2010 CHRYSLER TOWN AND COUNTRY radiator cap

CAUTION!
Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads “H”, pull
over and stop the vehicle. Idle the vehicle with the air
conditioner turned off until the pointer drops back
into the normal range. If the pointer remains on the
“H”, turn the engine off immediately, and call for
service.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
JACKING AND TIRE CHANGING
WARNING!
•Getting under a jacked-up vehicle is dangerous.
The vehicle could slip off the jack and fall on you.
You could be crushed. Never get any part of your
body under a vehicle that is on a jack. If you need
to get under a raised vehicle, take it to a service
center where it can be raised on a lift.
•The jack is designed to use as a tool for changing
tires only. The jack should not be used to lift the
vehicle for service purposes. The vehicle should
be jacked on a firm level surface only. Avoid ice or
slippery areas.
•If it is necessary to retrieve the spare tire from
under the vehicle on the side of the vehicle close to
moving traffic. Pull far enough off the road to
avoid the danger of being hit.
6
WHAT TO DO IN EMERGENCIES 413

Cooling System
WARNING!
•When working near the radiator cooling fan, dis-
connect the fan motor lead or turn the ignition
switch to the OFF position. The fan is temperature
controlled and can start at anytime the ignition
switch is in the ON position.
•You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the
hood, do not open the hood until the radiator has
had time to cool. Never try to open a cooling
system pressure cap when the radiator is hot.
Coolant Checks
Check the engine coolant (antifreeze) protection every
12 months (before the onset of freezing weather, where
applicable). If the engine coolant (antifreeze) is dirty orrusty in appearance, the system should be drained,
flushed and refilled with fresh coolant. Check the front of
the A/C condenser for any accumulation of bugs, leaves,
etc. If dirty, clean by gently spraying water from a garden
hose vertically down the face of the condenser.
Check the coolant recovery bottle tubing for brittle rub-
ber, cracking, tears, cuts and tightness of the connection
at the bottle and radiator. Inspect the entire system for
leaks.
With the engine at normal operating temperature (but
not running), check the cooling system pressure cap for
proper vacuum sealing by draining a small amount of
engine coolant (antifreeze) from the radiator drain cock.
If the cap is sealing properly, the engine coolant (anti-
freeze) will begin to drain from the coolant recovery
bottle. DO NOT REMOVE THE COOLANT PRESSURE
CAP WHEN THE COOLING SYSTEM IS HOT.
7
MAINTAINING YOUR VEHICLE 453

NOTE:Mixing engine coolant (antifreeze) types will
decrease the life of the engine coolant (antifreeze) and
will require more frequent coolant changes.
Cooling System Pressure Cap
The cap must be fully tightened to prevent the loss of
engine coolant (antifreeze), and to ensure that engine
coolant (antifreeze) will return to the radiator from the
coolant recovery bottle.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
456 MAINTAINING YOUR VEHICLE

Disposal of Used Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine cold, the level of the engine coolant (antifreeze) in
the coolant recovery bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking forengine coolant (antifreeze) freeze point or replacing the
engine coolant (antifreeze). Advise your service atten-
dant of this. As long as the engine operating temperature
is satisfactory, the coolant bottle only needs to be checked
once a month.
When additional engine coolant (antifreeze) is needed to
maintain the proper level, it should be added to the
coolant bottle. Do not overfill.
Points to Remember
NOTE:
When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
7
MAINTAINING YOUR VEHICLE 457

Caps, FillerFuel ............................... 387
Oil (Engine) .......................... 443
Power Steering ........................ 342
Radiator (Coolant Pressure) ............... 456
Car Washes ............................ 465
Carbon Monoxide Warning ..............101,383
Cargo Compartment Luggage Carrier ....................... 222
Cargo (Vehicle Loading) ................... 214
Caution, Exhaust Gas ................... 51,383
Cellular Phone ....................... 125,302
Center High Mounted Stop Light ............ 484
Changing A Flat Tire ..................... 413
Chart, Tire Sizing ........................ 353
Check Engine Light
(Malfunction Indicator Light) .............240,438
Checking Your Vehicle For Safety ............ 101
Checks, Safety .......................... 101 Child Restraint
........................ 87,89
Child Restraint Tether Anchors ............... 93
Child Safety Locks ........................ 46
Child Seat .............................. 92
Clean Air Gasoline ....................... 379
Cleaning Wheels ............................. 466
Climate Control ......................... 303
Clock ........................ 263,265,268,278
Coat Hook ............................ 214
Coin Holder ........................... 215
Cold Weather Operation ................... 328
Compact Disc (CD) Maintenance ............. 302
Compact Spare Tire ...................... 364
Compass ........................ 247,250,256
Compass Calibration .................. 250,256
Compass Variance .................... 249,257
Computer, Trip/Travel .................... 254
520 INDEX

ConnectorUCI ................................ 289
Universal Consumer Interface (UCI) ......... 289
Console .............................. 215
Console, Floor .......................... 215
Console, Overhead ....................... 189
Console, Removable ...................... 219
Contract, Service ........................ 511
Coolant Pressure Cap (Radiator Cap) .......... 456
Cooling System ......................... 453
Adding Coolant (Antifreeze) .............. 455
Coolant Capacity ...................... 485
Coolant Level ...................... 453,457
Disposal of Used Coolant ................ 457
Drain, Flush, and Refill .................. 454
Inspection ........................... 457
Points to Remember .................... 457
Pressure Cap ......................... 456
Radiator Cap ......................... 456 Selection of Coolant (Antifreeze)
......454,485,486
Cruise Control (Speed Control) .............. 174
Cupholders ......................... 205,469
Customer Assistance ..................... 509
Daytime Running Lights ................... 164
Dealer Service .......................... 440
Defroster, Rear Window ................... 220
Defroster, Windshield ............103,305,306,316
Diagnostic System, Onboard ................ 437
Dimmer Control ........................ 161
Dipsticks Automatic Transaxle .................... 463
Automatic Transmission ................. 462
Oil (Engine) .......................... 441
Power Steering ........................ 342
Disabled Vehicle Towing ................... 431
Disposal Antifreeze (Engine Coolant) ............... 457
10
INDEX 521

PowerDoor Locks ........................... 32
Lift Gate ............................. 49
Mirrors ............................. 114
Outlet (Auxiliary Electrical Outlet) .......... 201
Seats ............................... 130
Sliding Door .......................... 42
Steering .......................... 341,342
Sunroof ............................. 198
Windows ............................. 36
Windows, Express Down ................. 22
Power Steering Fluid ..................... 487
Pregnant Women and Seat Belts .............. 67
Preparation for Jacking .................... 415
Pretensioners Seat Belts ............................ 61
Programmable Electronic Features ............ 258
Radial Ply Tires ......................... 364 Radiator Cap (Coolant Pressure Cap)
.......453,456
Radio Operation ........................ 302
Radio Remote Controls .................... 300
Radio, Satellite (Uconnect studios)........ 294,298
Rear Air Conditioning .................309,317
Rear Camera ........................... 186
Rear Cross Path ......................... 123
Rear Heater ............................ 309
Rear Park Sense System ................... 177
Rear Window Defroster ................... 220
Rearview Mirrors ........................ 112
Reclining Front Seats ..................... 128
Recreational Towing ................... 409,432
Reminder, Seat Belt ..................... 65,66
Remote Keyless Entry (RKE) ................. 19
Remote Sound System (Radio) Controls ........ 300
Remote Starting System .................... 27
Removable Floor Console .................. 219
Replacement Keys ........................ 15
530 INDEX