2010 Acura TL Manual

The exhaust emissions controls
include f our systems: PGM-FI,
ignition timing control, exhaust gas
recirculation, and three way catalytic
converter. These f our systems work
together to control the engine’s
combustion and minimize the
amount of HC, CO, and NOx that
come out the tailpipe. The exhaust
emissions control systems are
separate f rom the crankcase and
evaporative emissions control
systems.The emissions control systems are
designed and certif ied to work
together in reducing emissions to
levels that comply with the Clean Air
Act. To make sure the emissions
remain low, you should use only new
Acura replacement parts or their
equivalent f or repairs. Using lower
qualitypartsmayincreasethe
emissions f rom your vehicle.
The emissions control systems are
covered by warranties separate from
the rest of your vehicle. Read your
warranty manual for more informa-
tion.
The PGM-FI system uses sequential
multiport f uel injection. It has three
subsystems: air intake, engine
control, and f uel control. The
powertrain control module (PCM) in
automatic transmission vehicles or
the engine control module (ECM) in
manual transmission vehicles uses
various sensors to determine how
much air is going into the engine. It then controls how much f uel to inject
under all operating conditions.
The three way catalytic converter is
in the exhaust system. Through
chemical reactions, it converts HC,
CO, and NOx in the engine’s exhaust
to carbon dioxide (CO ), nitrogen
(N ), and water vapor. The exhaust gas recirculation (EGR)
system takes some of the exhaust
gas and routes it back into the intake
manif old. Adding exhaust gas to the
air/f uel mixture reduces the amount
of NOx produced when the f uel is
burned. This system constantly adjusts the
ignition timing, reducing the amount
of HC, CO, and NOx produced.
2
2
Exhaust Emissions Controls Replacement Parts
PGM-FI System
Three Way Catalytic Converter
Exhaust Gas Recirculat ion (EGR)
Syst em
Ignit ion T iming Cont rol Syst em
Emissions Cont rols
588
09/07/29 18:42:14 31TK4610_593
2010 TL

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds.
If you take your vehicle f or an
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions. If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.
Make sure the vehicle has been
parked with the engine of f f or 6
hours or more.
Make sure the ambient
temperature is between 40° and
95°F (4° and 35°C). Keep the vehicle in Park
(automatic) or neutral (manual).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes).
Without touching the accelerator
pedal, let the engine idle f or 20
seconds.
1.
2.
3. 4.
5.
6.
T esting of Readiness Codes
Emissions T esting
590
09/07/29 18:42:34 31TK4610_595
2010 TL

Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing f acility determines the
readiness codes are still not set, see
your dealer. Make sure the vehicle has been
parked with the engine of f f or 30
minutes.
Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D (automatic) or 5th (manual). Do
notusethecruisecontrol.When
traffic allows, drive for 90 seconds
without moving the accelerator
pedal. (Vehicle speed may vary
slightly; this is okay.) If you cannot
do this f or a continuous 90
seconds because of traf f ic
conditions, drive f or at least 30
seconds, then repeat it two more
times (for a total of 90 seconds).
7.
8.
9.
Emissions T esting
Technical Inf ormation
591
09/07/29 18:42:40 31TK4610_596
2010 TL

..........
Client Service Inf ormation . 594
....................
Warranty Coverages .595
Reporting Saf ety Def ects ..........................
(U.S. Vehicles) .596
.....................
Authorized Manuals .597
Warranty and Client Relations
Warrant y and Client Relat ions
593
09/07/29 18:42:45 31TK4610_598
2010 TL

µ
µ µ
µ
µ µ
µ µ
µ
Your new Acura is covered by these
warranties:
covers your new vehicle, except f or
the battery, emissions control
systems, and accessories, against
def ects in materials and
workmanship.
these two
warranties cover your vehicle’s
emissions control systems. Time,
mileage, and coverage are
conditional. Please read your
warranty booklet f or exact
inf ormation. provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle. provides prorated
coverage f or a replacement battery
purchased f rom your dealer.
this warranty gives up
to 100% credit toward a replacement
battery. a seat
belt that f ails to f unction properly is
covered by a limited warranty.
Please read your warranty booklet
f or details.
covers all Acura
replacement parts against defects in
materials and workmanship. Acura accessories are covered under
this warranty. Time and mileage
limits depend on the type of
accessory and other f actors. Please
read your warranty manual f or
details. all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit. Restrictions and exclusions apply to
all these warranties. Please read the
2010 Acura Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your vehicle’s original
tires are covered by their
manuf acturer. Tire warranty
inf ormation is in a separate booklet.
Please ref er to the 2010 warranty
manual that came with your vehicle.
Warranty Coverages
U.S. Owners
Canadian Owners
New Vehicle L imit ed Warrant yEmissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty Replacement Muf f ler L if et ime
Limited Warranty
Replacement Bat t ery L imit ed
Warranty
Original Equipment Bat t ery L imit ed Warranty Seat Belt Limited Warranty
Replacement Part s L imit edWarranty
Accessory Limited Warranty
Rust Perf orat ion L imit ed Warrant y
Warrant y and Client Relat ions
595
09/07/29 18:43:10 31TK4610_600
2010 TL

T he publications shown below can be purchased f rom Helm
Incorporated. You can order by phone or online:Call Helm Inc. at 1-800-782-4356 (credit card orders only)
Go online at
If you are interested in other years or models, contact Helm Inc.
at 1-800-782-4356.
Covers maintenance and recommended procedures f or
repair to engine and chassis components. It is written
f or the journeyman mechanic, but it is simple enough
f or most mechanically inclined owners to understand.
Complements the Service Manual by providing in-depth
troubleshooting inf ormation f or each electrical circuit
in your vehicle.
Describes the procedures involved in the replacement
of damaged body parts.
Authorized Manuals
Purchasing Factory Authorized Manuals
(U.S. only) Service Manual:
Electrical T roubleshooting Manual:
Body Repair Manual:
Authorized Manuals
597
Publication
Form Number 61TK401
61TK401EL 61TK430
31TK4610
31TK4810
31TK4M10 31TK4Q10 ACU-R Form Description
2010 Acura TL Service Manual
2010 Acura TL Electrical Troubleshooting Manual
2009 Model Series Acura TL Body Repair Manual 2010 Acura TL Owner’s Manual
2010 Acura TL Navigation Manual
2010 Acura TL Maintenance Journal
2010 Acura TL Advanced Technology Guide Order Form for Previous Years-
Indicate Year and Model Desired
www. helminc. com
09/07/29 18:43:28 31TK4610_602
2010 TL

Î
CONT INUED
Doors.....
Lock Button, Outer Handle . 170
..........
Lockout Prevention . 147,171
.................
Monitor Indicator . 12,71
....................
Power Door Locks . 146
.
Unlock Sensor, Outer Handle . 169
........
DOT Tire Quality Grading . 581
Downshif ting, ..............
Manual Transmission . 465
....................
D-Paddle Shif t Mode .473
...........
Driver and Passenger Safety . 5
...........................................
Driving .459
....................................
Economy .450
Driving Position Memory ........................................
System .164
Dual Temperature and Mode .......................................
Control .222
..................
Dual and Pollen Filter . 532
...................................
Fan, Interior .220
..............................
Economy, Fuel .450
Electronic Stability Control ............................
(ESC) System .484
..................................
Emergencies .545
.............
Battery, Jump Starting . 555 ...........
Brake System Indicator . 561
................
Changing a Flat Tire . 547
.....
Charging System Indicator . 559
..................
Checking the Fuses . 563
.......
Hazard Warning Flashers . 139
.........
If the Engine Won’t Start . 552
......
If Your Vehicle Gets Stuck . 572
............................
Jump Starting .555
.....
Low Oil Pressure Indicator . 559
...
Malf unction Indicator Lamp . 560
Manually Opening Fuel Fill .......................................
Door .562
..................
Overheated Engine . 557
.......................................
Towing .570
.........................
Emergency Brake .204
..............
Emergency Engine Start . 464
....................
Emergency Flashers .139
......................
Emergency Towing .570
..........
Emergency Trunk Opener . 150
.......................
Emissions Controls .587
........................
Emissions Testing .590
Engine ............
Adding Engine Coolant . 512
....
Coolant Temperature Gauge . 76
.........................
If It Won’t Start .552 Malf unction Indicator
................................
Lamp .64, 560
.................................
Oil Lif e .84, 497
........
Oil Pressure Indicator . 64,559
..............
Oil, What Kind to Use . 509
...............................
Overheating .557
............................
Specif ications .579
....................
Speed Limiter . 466,471
.............
Start/Stop Button . 177,182
..............................
Starting .461, 463
Starting System .........................
Message .462, 464
......
Engine Compartment Covers . 508
..............................
Engine Coolant .512
............
Engine Start/Stop Button . 177
......................
Ethanol in Gasoline .445
.
Evaporative Emissions Controls . 587
...............................
Exhaust Fumes .57
Expectant Mothers, Use of Seat ........................................
Belts by .18
Index
F
EINDEX
III
09/07/29 18:43:50 31TK4610_606
2010 TL

...............................
Halogen Bulbs .526
......
HandsFreeLink
(HFL) . 388,406
............
Hazard Warning Flashers . 139
Hard Disc Drive (HDD), ........................................
Playing .308
.....................................
Headlights .133
........................................
Aiming .521
............
Automatic Lighting Off . 135
............
Automatic Lighting On . 134
.........
Daytime Running Lights . 136
..................
High Beam Indicator . 71
.......................
Reminder Beeps .133
........................
Replacing Bulbs .521
.................................
Turning on .133
............................
Head Restraints .156
.............................
Heated Mirrors .163
...................................
Heater, Seat .196
...............
High-Low Beam Switch . 133
.............................
Hill Start Assist .486
HomeLink
Universal ................................
Transceiver .385
........
Hood, Opening and Closing . 447
...........................................
Horn .4,130
...........................
Hydraulic Clutch .520
...............
Gas Mileage, Improving . 450
.........................................
Gasoline .444
...........................................
Gauge .75
.....................
Low Fuel Indicator .73
................
Octane Requirement . 444
........................
Tank, Ref ueling .445
................
Gas Station Procedures . 445
Gauges ...
Engine Coolant Temperature . 76
...............................................
Fuel .75
Gearshif t Lever Positions ..........
Automatic Transmission . 468
..............
Manual Transmission . 465
......................................
Glove Box .208
Gross Vehicle Weight Rating .....................................
(GVWR) .457
.........................................
Features .215
....................
Filling the Fuel Tank . 445
Filters .........................
Dust and Pollen .532
...............................................
Oil .510
...........
Flashers, Hazard Warning . 139
...................
Flat Tire, Changing a . 547
.....................................
Floor Mats .531
Fluids ..........
Automatic Transmission . 515
..........................................
Brake .519
.........................................
Clutch .520
..............
Manual Transmission . 517
................
Windshield Washers . 514
FM Stereo Radio ...................................
Reception .368
.....................................
Fog Lights .137
........................
Four-way Flashers .139
..............................
Front Airbags .9 ,26
....................................
Front Seats .155
....................................
Adjusting .155
.....................................
Airbags .9, 26
.......................................
Heaters .196
.................................................
Fuel .444
......................
Fill Door and Cap .445
...........................................
Gauge .75 .....................
Low Fuel Indicator .73
................
Octane Requirement . 444
...............................
Oxygenated .445
........................
Tank, Filling the .445
...............................
Fuel Economy .450
.....................
Fuses, Checking the .563
Index
H
G
IV
09/07/29 18:43:56 31TK4610_607
2010 TL