2009 TOYOTA TUNDRA power steering

477
4-3. Do-it-yourself maintenance
4
Maintenance and care
4.7 L V8 (2UZ-FE) engine
Washer fluid tank (
P. 492)
Engine oil level dipstick ( P. 479)
Engine coolant reservoir ( P. 484)
Engine oil filler cap ( P. 480)Brake fluid reservoir
( P. 486)
Fuse box ( P. 512)
Battery ( P. 489)
Radiator ( P. 486)
Condenser ( P. 486)
Power steering fluid reservoir ( P. 488)

478 4-3. Do-it-yourself maintenance
5.7 L V8 (3UR-FE, 3UR-FBE) engine
Washer fluid tank (P. 492)
Engine oil level dipstick ( P. 479)
Engine coolant reservoir ( P. 484)
Engine oil filler cap ( P. 481)Brake fluid reservoir
( P. 486)
Fuse box ( P. 512)
Battery ( P. 489)
Radiator ( P. 486)
Condenser ( P. 486)
Power steering fluid reservoir ( P. 488)

488 4-3. Do-it-yourself maintenance
Power steering fluid■ Fluid level
The fluid level should be within the appropriate range.
Full (when cold)
Add fluid (when cold)
Full (when hot)
Add fluid (when hot)
Hot: Vehicle has been driven around 50 mph (80 km/h) for 20 minutes, or slightly longer in frigid temperatures. (Fluid
temperature, 140°F - 175°F [60°C - 80°C])
Cold: Engine has not been run for about 5 hours. (Room tem- perature, 50°F - 85°F [10°C - 30°C])
■ Checking the fluid level
Make sure to check the fluid type and prepare the necessary items.
Clean all dirt off the reservoir.
Remove the cap by turning it counterclockwise.
Wipe the dipstick clean.
Reinstall and remove the reservoir cap again.
Check the fluid level.
Fluid type Automatic transmission fluid DEXRON® II or III
Items Rag or paper towel
CAUTION
■Checking the fluid level
Take care, as the reservoir may be hot.

489
4-3. Do-it-yourself maintenance
4
Maintenance and care
Battery
■ Battery exterior
Make sure that the battery terminals are not corroded and that
there are no loose connections, cracks, or loose clamps.
Te r m i n a l s
Hold-down clamp
■ Checking battery condition
Check the battery condition using the indicator color.
Type A
Blue: Good condition
White: Charging is necessary.
Have the vehicle inspected by
your Toyota dealer.
Red: Not working properly,
have the battery checked by
your Toyota dealer.
NOTICE
■When adding fluid
Avoid overfilling, or the power steering may be damaged.
■ After replacing the reservoir cap
Check the steering box case, vane pump and hose connections for leaks or
damage.

536 5-1. Essential information
Type BTowing eyelet
■Emergency towin g procedure
The engine switch must be in the ACC (engine off) or the ON
(engine running) position.
4WD models: Put the front wheel drive control switch in 2WD.
Put the shift lever in N.
Release the parking brake.
CAUTION
■ Caution while towing
●Use extreme caution when towing the vehicle.
Avoid sudden starts or erratic driving maneuvers which place excessive
stress on the emergency towing eyelet and the cables or chains.
● If the engine is not running, the power assist for the brakes and steering
will not function, making steering and braking more difficult.

614 6-1. Specifications
Brakes
*1: Minimum pedal clearance when depressed with a force of 110 lbf (490 N,50 kgf) with the engine running.
*2: Parking brake pedal travel when depressed with a force of 67.1 lbf (300 N,30.6 kgf).
Chassis lubrication
Steering
Pedal clearance *14.1 in. (104 mm) Min.
Pedal free play 0.04  0.20 in. (1  5 mm)
Brake pad wear limit 0.04 in. (1.0 mm)
Parking brake lining wear limit 0.04 in. (1.0 mm)
Parking brake pedal travel *26 — 9 clicks
Fluid type FMVSS No. 116 DOT 3 or SAE J1703
Propeller shafts Spider
Slide yokeLithium base chassis grease, NLGI No.2
Molybdenum — disulfide lithium base
chassis grease, NLGI No.2 or lithium
base chassis grease, NLGI No.2
Free playLess than 1.2 in. (30 mm)
Power steering fluid type
Automatic transmission fluid DEXRON® II
or III

627
6-1. Specifications
6
Vehicle specifications
Warning: The temperature grades for this tire are established for a
tire that is properly inflated and not overloaded.
Excessive speed, underinflation,
or excessive loading, either
separately or in combination, can cause heat buildup and possible
tire failure.
Glossary of tire terminology
Tire related termMeaning
Cold tire inflation
pressure
Tire pressure when the vehicle has been
parked for three hours or more, or has not
been driven more than 1 mile or 1.5 km under
that condition
Maximum inflation
pressureThe maximum cold inflated pressure to which a
tire may be inflated, s hown on the sidewall of
the tire
Recommended
inflation pressureCold tire inflation pressure recommended by a
manufacturer
Accessory weight
The combined weight (in excess of those
standard items which may be replaced) of
transmission, power steering, power brakes,
power windows, power seats, radio and heater,
to the extent that these items are available as
factory-installed equipment (whether installed
or not)
Curb weight
The weight of a motor vehicle with standard
equipment, including the maximum capacity of
fuel, oil and coolant, and if so equipped, air
conditioning and additional weight optional
engine
Maximum loaded
vehicle weight
The sum of:
(a) Curb weight
(b) Accessory weight
(c) Vehicle capacity weight
(d) Production options weight

656
Alphabetical index
Alphabetical index
A/C ..................................... 276, 285
ABS ........................................... 230
Accessory meter ...................... 204
Active traction control system .................................... 230
Air conditioning filter............... 507
Air conditioning system Air conditioning filter .............. 507
Automatic air conditioning system ................................ 276
Manual air conditioning system ................................ 285
Airbags
Airbag operating conditions............................ 118
Airbag precautions for your
child .................................... 123
Airbag warning light............... 546
Curtain shield airbag operating conditions............ 119
Curtain shield airbag precautions ......................... 125
Front passenger occupant classification system ........... 131
General airbag
precautions ......................... 122
Locations of airbags .............. 115
Modification and disposal of airbags ............................ 126
Passenger airbag off switch .......................... 127, 146
Proper driving posture ........................ 113, 122
Roll sensing of curtain shield airbag off switch .................. 129
Side airbag operating conditions............................ 119
Side airbag precautions ........ 124
SRS airbags .......................... 115
Alarm ......................................... 110
Antenna..................................... 304
Anti-lock brake system ABS warning light .................. 546 Anti-lock brake system .......... 230
Armrest ..................................... 444
Ashtray ..................................... 429
Audio input ............................... 325
Audio remote controls ............ 327
Audio system A/V input adapter .................. 350
Antenna................................. 304
Audio input ............................ 325
Audio visual input .................. 350
AUX adapter ......................... 325
CD player/changer ................ 307
DVD player............................ 336
MP3/WMA disc ..................... 314
Optimal use ........................... 323
Portable music player ........... 325
Radio..................................... 301
Rear seat entertainment system ................................ 329
Steering wheel audio switch.................................. 327
Type ...................................... 298
Audio visual input.................... 350
AUTO LSD system ................... 227
Automatic light control system .................................... 208
Automatic transmission Automatic transmission ......... 180
If the shift lever cannot be
shifted from P ..................... 577
TOW/HAUL switch ................ 183
AUX adapter ............................. 325
Auxiliary boxes ....................... 419
A/V input adapter ..................... 350
Back-up lights Replacing light bulbs ............. 528
Wattage................................. 617
Back window Back window ........................... 96
Power back window ................ 97
Back window defogger............ 295A
B