2010 OPEL COMBO coolant level

73
Instruments
Picture no: 11688s.tif
Coolant temperature display
Coolant temperature gauge. For physical reasons, the engine
temperature gauge shows the coolant
temperature only if the coolant level is
adequate.
During operation the system is pressurised.
The temperature may therefore rise briefly
to over 100 C.
Picture no: 11689s.tif
Fuel gauge

Control indicator Y illuminates when the
level is low. Refuel immediately if the
control indicator begins to flash.
Never run the tank dry!
Because of the fuel remaining in the tank,
the amount of fuel required to fill the tank
may be less than the specified tank
capacity. Pointer in zone
at left= Engine operating
temperature not yet
reached
Pointer between
the zones= Normal operating
temperature
Pointer in right
zone (warning
zone)= Temperature too
high: Stop the
vehicle and switch
off the engine.
Danger to engine.
Check coolant level
immediately 3177.

165 Opel Service, maintenance
European service plan⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
302
603
904
1205
150
Visually inspect control, lighting and signal devices as well as airbags;
check steering column lock and ignition switchxxxxx
Remote control: replace batteries (don’t forget the spare key) every 2 years
Check and correct windscreen wipers, windscreen washer system and headlamp
washer systemxxxxx
Check and correct coolant level and frost protection (pale orange)
2)
Note freeze protection temperature in the Service and Warranty Booklet
(confirmation box)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xxxxx
Check water hoses for leaks and check to make sure they are firmly seated x x x x x
Check and correct brake fluid level
2) xxx
Check battery clamps to make sure they are firmly seated and check the battery eye x x x x x
Vehicle System Check with TECH 2 x x x x x
Replace pollen filter or active charcoal filter x x
⊕o
if the air is heavily polluted or there are high levels of airborne dust, sand or pollen,
the air-conditioning system will produce an odourVerbal arrangement between the
customer and Opel Partner
Replace the air filter element every 4 years/60,000 km
⊕
Replace spark plugsevery 4 years/60,000 km
Z 16 YNGevery 2 years/30,000 km
Visually inspect the ribbed V-belt every 2 years/60,000 km
⊕
Replace ribbed V-belt
Y 13 DTJ, Z 13 DTJ, Y 13 DT, Z 13 DT, Z 17 DTH every 10 years/150,000 km
⊕
Check valve play and adjust
Z16 XEP, Z 17 DTHevery 10 years/150,000 km

168 Opel Service, maintenanceInternational service plan⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
Visually inspect control, lighting and signal devices as well as airbags;
check steering column lock and ignition switchxxxxx
Remote control: replace batteries (don’t forget the spare key) every 2 years
Check and correct windscreen wipers, windscreen washer system and headlamp
washer systemxxxxx
Check and correct coolant level and frost protection (pale orange)
2)
Note freeze protection temperature in the Service and Warranty Booklet
(confirmation box)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xxxxx
Check water hoses for leaks and check to make sure they are firmly seated x x x x x
Check and correct brake fluid level
2) xxx
Check battery clamps to make sure they are firmly seated and check the battery eye x x x x x
Vehicle System Check with TECH 2 x x x x x
Replace pollen filter or active charcoal filter x x
⊕o
if the air is heavily polluted or there are high levels of airborne dust, sand or pollen,
the air-conditioning system will produce an odourVerbal arrangement between the
customer and Opel Partner
Replace the air filter element every 4 years/60,000 km
⊕
Replace spark plugsevery 4 years/60,000 km
Z 16 YNGevery 2 years/30,000 km
Visually inspect the ribbed V-belt every 2 years/60,000 km
⊕
Replace ribbed V-belt
Y 13 DTJ, Z 13 DTJ, Y 13 DT, Z 13 DT, Z 17 DTH every 10 years/150,000 km
⊕
Check valve play and adjust
Z16 XEP, Z 17 DTHevery 10 years/150,000 km

174 Opel Service, maintenanceGenuine Opel Parts and
Accessories We recommend that you use "Genuine
Opel Parts and Accessories" and
conversion parts approved expressly for
your vehicle type. These parts have
undergone special tests to establish their
reliability, safety and specific suitability for
Opel vehicles. Despite continuous market
monitoring, we cannot assess or guarantee
these attributes for other products, even if
they have been granted approval by the
relevant authorities or in some other form.
"Genuine Opel Parts and Accessories" and
conversion parts approved by Opel can be
obtained from your Opel Partner, who can
provide comprehensive advice on
permitted technical changes and ensure
correct installation.
Picture no: 17922s.tif
Performing work To avoid injury from moving parts and
cables conducting ignition voltage, only
carry out engine compartment checks
(e. g. checking brake fluid or engine oil
level) when the ignition is switched off.
Picture no: 11671s.tif
To aid identification, the caps used when
topping up engine oil, coolant and washer
fluid as well as the oil dipstick are coloured
yellow.
9 Warning
Only perform engine compartment
checks when the ignition is off.
The cooling fan may start operating
even if the ignition is off.
9 Warning
The ignition system 3 and Xenon
headlamps 3 use extremely high
voltage. Do not touch.

178 Opel Service, maintenance
Picture no: 13213s.tif
Coolant level
In a closed cooling system, there is hardly
any loss.
When the cooling system is cold, the level of
coolant should lie above the KALT/COLD
mark. Top up if the level is low. Top up with anti-freeze. If no anti-freeze is
available, fill with clean tap water or
distilled water. Have the anti-freeze
concentration checked.
Have the cause of coolant loss rectified by
a workshop.
Fit the cap on straight and tighten it.
Brakes A screeching noise indicates that the brake
lining is at its minimum thickness.
Continued driving is possible. Have the
brake lining replace as soon as possible.
Once new brake lining is fitted, do not
brake unnecessarily hard for the first
200 km.
9 Warning
Allow the engine to cool before opening
the cap. Carefully open the cap,
relieving the overpressure slowly.
Caution
Too low a coolant level can cause
engine damage.

181
Opel Service, maintenance
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage.
zWash and wax the vehicle 3161.
zHave the wax in the engine
compartment and underbody checked.
zClean and preserve rubber seals.
zChange engine oil.
zCheck anti-freeze and corrosion
protection 3177.
zCheck the coolant level; top up
anti-freeze if necessary 3178.
zDrain the windscreen washer system.
zIncrease tyre pressure to the value
specified for full load 3121, 3191. zPark the vehicle in dry and
well-ventilated place. With manual
transmission select first or reverse gear;
with manual transmission automated 3
move the selector lever to the centre
position before switching the ignition off.
Use chocks or the like to prevent the
vehicle from rolling.
zDo not apply hand brake.
zDisconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
zCheck tyre pressure 3121, 3191.
zTop up the windscreen washer system
3180.
zCheck engine oil level 3175.
zCheck coolant level 3178.
zFit the number plate if necessary.

199
Index
CCapacities .............................................. 195
Car Pass .................................................... 20
Caravan/trailer towing .................. 106, 125
Care ........................................................ 160
Catalytic converter ............... 114, 118, 129
Central locking system ...................... 23, 24
Centre console lighting ........................... 88
Changeover inhibitor ............................. 114
Changing the remote control battery .... 24
Changing tyre/wheel type ..................... 121
Changing wheels ................................... 137
Child restraint system .............................. 53
Child safety locks ..................................... 27
Cigarette lighter ....................................... 61
Clock ......................................................... 72
Clutch operation ............................ 105, 107
CO
2 emissions ........................................ 186
Coin holder ............................................... 65
Cold start ................................................ 107
Contrast .................................................... 81
Control indicator
ABS (Anti-lock Braking System) ........ 119
Airbag ................................................... 59
Engine electronics .............................. 116
Exhaust ............................................... 115
Immobiliser ........................................... 21
Control indicators .............................. 12, 66
Belt tensioners ...................................... 50
EPS (Electric Power Steering) .............. 70
Coolant ................................................... 177Coolant level .......................................... 178
Coolant temperature display ................. 73
Coolant thermometer .............................. 73
Correcting time ........................................ 80
Coupling socket load ............................ 126
Courtesy lamp ......................................... 88
Courtesy lamps
Bulb replacement ...................... 158, 159
DDashboard, see Instrument panel ........... 9
Data .................................................. 20, 182
Date .......................................................... 77
Daytime running lights ............................ 84
Decommissioning .................................. 181
Demisting and defrosting
Windows ............................................... 96
With the air conditioning system ........ 98
Diesel fuel filter ...................................... 177
Diesel fuel system .................................. 128
Diesel particle filter ............37, 68, 107, 116
Dimensions ............................................. 196
Dipped beam ............................................. 7
Bulb replacement ...................... 151, 155
Display .............................................. 76, 100
Display instruments ................................. 71
Display mode ........................................... 82
Door locks ........................................ 20, 162
Driving abroad .............................. 110, 164
Headlamps ........................................... 89
Driving hints ........................................... 106
EEasytronic ................................................ 15
Driving programmes ......................... 102
Fault ................................................... 104
Interruption of power supply ............ 105
Kickdown ............................................ 103
Selector lever ....................................... 15
Winter programme ............................ 103
Economical driving ................................ 108
Electric power steering .................... 70, 106
Towing ................................................ 131
Electric windows ...................................... 36
Electrical system .................... 145, 180, 195
Electronic components .......................... 180
Electronic immobiliser ............................. 21
Ellipsoidal headlamp system ................ 155
Engine code ........................................... 184
Engine control indicator ....................... 116
Engine oil ....................................... 172, 175
Additives ............................................ 172
Topping up ........................................ 172
Viscosity ............................................. 172
Engine oil consumption ........ 106, 175, 184
Engine oil level ....................................... 175
Engine speed ......................................... 107
Engine wash ................................... 162, 163
Environmental protection ..................... 160
EPS .................................................... 70, 106
Exhaust control indicator ..................... 115
Exhaust gases ........................................ 116
Exhaust system ...................................... 106
Exterior mirrors ........................ 5, 34, 35, 37