2009 SATURN VUE HYBRID engine coolant

Engine Overheating
There is a coolant temperature
warning light on your vehicle’s
instrument panel. SeeEngine
Coolant Temperature Warning Light
on page 3-29.
If Steam Is Coming From Your
Engine
{CAUTION
Steam from an overheated engine
can burn you badly, even if you
just open the hood. Stay away
from the engine if you see or hear
steam coming from it. Just turn it
off and get everyone away from
the vehicle until it cools down.
Wait until there is no sign of
steam or coolant before you
open the hood.
(Continued)
CAUTION (Continued)
If you keep driving when your
engine is overheated, the liquids
in it can catch re. You or others
could be badly burned. Stop your
engine if it overheats, and get
out of the vehicle until the engine
is cool.
Notice:If the engine catches re
because of being driven with
no coolant, your vehicle can be
badly damaged. The costly
repairs would not be covered by
the vehicle warranty.
If No Steam Is Coming From
Your Engine
If you get an engine overheat
warning, but see or hear no steam,
the problem may not be too serious.
Sometimes the engine can get a little
too hot when you:
Climb a long hill on a hot day.
Stop after high-speed driving.
Idle for long periods in traffic.
Tow a trailer.
If you get the overheat warning with
no sign of steam, try this for a
minute or so:
1. If you have an air conditioner
and it is on, turn it off.
2. Turn on your heater to full hot at
the highest fan speed and open
the windows as necessary.
3. Try to minimize engine load.
If you are in a traffic jam,
shift to N (Neutral); otherwise,
shift to the highest gear possible
while driving.
Service and Appearance Care 5-23
ProCarManuals.com

If you no longer have the overheat
warning, you can drive. Just to
be safe, drive slower for about
ten minutes. If the warning does
not come back on, you can drive
normally.
If the warning continues and you
have not stopped, pull over, stop,
and park your vehicle right away.
If there is still no sign of steam, idle
the engine for three minutes
while you are parked. If the warning
continues, turn off the engine and
get everyone out of the vehicle until
it cools down.
You may decide not to lift the hood
but to get service help right away.Windshield Washer Fluid
What to Use
When you need windshield or rear
window washer uid, be sure to
read the manufacturer’s instructions
before use. If you will be operating
your vehicle in an area where
the temperature may fall below
freezing, use a uid that has
sufficient protection against freezing.
Adding Windshield Washer
Fluid
Open the cap with the washer
symbol on it. Add washer uid until
the tank is full. SeeEngine
Compartment Overview on
page 5-10for reservoir location.Notice:
When using concentrated
washer uid, follow the
manufacturer’s instructions
for adding water.
Do not mix water with
ready-to-use washer uid.
Water can cause the solution
to freeze and damage your
washer uid tank and other
parts of the washer system.
Also, water does not clean as
well as washer uid.
Fill the washer uid tank only
three-quarters full when it is
very cold. This allows for uid
expansion if freezing occurs,
which could damage the tank if
it is completely full.
Do not use engine coolant
(antifreeze) in your windshield
washer. It can damage the
vehicle’s windshield washer
system and paint.
5-24 Service and Appearance Care
ProCarManuals.com

MaintenanceI—Use
Maintenance Iif the Change Engine
Oil light displays within 10 months
since the vehicle was purchased or
Maintenance IIwas performed. Maintenance
II—Use
Maintenance IIif the previous
service performed was
Maintenance I. Always use Maintenance
IIwhenever the light
displays 10 months or more since
the last service or if the light has not
come on at all for one year.
Scheduled Maintenance
Service MaintenanceIMaintenance II
Change engine oil and lter. See Engine Oil on page 5-11. Reset oil life
system. See Engine Oil Life System on page 5-14 .An Emission Control
Service. ••
Visually check for any leaks or damage. See footnote (j). ••
Inspect engine air cleaner lter. If necessary, replace lter. See Engine Air
Cleaner/Filter on page 5-15 .See footnote (l). •
Rotate tires and check ination pressures and wear. See Tire Inspection and
Rotation on page 5-50 and “Tire Wear Inspection” in At Least Once a Month
on page 6-9. ••
Inspect brake system. See footnote (a). ••
Check engine coolant and windshield washer uid levels and add uid as
needed. ••
Perform any needed additional services. See “Additional Required Services”
in this section. ••
Inspect suspension and steering components. See footnote (b). •
Inspect engine cooling system. See footnote (c). •
6-4 Maintenance Schedule
ProCarManuals.com

See Engine Coolant on page 5-20
for what to use. Inspect hoses. Clean
radiator, condenser, pressure cap,
and filler neck. Pressure test the
cooling system and pressure cap.
(j)A fluid loss in any vehicle system
could indicate a problem. Have
the system inspected and repaired
and the fluid level checked. Add
fluid if needed.
(k)Or every 12 months, whichever
occurs first. If driving regularly
under dusty conditions, the filter may
require replacement more often.
(l)If driving regularly under dusty
conditions, inspect the filter at each
engine oil change.
(m)Visually inspect belt for fraying,
excessive cracks, or obvious
damage. Replace belt if necessary.
(n)Vehicles using DOT-4 brake
fluid only: Drain, flush, and
refill brake hydraulic system at a
regular maintenance service (IorII)
every two years. This service can
be complex; you should haveyour dealer/retailer perform this
service. See Brakes on page 5-25
andRecommended Fluids and
Lubricants on page 6-11.
Owner Checks and
Services
These owner checks and services
should be performed at the intervals
specied to help ensure vehicle
safety, dependability, and emission
control performance. Your dealer/
retailer can assist with these checks
and services.
Be sure any necessary repairs are
completed at once. Whenever
any uids or lubricants are added to
the vehicle, make sure they are
the proper ones, as shown in
Recommended Fluids and
Lubricants on page 6-11.
At Each Fuel Fill
It is important to perform these
underhood checks at each fuel fill.
Engine Oil Level Check
Notice:It is important to check
the engine oil regularly and
keep it at the proper level. Failure
to keep the engine oil at the
proper level can cause damage to
the engine not covered by the
vehicle warranty.
Check the engine oil level and add
the proper oil if necessary. See
Engine Oil on page 5-11.
Engine Coolant Level Check
Check the engine coolant level
and add DEX-COOL®coolant
mixture if necessary. SeeEngine
Coolant on page 5-20.
6-8 Maintenance Schedule
ProCarManuals.com

Recommended Fluids and Lubricants
Fluids and lubricants identied below by name, part number, or specication can be obtained from your
dealer/retailer.
UsageFluid/Lubricant
Engine Oil Engine oil which meets GM Standard GM6094M and displays the
American Petroleum Institute Certied for Gasoline Engines starburst
symbol. To determine the proper viscosity for your vehicle’s engine, see
Engine Oil on page 5-11
.
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL
®
Coolant. See
Engine Coolant on page 5-20 .
Hydraulic Brake System Vehicles with DOT-3 brake uid only: Delco®Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Vehicles with DOT-4 brake uid only: DOT-4 Brake Fluid (GM Part
No. U.S. 88862828, in Canada 88862829).
Windshield Washer Optikleen
®Washer Solvent.
Parking Brake Cable Guides Chassis Lubricant (GM Part No. 12377985, in Canada 88901242) or
lubricant meeting requirements of NLGI #2, Category LB or GC-LB.
Automatic Transmission DEXRON
®-VI Automatic Transmission Fluid.
Key Lock Cylinders Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241,
in Canada 10953474).
Hood Latch Assembly, Secondary Latch, Pivots, Spring Anchor, and Release Pawl Lubriplate Lubricant Aerosol (Saturn Part No. 21038869 or GM Part No.
U.S. 12346293, in Canada 992723) or lubricant meeting requirements of
NLGI #2, Category LB or GC-LB.
Hood, Liftgate Door, and Rear Folding Seat Hinges Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241, in
Canada 10953474).
Maintenance Schedule 6-11
ProCarManuals.com

Child Restraints (cont.)
Securing a Child Restraint
in the Right Front Seat
Position.......................1-38
Where to Put the
Restraint......................1-29
Chime Level Adjustment........3-84
Cleaning
Aluminum Wheels.............5-72
Exterior Lamps/Lenses......5-70
Fabric/Carpet...................5-68
Finish Care......................5-70
Instrument Panel, Vinyl,
and Other Plastic
Surfaces......................5-69
Interior............................5-66
Leather...........................5-68
Tires...............................5-72
Underbody Maintenance....5-73
Washing Your Vehicle........5-69
Weatherstrips...................5-69
Windshield and Wiper
Blades.........................5-71
Climate Control System
Automatic........................3-17
Outlet Adjustment.............3-22
Clock, Setting......................3-56Collision Damage Repair......... 7-9
Compass............................3-40
Compressor Kit
Storing............................5-66
Compressor Kit, Tire
Sealant...........................5-59
Content Theft-Deterrent.........2-10
Control of a Vehicle............... 4-4
Convenience Net.................2-38
Coolant
Engine............................5-20
Engine Temperature
Warning Light...............3-29
Surge Tank
Pressure Cap...............5-22
Cooling System...................5-17
Cruise Control....................... 3-9
Cruise Control Light..............
3-33
Cupholders.........................2-37
Customer Assistance
Information
Courtesy Transportation....... 7-8
Customer Assistance for
Text Telephone (TTY)
Users............................ 7-4
Customer Assistance
Offices........................... 7-5
Customer Satisfaction
Procedure...................... 7-1Customer Assistance Information
(cont.)
GM Mobility
Reimbursement
Program........................ 7-5
Reporting Safety Defects to
Saturn.........................7-13
Reporting Safety Defects to
the Canadian
Government..................7-12
Reporting Safety Defects to
the United States
Government..................7-12
Roadside Assistance
Program........................ 7-5
Service Publications
Ordering Information......7-13
D
Daytime Running Lamp.........3-13
Defensive Driving................... 4-3
Delayed Locking.................... 2-6
DIC Compass......................3-40
Disc, MP3...........................3-66
Doing Your Own
Service Work..................... 5-4
Dome Lamp ........................3-14
INDEX i-3
ProCarManuals.com

Door
Automatic Door Lock.......... 2-7
Automatic Door Unlock........ 2-7
Delayed Locking................. 2-6
Locks............................... 2-6
Power Door Locks.............. 2-6
Rear Door Security Locks.... 2-7
Driver
Seat Height Adjuster........... 1-4
Driver Behavior..................... 4-2
Driver Information
Center (DIC)....................3-36
DIC Operation and
Displays.......................3-36
DIC Vehicle
Customization...............3-49
DIC Warnings and
Messages....................3-42
Driver Storage
Compartment...................2-38
Driving
At Night..........................4-12
Before a Long Trip............4-14
Defensive.......................... 4-3
Drunken............................ 4-4Driving (cont.)
Environment...................... 4-2
Highway Hypnosis............4-14
Hill and Mountain Roads....4-14
In Rain and on Wet
Roads.........................4-13
Rocking Your Vehicle to
Get it Out ....................4-17
Winter.............................4-15
Driving for Better Fuel
Economy........................... 4-3
E
EDR ..................................7-14
Electrical System
Add-On Equipment............5-75
Fuses and Circuit
Breakers......................5-75
Instrument Panel Fuse
Block...........................5-76
Power Windows and Other
Power Options..............5-75
Underhood Fuse Block......5-77
Windshield Wiper Fuses....5-75
Electronic Immobilizer
PASS-Key
®III+................2-12Electronic Immobilizer
Operation
PASS-Key
®III+................2-12
Engine
Air Cleaner/Filter...............5-15
Change Engine Oil Light....3-33
Check and Service Engine
Soon Lamp..................3-30
Coolant...........................5-20
Coolant Heater.................2-19
Coolant Temperature
Warning Light...............3-29
Drive Belt Routing.............6-13
Engine Compartment
Overview......................5-10
Exhaust...........................2-26
Oil ..................................5-11
Oil Life System.................5-14
Overheating.....................5-23
Starting...........................2-15
Entry Lighting......................3-14
Event Data Recorders..........7-14
Extender, Safety Belt............1-22
Exterior Lamps....................3-12
i-4 INDEX
ProCarManuals.com

F
Filter
Engine Air Cleaner............5-15
Finish Damage....................5-73
Fixed Mast Antenna.............3-84
Flashers, Hazard Warning....... 3-5
Flash-to-Pass........................ 3-7
Flat Tire..............................5-58
Fluid
Automatic Transmission.....5-17
Windshield Washer...........5-24
Folding Rear Seat................. 1-9
Folding Seatback,
Passenger......................... 1-7
Fuel..................................... 5-5
Additives........................... 5-5
California Fuel................... 5-5
Driving for Better
Economy....................... 4-3
Filling a Portable Fuel
Container....................... 5-8
Filling the Tank.................. 5-7
Fuels in Foreign Countries . . . 5-6
Gage ..............................3-34
Gasoline Octane................ 5-5
Gasoline Specications........ 5-5
Low Warning Light............3-34Fuel Economy Light.............3-35
Fuses
Fuses and Circuit
Breakers......................5-75
Instrument Panel Fuse
Block...........................5-76
Underhood Fuse Block......5-77
Windshield Wiper..............5-75
G
Gage
Fuel................................3-34
Speedometer...................3-24
Tachometer......................3-24
Gage, Charge/Assist.............3-35
Garage Door Opener............2-32
Gasoline
Octane............................. 5-5
Specications..................... 5-5
Glove Box...........................2-37
GM Mobility Reimbursement
Program............................ 7-5
H
Hazard Warning Flashers........ 3-5
Head Restraints..................... 1-2Headlamp
Aiming ............................5-33
Headlamps..........................5-35
Bulb Replacement.............5-35
Daytime Running Lamp.....3-13
Exterior Lamps.................3-12
Flash-to-Pass..................... 3-7
Front Turn Signal and
Parking Lamps..............5-36
Halogen Bulbs..................5-35
High/Low Beam Changer..... 3-7
Wiper Activated................3-12
Heated Seats........................ 1-5
Heater................................3-17
Engine Coolant.................2-19
Height Adjuster, Driver Seat.... 1-4
Highbeam On Light..............3-34
Highway Hypnosis................4-14
Hill and Mountain Roads.......4-14
Hood
Checking Things Under....... 5-9
Release............................ 5-9
Horn .................................... 3-5
How to Wear Safety Belts
Properly..........................1-13
INDEX i-5
ProCarManuals.com