2010 HYUNDAI TUCSON steering

Maintenance
20
7
Brake hoses and lines
Visually check for proper installation,
chafing, cracks, deterioration and any
leakage. Replace any deteriorated or
damaged parts immediately.
Brake/Clutch* fluid
Check the brake fluid level in the brake
fluid reservoir. The level should be
between “MIN” and “MAX” marks on the
side of the reservoir. Use only hydraulic
brake fluid conforming to DOT 3 or DOT
4 specification.
* : if equipped
Parking brake
Inspect the parking brake system includ-
ing the parking brake pedal and cables.
Brake discs, pads, calipers and
rotors
Check the pads for excessive wear, discs
for run out and wear, and calipers for fluid
leakage.
Exhaust pipe and muffler
Visually inspect the exhaust pipes, muf-
fler and hangers for cracks, deterioration,
or damage. Start the engine and listen
carefully for any exhaust gas leakage.
Tighten connections or replace parts as
necessary.
Suspension mounting bolts
Check the suspension connections for
looseness or damage. Retighten to the
specified torque.
Steering gear box, linkage &
boots/lower arm ball joint
With the vehicle stopped and engine off,
check for excessive free-play in the
steering wheel.
Check the linkage for bends or damage.
Check the dust boots and ball joints for
deterioration, cracks, or damage.
Replace any damaged parts.
Drive shafts and boots
Check the drive shafts, boots and clamps
for cracks, deterioration, or damage.
Replace any damaged parts and, if nec-
essary, repack the grease.
Air conditioning refrigerant
Check the air conditioning lines and con-
nections for leakage and damage.
CAUTION
The use of a non-specified fluid
could result in transaxle malfunc-tion and failure.
Use only specified automatictransaxle fluid. (Refer to“Recommended lubricants andcapacities” in section 8.)

741
Maintenance
Tire replacement
If the tire is worn evenly, a tread wear
indicator will appear as a solid band
across the tread. This shows there is
less than 1/16 inch (1.6 mm) of tread
left on the tire. Replace the tire when
this happens.
Do not wait for the band to appear
across the entire tread before replac-
ing the tire.
OEN076053
Tread wear indicatorWARNING - Replacingtires
To reduce the chance or serious
or fatal injuries from an acci-
dent caused by tire failure or
loss of vehicle control:
Replace tires that are worn, show uneven wear, or are
damaged. Worn tires can
cause loss of braking effec-
tiveness, steering control, and
traction.
Do not drive your vehicle with too little or too much pressure
in your tires. This can lead to
uneven wear and tire failure.
When replacing tires, never mix radial and bias-ply tires
on the same car. You must
replace all tires (including the
spare) if moving from radial to
bias-ply tires.
(Continued)(Continued)
Using tires and wheel otherthan the recommended sizes
could cause unusual handling
characteristics and poor vehi-
cle control, resulting in a seri-
ous accident.
Wheels that do not meet HYUNDAI’s specifications may
fit poorly and result in damage
to the vehicle or unusual han-
dling and poor vehicle control.
The ABS works by comparing the speed of the wheels. Tire
size can affect wheel speed.
When replacing tires, all 4
tires must use the same size
originally supplied with the
vehicle. Using tires of a differ-
ent size can cause the ABS
(Anti-lock Brake System) and
ESC (Electronic Stability
Control) to work irregularly (if
equipped).

755
Maintenance
Instrument panel fuse panel
Description Fuse rating Protected component
AUDIO 1 10A Audio, A/V & Navigation Head Module
ROOM LP
(MEMORY FUSE) 10ABCM, Auto Light & Photo Sensor, Room Lamp, Driver/Passenger Vanity Lamp Switch,
Date Link Connector, Door warning Switch, RF Receiver, A/C Control Module, Luggage Lamp,
IPS Control Module, Instrument Cluster (IND.), Map Lamp, Electro Chromic Mirror
MODULE 2 10A IPS Control Module, BCM, Electro Chromic Mirror, PDM
START 10A Burglar Alarm Relay, E/R Fuse & Relay Box(Start Relay)
A/BAG IND 10A Instrument Cluster (Air Bag IND.)
CLUSTER 10A Audio, Console Switch, Instrument Cluster(IND.), BCM, Alternator, A/V & Navigation Head Module
MODULE 4 10A E/R Fuse & Relay Box(Blower Relay), Cluster Ionizer, A/C Control Module, Sunroof Motor
POWER OUTLET 2 25A Cigarette Lighter & Front Power Outlet, Rear Power Outlet
AUDIO 2 10A Power Outside Mirror Switch, AMP, BCM, PDM, A/V & Navigation Head Module, Audio
A/BAG 10A SRS Control Module, Passenger Occupant Detection Sensor
MODULE 1 10A IPS
Control Module, Tire Pressure Monitoring Module, EPS ControlModule, Steering Angle Sensor,
ESC OFF Switch, DBC Switch, ICM Relay Box(DBC Relay), Multifunction Switch(Light),
Stop Lamp Switch, AWD ECM
FOG LP RR 10A -
WIPER FRT 25A Front Wiper Motor, Multifunction Switch(Wiper), E/R Fuse & Relay Box(Front Wiper Relay)
S/HEATER FRT 15A Console Switch
POWER OUTLET 1 15A Cigarette Lighter & Front Power Outlet

771
Maintenance
Interior care
Interior general precautions
Prevent caustic solutions such as per-
fume and cosmetic oil from contacting
the dashboard because they may cause
damage or discoloration. If they do con-
tact the dashboard, wipe them off imme-
diately. See the instructions for the prop-
er way to clean vinyl.
Cleaning the upholstery and interiortrim
Vinyl
Remove dust and loose dirt from vinyl
with a whisk broom or vacuum cleaner.
Clean vinyl surfaces with a vinyl cleaner.
Fabric
Remove dust and loose dirt from fabric
with a whisk broom or vacuum cleaner.
Clean with a mild soap solution recom-
mended for upholstery or carpets.
Remove fresh spots immediately with a
fabric spot cleaner. If fresh spots do not
receive immediate attention, the fabric
can be stained and its color can be
affected. Also, its fire-resistant properties
can be reduced if the material is not
properly maintained.
Cleaning the lap/shoulder belt web-bing
Clean the belt webbing with any mild
soap solution recommended for cleaning
upholstery or carpet. Follow the instruc-
tions provided with the soap. Do not
bleach or re-dye the webbing because
this may weaken it.
Cleaning the interior window glass
If the interior glass surfaces of the vehi-
cle become fogged (that is, covered with
an oily, greasy or waxy film), they should
be cleaned with glass cleaner. Follow the
directions on the glass cleaner container.CAUTION
Never allow water or other liquids to come in contact with electrical/elec-tronic components inside the vehi-cle as this may damage them.
CAUTION
Using anything but recommended cleaners and procedures may affectthe fabric’s appearance and fire-resistant properties.
CAUTION
Do not scrape or scratch the inside of the rear window. This may resultin damage to the rear windowdefroster grid.CAUTION
When cleaning leather products (steering wheel, seats etc.), useneutral detergents or low alcoholcontent solutions. If you use high alcohol content solutions oracid/alkaline detergents, the color of the leather may fade or the sur-face may get stripped off.

Index
2I
Air bags··················\
··················\
··················\
··················\
··3-38Air bag warning label ··················\
··················\
··············3-63
Air bag warning light ··················\
··················\
··············3-41
Curtain air bag ··················\
··················\
··················\
·······3-55
Driver's and passenger's front air bag··········\
················3-49
Occupant classification system ··················\
·················3-44\
Side impact air bag ··················\
··················\
··················\
3-53
Air cleaner ··················\
··················\
··················\
···············7-28
Alarm system ··················\
··················\
··················\
·············4-7
All wheel drive (AWD)··················\
··················\
··············5-17
Antenna ··················\
··················\
··················\
··················\
··4-90
Anti-lock brake system (ABS) ··················\
··················\
··5-27
Appearance care··················\
··················\
··················\
·······7-66 Exterior care ··················\
··················\
··················\
··········7-66
Interior care ··················\
··················\
··················\
···········7-71
Armrest ··················\
··················\
··················\
··················\
··3-13
Ashtray ··················\
··················\
··················\
··················\
···4-83
Audio system ··················\
··················\
··················\
···········4-90 Antenna··················\
··················\
··················\
··················\
4-90
Steering wheel audio control ··················\
··················\
···4-90
Auto lock mode (Passenger seat belt) ··················\
·········3-33
Automatic climate control system ··················\
···············4-71 Air conditioning ··················\
··················\
··················\
····4-77
Automatic heating and air conditioning ··················\
····4-72
Manual heating and air conditioning··················\
·········4-73 Automatic transaxle ··················\
··················\
··················\
·5-10
Ignition key interlock system ··················\
··················\
··5-14
Shift lock system ··················\
··················\
··················\
···5-14
Sports mode ··················\
··················\
··················\
···········5-13
Battery··················\
··················\
··················\
··················\
····7-34
Battery saver function ··················\
··················\
················4-50
Before driving ··················\
··················\
··················\
············5-3
Bottle holders, see cup holders ··················\
··················\
··4-84
Brake system··················\
··················\
··················\
············5-24 Anti-lock brake system (ABS) ··················\
··················\
5-27
Electronic stability control (ESC) ··················\
·············5-30
Parking brake ··················\
··················\
··················\
·········5-25
Power brakes··················\
··················\
··················\
··········5-24
Brakes/clutch fluid ··················\
··················\
··················\
···7-25
Bulb replacement ··················\
··················\
··················\
·····7-59 Front fog light bulb replacement ··················\
···············7-61
Headlight bulb replacement··················\
··················\
·····7-60
High mounted stop light replacement ··················\
·······7-64
Interior light bulb replacement ··················\
··················\
7-65
License plate light bulb replacement··················\
·········7-64
Position light bulb replacement ··················\
·················7-61\
Rear combination light bulb replacement ··················\
·7-62
Side marker light bulb replacement ··················\
··········7-61
Side repeater light bulb replacement ··················\
·········7-62
Turn signal light bulb replacement··················\
············7-61
Bulb wattage ··················\
··················\
··················\
··············8-2
A
B

Index
4I
Digital clock··················\
··················\
··················\
·············4-86
Dimensions ··················\
··················\
··················\
················8-2
Displays, see instrument cluster ··················\
··················\
4-33
Display illumination, see instrument panel illumination···4-34
Door locks··················\
··················\
··················\
··················\
4-9
Central door lock switch ··················\
··················\
·········4-10
Child-protector rear door lock ··················\
··················\
·4-12
Drinks holders, see cup holders··················\
··················\
·4-84
Driver's air bag··················\
··················\
··················\
·········3-49
Driving at night ··················\
··················\
··················\
········5-43
Driving in flooded areas ··················\
··················\
············5-44
Driving in the rain··················\
··················\
··················\
····5-44
Economical operation ··················\
··················\
················5-40
Electric chromic mirror (ECM) ··················\
··················\
·4-30
Electronic power steering ··················\
··················\
·········4-28
Emergency starting ··················\
··················\
··················\
····6-4 Jump starting ··················\
··················\
··················\
···········6-4
Push starting ··················\
··················\
··················\
············6-5
Emergency tailgate safety release··················\
················4-14
Emergency towing ··················\
··················\
··················\
···6-21
Emergency while driving ··················\
··················\
·············6-2
Emission control system ··················\
··················\
············7-72 Crankcase emission control system··················\
···········7-72
Evaporative emission control (including ORVR) System ··················\
··················\
··················\
·················7-72\
Exhaust emission control system ··················\
··············7-73 Engine compartment ··················\
··················\
············2-4, 7-2
Engine coolant ··················\
··················\
··················\
·········7-22
Engine number ··················\
··················\
··················\
···········8-7
Engine oil ··················\
··················\
··················\
·················7-21\
Engine overheats ··················\
··················\
··················\
········6-6
Engine temperature gauge ··················\
··················\
·········4-35
Engine will not start··················\
··················\
··················\
···6-3
Evaporative emission control (including ORVR) System ··
7-72
Exhaust emission control system··················\
·················7-73\
Explanation of scheduled maintenance items ···············7-18
Exterior care··················\
··················\
··················\
·············7-66
Exterior features··················\
··················\
··················\
·······4-89 Roof rack ··················\
··················\
··················\
···············4-89
Flat tire ··················\
··················\
··················\
··················\
···6-12 Changing tires··················\
··················\
··················\
········6-13
Compact spare tire ··················\
··················\
··················\
·6-18
Jack and tools ··················\
··················\
··················\
········6-12
Removing and storing the spare tire···········\
·················6-13\
Floor mat anchor(s) ··················\
··················\
··················\
·4-86
Fluid Washer fluid··················\
··················\
··················\
···········7-26
Brakes/clutch fluid··················\
··················\
··················\
·7-25
Folding the rear seat ··················\
··················\
··················\
3-13
Four wheel drive (4WD), See all wheel drive (AWD) ··5-17
Front fog light bulb replacement ··················\
·················7-61\
Front seat adjustment - manual ··················\
··················\
···3-5
E
F

Index
8I
Seat belt - Driver's ··················\
··················\
··················\
·3-18
Seat belts - Front passenger and rear seat ··················\
·3-19
Seat belt warning ··················\
··················\
··················\
···3-17
Seat warmer ··················\
··················\
··················\
·············3-10
Seatback pocket ··················\
··················\
··················\
·······3-11
Seating capacity ··················\
··················\
··················\
·······5-57
Seats ··················\
··················\
··················\
··················\
·········3-2
Armrest ··················\
··················\
··················\
··················\
3-13
Headrest················\
··················\
··················\
············3-8, 3-12
Folding the rear seat ··················\
··················\
················3-13
Front seat adjustment - manual ··················\
··················\
·3-5
Front seat adjustment - power ··················\
··················\
···3-6
Lumbar support ··················\
··················\
··················\
·······3-7
Rear seat adjustment··················\
··················\
················3-12
Seatback pocket ··················\
··················\
··················\
·····3-11
Seat warmer ··················\
··················\
··················\
···········3-10
Shift lock system ··················\
··················\
··················\
·····5-14
Side impact air bag ··················\
··················\
··················\
··3-53
Side marker light bulb replacement ··················\
·············7-61
Side repeater light bulb replacement ··················\
···········7-62
Spare tire Compact spare tire ··················\
··················\
··················\
·6-18
Compact spare tire replacement ··················\
················7-42
Removing and storing the spare tire···········\
·················6-13\
Smooth cornering··················\
··················\
··················\
·····5-43
Snow tires ··················\
··················\
··················\
················7-48
Snow tires ··················\
··················\
··················\
················5-46
Special driving conditions ··················\
··················\
·········5-42 Driving at night ··················\
··················\
··················\
·····5-43 Driving in flooded areas ··················\
··················\
··········5-44
Driving in the rain ··················\
··················\
··················\
·5-44
Hazardous driving conditions ··················\
··················\
··5-42
Highway driving ··················\
··················\
··················\
····5-45
Rocking the vehicle ··················\
··················\
·················5-42\
Smooth cornering ··················\
··················\
··················\
··5-43
Speedometer··················\
··················\
··················\
·············4-34
Sports mode ··················\
··················\
··················\
·············5-13
Starting difficulties, see engine will not start ··················\
6-3
Starting the engine ··················\
··················\
··················\
·····5-6
Steering wheel ··················\
··················\
··················\
·········4-28 Horn ··················\
··················\
··················\
··················\
·····4-29
Electronic power steering ··················\
··················\
········4-28
Tilt steering ··················\
··················\
··················\
············4-28
Steering wheel audio control ··················\
··················\
·····4-90
Storage compartment ··················\
··················\
·················4-81\
Center console storage·············\
··················\
··················\
4-81
Glove box ··················\
··················\
··················\
··············4-81
Sunglass holder··················\
··················\
··················\
······4-82
Summer tires ··················\
··················\
··················\
············7-48
Sunglass holder ··················\
··················\
··················\
········4-82
Sunroof··················\
··················\
··················\
··················\
···4-24
Sunvisor ··················\
··················\
··················\
··················\
·4-84
Tachometer··················\
··················\
··················\
···············4-34
Tailgate··················\
··················\
··················\
··················\
···4-13
Emergency tailgate safety release ··················\
·············4-14
T

I9
Index
Tether anchor system ··················\
··················\
·················3-35\
Theft-alarm system ··················\
··················\
··················\
····4-7
Tie-down hook (for flatbed towing) ··················\
············6-24
Tilt steering ··················\
··················\
··················\
··············4-28
Tire and loading information label ··················\
··············5-57
Tires pressure monitoring system (TPMS)··················\
····6-7Changing a tire with TPMS··················\
··················\
·····6-10
Low tire pressure telltale ··················\
··················\
···········6-8
TPMS (Tire pressure monitoring system) malfunction indicator ··················\
··················\
··············6-9
Tire specification and pressure label ··················\
·············8-7
Tires and wheels ··················\
··················\
·················7-37\
, 8-3 All season tires ··················\
··················\
··················\
······7-48
Checking tire inflation pressure ··················\
················7-38
Compact spare tire replacement ··················\
················7-42
Radial-ply tires ··················\
··················\
··················\
······7-49
Recommended cold tire inflation pressures ················7-37
Snow tires ··················\
··················\
··················\
··············7-48
Summer tires··················\
··················\
··················\
··········7-48
Tire care ··················\
··················\
··················\
·················7-37\
Tire chains ··················\
··················\
··················\
·············7-49
Tire maintenance ··················\
··················\
··················\
···7-42
Tire replacement ··················\
··················\
··················\
····7-41
Tire rotation ··················\
··················\
··················\
···········7-39
Tire sidewall labeling ··················\
··················\
··············7-43
Tire terminology and definitions ··················\
···············7-46
Tire traction ··················\
··················\
··················\
···········7-42
Wheel alignment and tire balance ··················\
·············7-40
Wheel replacement ··················\
··················\
··················\
7-42 Towing ··················\
··················\
··················\
··················\
···6-20
Emergency towing ··················\
··················\
··················\
·6-21
Removable towing hook (rear) ··················\
··················\
6-21
Tie-down hook (for flatbed towing) ··················\
··········6-24
Towing capacity ··················\
··················\
··················\
·······5-57
Trailer towing··················\
··················\
··················\
···········5-50 Hitches ··················\
··················\
··················\
··················\
·5-51
Safety chains··················\
··················\
··················\
··········5-51
Trailer brakes ··················\
··················\
··················\
·········5-51
Weight of the trailer (tongue) ··················\
··················\
··5-56
Transaxle Automatic transaxle ··················\
··················\
·················5-10\
Manual transaxle ··················\
··················\
··················\
·····5-7
Tripmeter··················\
··················\
··················\
··················\
4-37
Trip computer ··················\
··················\
··················\
··········4-36
Turn signal light bulb replacement ··················\
··············7-61
Vehicle break-in process ··················\
··················\
··············1-5
Vehicle certification label ··················\
··················\
············8-6
Vehicle data collection and event data recorders·············1-6
Vehicle identification number (VIN) ··················\
·············8-6
Vehicle load limit ··················\
··················\
··················\
·····5-57 Cargo capacity ··················\
··················\
··················\
·······5-57
Certification label ··················\
··················\
··················\
··5-59
Seating capacity ··················\
··················\
··················\
·····5-57
Tire and loading information label ··················\
············5-57
Towing capacity··················\
··················\
··················\
·····5-57
Vehicle capacity weight ··················\
··················\
···········5-57
V