2010 HYUNDAI TUCSON climate control

717
Maintenance
MAINTENANCE UNDER SEVERE USAGE CONDITIONS
SEVERE DRIVING CONDITIONS
A - Repeatedly driving short distance of less than 5 miles (8 km) in normal tem-perature or less than 10 miles (16 km) in freezing temperature
B - Extensive engine idling or low speed driving for long distances
C - Driving on rough, dusty, muddy, unpaved, graveled or salt- spread roads
D - Driving in areas using salt or other corrosive materials or in very cold weather
E - Driving in sandy areas F - Driving in heavy traffic area over 90°F (32°C)
G - Driving on uphill, downhill, or mountain road
H - Towing a Trailer, or using a camper, or roof rack
I - Driving as a patrol car, taxi, other commercial use or vehicle towing
J - Driving over 106 mph (170 km/h)
K - Frequently driving in stop-and-go conditions
The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the chart
below for the appropriate maintenance intervals.
R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if neces\
sary
MAINTENANCE ITEMMAINTENANCE
OPERATIONMAINTENANCE INTERVALSDRIVING CONDITION
ENGINE OIL AND FILTERREVERY 3,750 MILES (6,000 KM) OR 6 MONTHSA, B, C, D, E, F, G, H, I, K
AIR CLEANER FILTERRMORE FREQUENTLYC, E
SPARK PLUGSRMORE FREQUENTLYB, H
AUTOMATIC TRANSAXLE FLUIDREVERY 60,000 MILES (96,000 KM) A, C, E, F, G, I
MANUAL TRANSAXLE FLUIDREVERY 75,000 MILES (120,000 KM) A, C, E, F, G, I
FRONT DISC BRAKE/PADS, CALIPERS AND ROTORSIMORE FREQUENTLYC, D, G, H
REAR DISC BRAKE/PADS, PARKING BRAKEIMORE FREQUENTLYC, D, G, H
STEERING GEAR BOX, LINKAGE & BOOTS/
LOWER ARM BALL JOINT, UPPER ARM BALL JOINTIMORE FREQUENTLYC, D, E, F, G, H, I
DRIVE SHAFTS AND BOOTSIEVERY 7,500 MILES (12,000 KM) OR 6 MONTHSC, D, E, F, G, H, I, J
TRANSFER CASE OIL (AWD) REVERY 75,000 MILES (120,000 KM)C, D, E, G, H, I, J
REAR AXLE OIL (AWD)REVERY 75,000 MILES (120,000 KM)C, D, E, G, H, I, J
CLIMATE CONTROL AIR FILTER
(FOR EVAPORATOR AND BLOWER UNIT)RMORE FREQUENTLYC, E
PROPELLER SHAFTIEVERY 7,500 MILES (12,000 KM) OR 6 MONTHSC, E

729
Maintenance
Filter inspection
The climate control air filter should be
replaced according to the Maintenance
Schedule. If the vehicle is operated in
severely air-polluted cities or on dusty
rough roads for a long period, it should
be inspected more frequently and
replaced earlier. When you replace the
climate control air filter, replace it per-
forming the following procedure, and be
careful to avoid damaging other compo-
nents.
Filter replacement
1. Open the glove box and remove thesupport rod (1).
CAUTION
Do not drive with the air cleaner removed; this will result in exces-sive engine wear.
When removing the air cleaner fil- ter, be careful that dust or dirtdoes not enter the air intake, ordamage may result.
Use a HYUNDAI genuine part. Use of non-genuine parts could dam-age the air flow sensor.
CLIMATE CONTROL AIR FILTER

OLM079015

Maintenance
30
7
2. With the glove box open, remove the
stoppers on both sides. 3. Remove the climate control air filter
case pulling out both sides of the
cover. 4. Replace the climate control air filter.
5. Reassemble in the reverse order of
disassembly.
✽ ✽NOTICE
When replacing the climate control air
filter install it properly. Otherwise, the
system may produce noise and the effec-
tiveness of the filter may be reduced.

OLM079016
OLM079017
OLM079018

Maintenance
36
7
Reset items
Items should be reset after the battery
has been discharged or the battery has
been disconnected.
Auto up/down window (See section 4)
Sunroof (See section 4)
Trip computer (See section 4)
Climate control system
(See section 4)
Clock (See section 4)
Audio (See section 4)(Continued)
Wear eye protection when check- ing the battery during charging.
Disconnect the battery charger in the following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery terminal.
3. Unhook the positive clamp from the positive battery terminal.
WARNING
Before performing maintenanceor recharging the battery, turn off
all accessories and stop the
engine.
The negative battery cable must be removed first and installed
last when the battery is discon-
nected.

Maintenance
44
7
Tire speed ratings
The chart below lists many of the dif-
ferent speed ratings currently being
used for passenger car tires. The
speed rating is part of the tire size
designation on the sidewall of the
tire. This symbol corresponds to that
tire's designed maximum safe oper-
ating speed.
3. Checking tire life (TIN : Tire
Identification Number)
Any tires that are over 6 years old,
based on the manufacturing date,
(including the spare tire) should be
replaced by new ones. You can find
the manufacturing date on the tire
sidewall (possibly on the inside of the
wheel), displaying the DOT Code.
The DOT Code is a series of num-
bers on a tire consisting of numbers
and English letters. The manufactur-
ing date is designated by the last four
digits (characters) of the DOT code.
DOT : XXXX XXXX OOOO
The front part of the DOT means a
plant code number, tire size and
tread pattern and the last four num-
bers indicate week and year manu-
factured.
For example:
DOT XXXX XXXX 1609 represents
that the tire was produced in the 16th
week of 2009.
4. Tire ply composition and material
The number of layers or plies of rub-
ber-coated fabric in the tire. Tire
manufacturers also must indicate the
materials in the tire, which include
steel, nylon, polyester, and others.
The letter "R" means radial ply con-
struction; the letter "D" means diago-
nal or bias ply construction; and the
letter "B" means belted-bias ply con-
struction.
S 112 mph (180 km/h)
T 118 mph (190 km/h)
H 130 mph (210 km/h) V 149 mph (240 km/h)Z Above 149 mph (240 km/h)
Maximum Speed
Speed
Rating
Symbol
WARNING - Tire age
Tires degrade over time, even
when they are not being used.
Regardless of the remaining
tread, it is recommended that
tires generally be replaced after
six (6) years of normal service.
Heat caused by hot climates or
frequent high loading condi-
tions can accelerate the aging
process. Failure to follow this
warning can result in sudden
tire failure, which could lead to
a loss of control and an acci-
dent involving serious injury or
death.

745
Maintenance
5. Maximum permissible inflationpressure
This number is the greatest amount
of air pressure that should be put in
the tire. Do not exceed the maximum
permissible inflation pressure. Refer
to the Tire and Loading Information
label for recommended inflation
pressure.
6. Maximum load rating
This number indicates the maximum
load in kilograms and pounds that
can be carried by the tire. When
replacing the tires on the vehicle,
always use a tire that has the same
load rating as the factory installed
tire.
7. Uniform tire quality grading
Quality grades can be found where
applicable on the tire sidewall
between tread shoulder and maxi-
mum section width.
For example:
TREAD wear 200
TRACTION AA
TEMPERATURE A
Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires
depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
due to variations in driving habits,
service practices and differences in
road characteristics and climate.
These grades are molded on the
side-walls of passenger vehicle tires. The tires available as standard or
optional equipment on your vehicle
may vary with respect to grade.
Traction - AA, A, B & C
The traction grades, from highest to
lowest, are AA, A, B and C. Those
grades represent the tire’s ability to
stop on wet pavement as measured
under controlled conditions on spec-
ified government test surfaces of
asphalt and concrete. A tire marked
C may have poor traction perform-
ance.
WARNING
The traction grade assigned to
this tire is based on straight-
ahead braking traction tests,
and does not include accelera-
tion, cornering, hydroplaning,
or peak traction characteristics.

Index
2I
Air bags··················\
··················\
··················\
··················\
··3-38Air bag warning label ··················\
··················\
··············3-63
Air bag warning light ··················\
··················\
··············3-41
Curtain air bag ··················\
··················\
··················\
·······3-55
Driver's and passenger's front air bag··········\
················3-49
Occupant classification system ··················\
·················3-44\
Side impact air bag ··················\
··················\
··················\
3-53
Air cleaner ··················\
··················\
··················\
···············7-28
Alarm system ··················\
··················\
··················\
·············4-7
All wheel drive (AWD)··················\
··················\
··············5-17
Antenna ··················\
··················\
··················\
··················\
··4-90
Anti-lock brake system (ABS) ··················\
··················\
··5-27
Appearance care··················\
··················\
··················\
·······7-66 Exterior care ··················\
··················\
··················\
··········7-66
Interior care ··················\
··················\
··················\
···········7-71
Armrest ··················\
··················\
··················\
··················\
··3-13
Ashtray ··················\
··················\
··················\
··················\
···4-83
Audio system ··················\
··················\
··················\
···········4-90 Antenna··················\
··················\
··················\
··················\
4-90
Steering wheel audio control ··················\
··················\
···4-90
Auto lock mode (Passenger seat belt) ··················\
·········3-33
Automatic climate control system ··················\
···············4-71 Air conditioning ··················\
··················\
··················\
····4-77
Automatic heating and air conditioning ··················\
····4-72
Manual heating and air conditioning··················\
·········4-73 Automatic transaxle ··················\
··················\
··················\
·5-10
Ignition key interlock system ··················\
··················\
··5-14
Shift lock system ··················\
··················\
··················\
···5-14
Sports mode ··················\
··················\
··················\
···········5-13
Battery··················\
··················\
··················\
··················\
····7-34
Battery saver function ··················\
··················\
················4-50
Before driving ··················\
··················\
··················\
············5-3
Bottle holders, see cup holders ··················\
··················\
··4-84
Brake system··················\
··················\
··················\
············5-24 Anti-lock brake system (ABS) ··················\
··················\
5-27
Electronic stability control (ESC) ··················\
·············5-30
Parking brake ··················\
··················\
··················\
·········5-25
Power brakes··················\
··················\
··················\
··········5-24
Brakes/clutch fluid ··················\
··················\
··················\
···7-25
Bulb replacement ··················\
··················\
··················\
·····7-59 Front fog light bulb replacement ··················\
···············7-61
Headlight bulb replacement··················\
··················\
·····7-60
High mounted stop light replacement ··················\
·······7-64
Interior light bulb replacement ··················\
··················\
7-65
License plate light bulb replacement··················\
·········7-64
Position light bulb replacement ··················\
·················7-61\
Rear combination light bulb replacement ··················\
·7-62
Side marker light bulb replacement ··················\
··········7-61
Side repeater light bulb replacement ··················\
·········7-62
Turn signal light bulb replacement··················\
············7-61
Bulb wattage ··················\
··················\
··················\
··············8-2
A
B

I3
Index
California Perchlorate Notice ··················\
··················\
····7-75
Capacities (Lubricants) ··················\
··················\
················8-4
Care Exterior care ··················\
··················\
··················\
··········7-66
Interior care ··················\
··················\
··················\
···········7-71
Tire care ··················\
··················\
··················\
·················7-37\
Cargo capacity ··················\
··················\
··················\
·········5-57
Cargo security screen··················\
··················\
·················4-87\
Cargo weight ··················\
··················\
··················\
············5-61
Center console storage ··················\
··················\
···············4-81
Central door lock switch··················\
··················\
············4-10
Certification label ··················\
··················\
··················\
····5-59
Changing a tire with TPMS ··················\
··················\
·······6-10
Changing tires ··················\
··················\
··················\
··········6-13
Chains Safety chains··················\
··················\
··················\
··········5-51
Tire chains ··················\
··················\
··················\
·············7-49
Tire chains ··················\
··················\
··················\
·············5-47
Checking tire inflation pressure··················\
··················\
·7-38
Child restraint system ··················\
··················\
················3-30 Auto lock mode (Passenger seat belt) ··················\
·······3-33
Tether anchor system ··················\
··················\
···············3-35
Lower anchor system··················\
··················\
···············3-36
Child-protector rear door lock ··················\
··················\
···4-12
Climate control system (Automatic) ··················\
···········4-71 Air conditioning ··················\
··················\
··················\
····4-77 Automatic heating and air conditioning ··················\
····4-72
Manual heating and air conditioning··················\
·········4-73
Climate control system (Manual) ··················\
···············4-62 Air conditioning ··················\
··················\
··················\
····4-67
Heating and air conditioning ··················\
··················\
···4-63
Cigarette lighter ··················\
··················\
··················\
·······4-83
Climate control air filter ··················\
··················\
············4-69
Climate control air filter ··················\
··················\
············7-29
Clock (Digital) ··················\
··················\
··················\
·········4-86
Combined instrument, see instrument cluster ···············4-33
Compact spare tire ··················\
··················\
··················\
···6-18
Compact spare tire replacement ··················\
··················\
7-42
Consumer information ··················\
··················\
·················8-8
Coolant ··················\
··················\
··················\
··················\
···7-22
Cooling fluid, see engine coolant ··················\
················7-22
Crankcase emission control system ··················\
·············7-72
Cruise control system ··················\
··················\
················5-36
Cup holder ··················\
··················\
··················\
···············4-84
Curtain air bag ··················\
··················\
··················\
·········3-55
Dashboard, see instrument cluster ··················\
···············4-33
Dashboard illumination, see instrument panel illumination ··················\
·············4-34
Defogging (Windshield) ··················\
··················\
············4-78
Defogging logic (Windshield) ··················\
··················\
···4-80
Defroster (Rear window) ··················\
··················\
···········4-60
Defrosting (Windshield) ··················\
··················\
············4-78
C
D