2010 FIAT LINEA RHD service

NOTE Carefully clean the cap of reservoir
Aand the surrounding surface.
When opening the cap,
make sure that no
dirt gets into the reservoir.
For topping up always use a
funnel with
built in filter (mesh smaller than or equal
to 0.12 mm).
IMPORTANT Brake fluid absorbs
mois-
ture. For this reason, if the car is mainlyused in areas with a high degree of at-
mospheric humidity, the fluid should be
replaced at more frequent intervals than
specified in the “Service schedule”.
fig. 7F0R0138m
Do not travel with the wind-
screen washing reservoir
empty: the windscreen washer is fun-
damental to improve visibility.
WARNING
Some commercial wind-
screen washer additives are
flammable. The engine compartment
contains
hot parts which could start
a fire if they come into contact.
WARNING
Prevent brake fluid which is
highly corrosive from coming
into contact with painted
parts. Wash with water im-
mediately if this should happen.
Brake fluid is poisonous and
highly corrosive. In the case
of accidental contact, wash the parts
with water and mild soap and rinse
with plenty of water. Call a doctor
immediately if swallowed.
WARNING
Symbol on the contain in-
dicates a synthetic brake flu-
id, which is different from a mineral
fluid. Use of a mineral type fluid will
damage the special rubber seals of
the braking system beyond repair.
WARNINGBRAKE FLUID fig. 7
Release cap A: check that the liquid con-
tained in the tank
is at the maximum level.
Fluid level in the reservoir must not ex-
ceed the MAXmark.
Use the brake fluid shown in the “Fluids
and lubricants” table (see “Technical Spec-
ifications”).
148
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
LINEA Owner HAND BOOK RHD.pdf 148LINEA Owner HAND BOOK RHD.pdf 1488/21/09 2:16:35 PM8/21/09 2:16:35 PM

Oil consumption is extremely
low; if another top-up should
be required after only a short
period of time, have the system checked
for leakage at a Fiat Dealership.
BATTERY
The car fits a low-maint enan ce batter y.
Under normal condition it does not need
frequent top ups with distelled water.
POWER STEERING FLUID fig. 8
Check that the oil level with the car on flat
ground and the engine cold is between the
MINand MAXline s on the reser voir
body. The level may go over the MAX
line when the oil is hot.
If topping up is required, make sure the oil
you used has the same specific ations as
that already in the system.
AIR CLEANER
Have the air cleaner replaced by a Fiat
Dealership. (Refer Service schedule)
POLLEN FILTER
Have the pollen filter replaced by a Fiat
Dealership.
Prevent power steering flu-
id from coming into contact
with hot engine par ts: the liquid is
flammable.
WARNING
fig. 8F0R0139m
149
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 149LINEA Owner HAND BOOK RHD.pdf 1498/21/09 2:16:35 PM8/21/09 2:16:35 PM

IMPORTANT Check the battery charge
once a year, preferably before the begin-
ning to winter, to prevent freezing of the
electrolyte. Perform this inspection more
frequently if the car is mainly used for
short distances or if electrical devices run-
ning with the key off are installed, partic-
ularly after-market. CHANGING THE BATTERY
If required, replace the battery with one
having the same specifications.
If a battery with different specifications is
fitte d, the service intervals given in the
“Service schedule” in this section will no
longer apply.
Follow the battery manufacturer’s in-
structions for maintenance.Incorrect assembly of electric
and electronic devices may
cause severe damage to your
car. Go to a Fiat Dealership
if you want to install accessories (al-
gge st the most su itabl e devi ces and
advise you if a higher capacity battery
needs to be installed.
Batteries contain very dan-
gerous substances for the en-
vi ronm ent . You are recom-
mended to go to a Fiat
Dealership to have the battery rep-
laced where the old battery will be dis-
posed of respecting both the environm-
ent and the laws in force.
If the car is left for long peri-
ods in very cold environ-
ments, remove the battery and store it
in a warm place to prevent freezing.
WARNING
Battery liquid is poisonous
and corrosive. Avoid contact
with the skin and eyes. Keep naked
flames and sources of sparks away
from the battery: risk of fire and ex-
plosion.
WARNING
Running the battery with an
excessively low liquid level
will damage the battery beyond re-
pair and even cause an explosion.
WARNING
150
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES
SPECIFICATIONS
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
DASHBOARD
SAFETY
TECHNICAL
arms, mobile phone, etc.): they will su-
LINEA Owner HAND BOOK RHD.pdf 150LINEA Owner HAND BOOK RHD.pdf 1508/21/09 2:16:35 PM8/21/09 2:16:35 PM

WINDSCREEN WIPER
BLADES
Period ically clean the rub ber part with
suitable products.
Replace the blades if the rubber edge is
deformed or worn. In all cas es, it is ad-
visable to replace them approximately
once a year.
A few simple precautions can reduce the
possibility of damage to the blades:
make sure that the rubber part is not
stuck to the windscreen at sub-zero
temperatures. Use an antifreeze prod-
uct to release it if required.
remove the snow from the window:
this will avoid overstressing the elec-
trical motor in addition to protecting
the blades;
do not operate the windscreen wipers
on dry glass.
Driving with worn wiper
blades is a serious hazard,
because visibility is reduced in bad
weather.
WARNING
RUBBER HOSES
Carefully follow the information contained
in the “Service schedule” in this section
for maintenance of brake system and fuel
feed rubber hoses.
Ozone, high temperatures and prolonged
lack of fluid in the system may cause hard-
ening and cracking of the hoses, with pos-
sible leaks. Careful inspections are there-
fore necessary.Excessively low pressure will
cause overheating of the
tyre and may cause severe tyre dam-
age.
WARNING
Do not exchange the tyres
from the left to the right of
the car and vice versa.
WARNING
Do not repaint alloy wheel
rims at temperatures higher
than 150°C. The mechanical features
of the wheels could be compromised.
WARNING
153
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
TECHNICAL
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
SPECIFICATIONS
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 153LINEA Owner HAND BOOK RHD.pdf 1538/21/09 2:16:35 PM8/21/09 2:16:35 PM

SUSPENSIONS
1.4 16v - 1.3 Multijet
Front
Rear
BRAKES
1.4 16v - 1.3 Multijet
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and salt sprinkled on the roads may deposit on the brake disks reducing braking efficiency
when the brakes are applied first time.
Telescopic
Hydraulic, Telescopic controlled by hand lever, operating on rear brakes
Steering wheel with jointed, energy absorbing column, Hydraulic power steering with rackdrum brakes with self centring shoes with one control cylinder per wheelventilated disk
STEERING
1.4 16v - 1.3 Multijet
Type
Steering diameter (m)
Steering box ratio (mm/turn) No. of steering wheel turn (lock to lock)
Rack track (mm)11.1
2.65
51
135
164
CORRECT USE
OF THE CAR
AND CONTROLS
DEVICES WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
CAR
MAINTENANCE
INDEX
TECHNICAL
SPECIFICATIONS
DASHBOARD
SAFETY
LINEA Owner HAND BOOK RHD.pdf 164LINEA Owner HAND BOOK RHD.pdf 1648/21/09 2:16:37 PM8/21/09 2:16:37 PM

According to
Service Schedule
According to
Service Schedule Synthetic base lubricants SAE 5W40 grade ACEA A3/B3/B4
Synthetic base lubricants SAE 5W40 grade ACEA A3/B3/B4 FIAT 9.55535-M2 or N2 qualification.
FIAT 9.55535-N2 qualificationSelenia K
Selenia WR
FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND SPECIFICATIONS
Use Fluid and lubricant specificationsGenuine fluids and Changing
for correct car operation lubricants frequency
Lubricants for
petrol engines
Lubricants for
diesel engines
Use of products with low-quality properties than ACEA A3/B3/B4 could cause damages to the engine that are not covered
by the warranty.
For very cold climate conditions, ask Fiat Dealership for the appropriate Selenia product to use.
173
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
INDEX
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY
AND CONTROLS
DEVICES
LINEA Owner HAND BOOK RHD.pdf 173LINEA Owner HAND BOOK RHD.pdf 1738/21/09 2:16:37 PM8/21/09 2:16:37 PM

II I
N N
D D
E E
X X
175
TECHNICAL
SPECIFICATIONS
CAR
MAINTENANCE
CORRECT USE
OF THE CAR
DASHBOARD
SAFETY
WARNING
LIGHTS AND
MESSAGES IN AN
EMERGENCY INDEX
AND CONTROLS
DEVICES
ABS system ....................................... 71
Accessories purchased
- by the owner ................................ 74
Additional heater .............................. 41
Air bag
- front ...............................................
87
Air cleaner ......................................... 149
Adjustable Air vents ......................... 38
Ashtray ................................................ 63
At the filling station ......................... 75
Automatic climate
- control system .............................
44
Battery
- checking the charge ....................149
- jump starting ................................
112
- recharging ..................................... 135
Bodywork
- maintenance ................................. 155

Bonnet ................................................
68Boot .................................................... 67
- extension ...................................... 68
- opening/closing the tailgate ...... 67
- emergency opening .................... 65
Boot light ........................................... 56
Brakes
- fluid level ....................................... 148
- technical data ............................... 164
Bulb (replacement)
- general instructions ....................
119
- types of bulbs ............................... 119
Capacities ......................................... 172
Car inactivity ..................................... 100
Car maintenance
- periodical checks ........................ 143
- scheduled servicing .................... 138
- service schedule ................. 139-142
- use of the car under
heavy conditions ..........................
143
Carrying children safely .................. 83
Ceiling lights ...................................... 54
- boot light ...................................... 56
- courtesy ........................................ 56
- front ............................................... 54
- rear ................................................ 54
Chassis (marking) ............................ 160
Checking fluid ................................... 144
Child lock .......................................... 65
Cigar lighter ...................................... 62
Code Card ........................................ 8
Consumption
- engine oil ...................................... 146
Controls ............................................. 57
Correct use of the car ....................
92
Courtesy lights ................................. 56
- bulb replacement ........................ 127
- control button ............................. 56
Current outlet .................................. 55
Dashboard ........................................ 5
- Right hand drive version .............. 5
Dashboard and controls ................. 4
Dead lock device .............................. 59
Digital display .................................... 16
LINEA Owner HAND BOOK RHD.pdf 175LINEA Owner HAND BOOK RHD.pdf 1758/21/09 2:16:38 PM8/21/09 2:16:38 PM