.
As the brake servo does not work if the engine is not running, you must apply
considerably more pressure to the brake pedal than you normally would.
As the power assisted steering does not work if the engine is not running, you
will need more strength to steer than you normally would.
Towing vehicles with an automatic gearbox
•Put the selector lever into position “N”.•Do not drive faster than 50 km/h.•Do not tow further than 50 km.•If a breakdown vehicle is used, the vehicle must be towed with the front
wheels raised.Note
•Observe legal requirements when towing or tow-starting.•Switch on the hazard warning lights of both vehicles. However, observe
any regulations to the contrary.•For technical reasons, vehicles with an automatic gearbox must not be
tow-started.•If damage to your vehicle means that there is no lubricant in the gearbox,
you must raise the drive wheels while the vehicle is being towed.•If the vehicle has to be towed more than 50 km, the front wheels should
be raised during towing, and towing should be carried out by a qualified
person.
•The steering wheel is locked when the vehicle has no electrical power. The
vehicle must then be towed with the front wheels raised. Towing should be
carried out by a qualified person.•The towing eye should always be kept in the vehicle.To w i n g e y e sFitting the towing eye
– Take the towing ring from the on-board tool set.
– Remove the front cover by pressing down on its left-hand side. For FR finishes, press down and pull outwards.
– Bolt the eye to its limit to the left, in the direction of the arrow
⇒ fig. 165 .
Fig. 165 Fitting the
towing eye to front rear of
the vehicle
IbizaST_EN.book Seite 235 Dienstag, 14. September 2010 1:31 13

Index255
Dash panel cleaning . . . . . . . . . . . . . . . . . . . . . 179
Daytime running lights . . . . . . . . . . . . . . . . . . . . 93
Deactivating front passenger airbag
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Deactivating the airbag Front passenger airbag . . . . . . . . . . . . . . . . . 37
Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
Diesel engine Winter driving . . . . . . . . . . . . . . . . . . . . . . . . 187
Diesel engine particulate filter . . . . . . . . . . . . . 166
Differential lock . . . . . . . . . . . . . . . . . . . . . . . . . 162
Differential lock fault (EDL) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64
Digital clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Dipped beam headlights . . . . . . . . . . . . . . . . . . 91
Disposal Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Seat belt tensioners . . . . . . . . . . . . . . . . . . . 26
Door lock cylinders . . . . . . . . . . . . . . . . . . . . . . 176
Door release lever . . . . . . . . . . . . . . . . . . . . . . . . 49
Doors Childproof locks . . . . . . . . . . . . . . . . . . . . . . . 78
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 66
Drive wheels traction control system . . . . . . . . 160
Driver See Correct sitting position . . . . . . . . . . . . . . . 9
Driveshaft differential XDS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161 Driving
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 169
Economically / Environmentally friendly . . 167
With a trailer . . . . . . . . . . . . . . . . . . . . 169, 170
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . . . . 169 Headlights . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Driving safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Duplicate keys . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Dust filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Dynamic headlight range control . . . . . . . . . . . . 93
EEconomical driving . . . . . . . . . . . . . . . . . . . . . . 167
EDL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 63
Electro-hydraulic steering Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 67
Electronic differential lock . . . . . . . . . . . . . . . . 162 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 63
Electronic immobiliser . . . . . . . . . . . . . . . . . . . . 137
Electronic Stability Programme . . . . . . . . . 64, 161 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Electronic Stability Programme (ESP) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64
Emission control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 67
Engine Running in . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Engine compartment Working in the engine compartment . . . . . 188 Engine coolant . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Engine fault
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 62
Engine management Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 62
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191 Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . 194
Checking engine oil level . . . . . . . . . . . . . . 192
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . 192
Specifications . . . . . . . . . . . . . . . . . . . . . . . 191
Topping up . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Engine oil dipstick . . . . . . . . . . . . . . . . . . . . . . . 192
Engine oil pressure Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 62
Environment . . . . . . . . . . . . . . . . . . . . . . . . . . . . 167 Environmental friendliness . . . . . . . . . . . . . 168
Environmental tip Avoiding pollution . . . . . . . . . . . . . . . . . . . . 186
Environmentally friendly driving . . . . . . . . . . . . 167
ESP . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64, 161 See also Electronic Stability Programme . . 136
Exhaust gas purification system . . . . . . . . . . . 165
Exterior mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 175
External aerial . . . . . . . . . . . . . . . . . . . . . . . . . . 182
FFabric trim cleaning . . . . . . . . . . . . . . . . . . . . . . 179
Fastening rings . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Fire extinguisher . . . . . . . . . . . . . . . . . . . . . . . . 119
First-aid kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
IbizaST_EN.book Seite 255 Dienstag, 14. September 2010 1:31 13

Index259
Spare wheel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Speed selector lever lock
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 66
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Starting Petrol engines . . . . . . . . . . . . . . . . . . . 138
Starting petrol engines . . . . . . . . . . . . . . . . . . . 138
Starting the engine . . . . . . . . . . . . . . . . . . . . . . 138 After the fuel tank has been run dry . . . . . . 139
Start-Stop Function . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Switching on and off . . . . . . . . . . . . . . . . . . 141
Steam jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 174
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135 Steering lock . . . . . . . . . . . . . . . . . . . . . . . . 136
Steering column controls Audio Control . . . . . . . . . . . . . . . . . . . . . . . . . 70
Steering wheel height adjustment . . . . . . . . . . 135
Storage compartment . . . . . . . . . . . . . . . . . . . . 123 Front passenger side . . . . . . . . . . . . . . . . . . 112
front seat . . . . . . . . . . . . . . . . . . . . . . . . . . . 114
Sun visor Sliding/tilting sunroof . . . . . . . . . . . . . . . . . . 89
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Switch Hazard warning lights . . . . . . . . . . . . . . . . . . 96
Heated rear window . . . . . . . . . . . . . . . . . . . . 95
Light switch . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Switches Electric windows . . . . . . . . . . . . . . . . . . . . . . 86
Sliding/tilting sunroof . . . . . . . . . . . . . . . . . . 89
Switching off the engine . . . . . . . . . . . . . . . . . . 139
TTailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84 Emergency opening . . . . . . . . . . . . . . . . . . . . 85
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 67
Tank Fuel level . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Reserve indicator . . . . . . . . . . . . . . . . . . . . . . 52
Tank capacity . . . . . . . . . . . . . . . . . . . . . . . . . 52
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
TCS (Traction control system) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64
Technical modifications . . . . . . . . . . . . . . . . . . 181
The danger of not using the seat belt . . . . . . . . 20
Tightening torque of wheel bolts . . . . . . . . . . . 240
Tilting sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Top Tether system . . . . . . . . . . . . . . . . . . . . . . . . 45
Tow starting Comments . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Towing a trailer . . . . . . . . . . . . . . . . . . . . 169, 239
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . 170
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 183
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 235
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Traction control system Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64 Trailer turn signals
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 97
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 239
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97 Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 68
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 97
Two-way radio . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Tyre Mobility-System (Tyre repair kit) . . . . . . . . 211
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 204 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 65
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . 211, 216
Tyre-Mobility-System (Tyre repair kit) . . . . . . . . 216
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 206
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 205
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . . 205
Tyres with directional tread pattern . . . . . . . . . 204
UUnderbody protection . . . . . . . . . . . . . . . . . . . . 178VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . . 201
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238
Vehicle identification data . . . . . . . . . . . . . . . . 238
Vehicle identification number . . . . . . . . . . . . . 238
Vehicle interior heating or cooling system . . . 129
Vehicle modifications . . . . . . . . . . . . . . . . . . . . 181
IbizaST_EN.book Seite 259 Dienstag, 14. September 2010 1:31 13