2010 CHRYSLER SEBRING engine overheat

NOTE:There are steps that you can take to slow down
an impending overheat condition:
•If your air conditioner (A/C) is on, turn it off. The A/C
system adds heat to the engine cooling system and
turning the A/C off can help remove this heat.
•You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
WARNING!
You or others can be badly burned by hot engine
coolant (antifreeze) or steam from your radiator. If
you see or hear steam coming from under the hood,
do not open the hood until the radiator has had time
to cool. Never try to open a cooling system pressure
cap when the radiator or coolant bottle is hot.
Engine Oil Overheating (2.4L Engine Only) —
If Equipped
During sustained high-speed driving or trailer tow up
long grades on a hot day, the engine oil temperature may
become too hot. If this happens, the “HOTOIL” message
flashes in the odometer and the vehicle speed will be
reduced to 53 mph (85 km/h) until the engine oil
temperature is reduced.
NOTE: The vehicle speed is reduced to a maximum of
53 mph (85 km/h). You may of course, reduce your
vehicle speed further if needed.
322 WHAT TO DO IN EMERGENCIES

front wheels. Then shift back and forth between RE-
VERSE and FIRST gear. Using minimal accelerator pedal
pressure to maintain the rocking motion, without spin-
ning the wheels, is most effective.
NOTE:If your vehicle is equipped with Electronic
Stability Control (ESC), turn the system to Partial OFF
before attempting to “rock” the vehicle. Refer to “Elec-
tronic Brake Control” in “Starting and Operating” for
further information.
CAUTION!
•When “rocking” a stuck vehicle by moving be-
tween 1st and REVERSE, do not spin the wheels
faster than 15 mph (24 km/h), or drivetrain damage
may result.
(Continued)
CAUTION! (Continued)
•Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure.
It can also damage the tires. Do not spin the
wheels above 30 mph (48 km/h) while in gear (no
transmission shifting occurring).
WARNING!
Fast spinning tires can be dangerous. Forces gener-
ated by excessive wheel speeds may cause damage, or
even failure, of the axle and tires. A tire could
explode and injure someone. Do not spin your vehi-
cle’s wheels faster than 30 mph (48 km/h) or for
longer than 30 seconds continuously without stop-
ping when you are stuck and do not let anyone near
a spinning wheel, no matter what the speed.
334 WHAT TO DO IN EMERGENCIES

WARNING!
•Exhaust gases can injure or kill. They contain
carbon monoxide (CO), which is colorless and
odorless. Breathing it can make you unconscious
and can eventually poison you. To avoid breathing
CO, refer to “Safety Tips/Exhaust Gas” in “Things
To Know Before Starting Your Vehicle” for further
information.
•A hot exhaust system can start a fire if you park
over materials that can burn. Such materials might
be grass or leaves coming into contact with your
exhaust system. Do not park or operate your ve-
hicle in areas where your exhaust system can
contact anything that can burn.
CAUTION!
•The catalytic converter requires the use of un-
leaded fuel only. Leaded gasoline will destroy the
effectiveness of the catalyst as an emissions con-
trol device and may seriously reduce engine per-
formance and cause serious damage to the engine.
•Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition.
In the event of engine malfunction, particularly
involving engine misfire or other apparent loss of
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
7
MAINTAINING YOUR VEHICLE 359

Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE:Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately. To minimize the possibility of catalytic converter dam-
age:
•Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
360 MAINTAINING YOUR VEHICLE

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add engine coolant (antifreeze)
when the engine is overheated. Do not loosen or
remove the cap to cool an overheated engine. Heat
causes pressure to build up in the cooling system.
To prevent scalding or injury, do not remove the
pressure cap while the system is hot or under
pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposalrules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol based
engine coolant (antifreeze) in open containers or allow it
to remain in puddles on the ground. If ingested by a child
or pet, seek emergency assistance immediately. Clean up
any ground spills immediately.
Coolant Level
Four-Cylinder Engines –
the coolant bottle provides a
quick visual method for determining that the engine
coolant (antifreeze) level is adequate. With the engine
idling and warm to normal operating temperature, the
level of the engine coolant (antifreeze) in the bottle
should be between the “ADD” and “FULL” lines, shown
on the bottle.
Six-Cylinder Engines – the level of the engine coolant
(antifreeze) in the pressurized coolant bottle should be
between the “COLD” and “FULL” range on the bottle
when the engine is cold.
364 MAINTAINING YOUR VEHICLE

Oil Selection....................... 349,392
Oil Synthetic ......................... 351
Overheating .......................... 321
Starting ............................. 238
Temperature Gauge .................... 145
Engine Oil Viscosity ...................... 350
Enhanced Accident Response Feature .......... 64
Entry System, Illuminated .................. 20
Ethanol ............................... 295
Exhaust Gas Caution ................... 81,298
Exhaust System ....................... 81,358
Extender, Seat Belt ........................ 52
Exterior Lights .......................... 84
Fabric Care ............................ 374
Filler Location Fuel .................... 145,303
Filters Air Cleaner .......................... 352
Air Conditioning .................... 230,355Automatic Transaxle
.................... 370
Engine Oil ........................ 351,393
Engine Oil Disposal .................... 351
Flashers .............................. 321
Hazard Warning ....................... 321
Turn Signal ........................... 84
Flash-To-Pass ........................... 108
Flexible Fuel Vehicles ..................... 299
Cruising Range ....................... 302
Engine Oil ........................... 302
Fuel Requirements .................. 299,301
Maintenance ....................... 299,303
Replacement Parts ..................... 303
Starting ............................. 302
Flooded Engine Starting ................... 239
Floor Console .......................... 135
Fluid Capacities ......................... 392
Fluid Leaks ............................. 84
10
INDEX 429

New Vehicle Break-In Period................ 79
Occupant Restraints ..................... 60,64
Occupant Restraints (Sedan) .........38,56,57,60,63
Octane Rating, Gasoline (Fuel) .............. 294
Odometer ............................. 149
Trip ............................. 149,152
Oil Change Indicator ................ 151,161,396
Oil Change Indicator, Reset ..............151,161
Oil, Engine ......................... 348,393
Capacity ............................ 392
Change Interval ............... 151,161,349,396
Checking ............................ 348
Dipstick ............................. 348
Disposal ............................ 351
Filter ............................ 351,393
Filter Disposal ........................ 351
Identification Logo ..................... 349
Materials Added to ..................... 351 Recommendation
................... 349,392
Synthetic ............................ 351
Viscosity ......................... 350,392
Oil Filter, Change ........................ 351
Oil Filter, Selection ....................... 351
Oil Pressure Light ....................... 147
Onboard Diagnostic System ..............344,345
Opener, Garage Door (HomeLink) ........... 120
Operator Manual (Owner’s Manual) ............ 4
Overdrive ............................. 246
Overheating, Engine ...................... 321
Owner’s Manual (Operator Manual) .........4,419
Paint Care ............................. 371
Panic Alarm ............................ 24
Parking Brake .......................... 254
Passing Light ........................... 108
Personal Settings ........................ 166
Pets .................................. 79
10
INDEX 435