2009 PORSCHE CAYMAN low beam

Practical Tips, Emergency Service
247
Bulb chart
Ty p e , r a t i n g
Halogen low beam H7, 55W
Halogen high beam H9, 65W
Low beam/high beam with Bi-Xen on headlights Philips, D2S 35W
Additional high beam with Bi-Xenon headlights H7, 55 W
Turn signal light, front Philips HY21W
Turn signal light, side WY5W
Fog light H8, 35W
License plate light C5W
Lights, Replacing Bulbs
Warning!
Risk of short circuit.
f Always switch off the relevant consumer when
changing bulbs.
Risk of serious personal injury or death.
The Bi-Xenon headlights are under high
voltage when installed.
f Be careful during all work in the area of the Bi-
Xenon headlights.
Risk of damage. Bulbs of a higher wattage
can damage the lamp housing.
f Only the bulbs shown in the chart may be used.
f New bulbs must be clean and free from oil,
grease and fingerprints. Therefore, never
touch bulbs with your bare hands.
Use a cloth or soft paper while replacing bulbs.

Practical Tips, Emergency Service
249
3. Place socket wrench (tool kit) on the unlocking spindle.
The handle of the wrench should point horizon-
tally to the rear.
4. Turn socket wrench approx. 180° A. The
headlight is unlocked and pushed forward
slightly during this process.
5. Turn socket wrench ba ck until it is pointing
vertically downward B and leave in position.
6. The headlight is now unlocked and can be pulled forward out of the fender.
Installing1. Insert headlight into the guide rails and push
fully into the fender.
2. Push headlight to the rear and at the same time turn the socket wrench until it points
horizontally to the rear C.
The headlight locking device must perceptibly
and audibly engage.
3. Insert the rubber plug into the unlocking opening and secure the carpet.
Check the function of all lights.
Low beam/high beam
Halogen/Bi-Xenon headlightOpening the lid of the headlight housing
1. Unscrew the 4 screws A .
2. First lift release tab B, then push both release
tabs C upwards and take off lid.

250
Practical Tips, Emergency Service
Changing bulb for low beam
Halogen headlights1. Pull off plug A.
2. Disengage fixing clip B.
3. Replace defective bulb. When doing so, ensure bulb is seated properly.
4. Reassemble in reverse order.
Closing the cover of the headlight housing
1. Push on cover until it is felt to engage.
2. Fasten cover with the 4 screws.
Changing bulb for high beam
Halogen headlights1. Turn housing cover counter-clockwise and take it off. 2. Turn bulb holder clockwise and remove it
(bayonet lock).
3. Pull both plug release tabs apart and pull plug out.
4. Replace the defective bulb with bulb holder.
5. Insert bulb holder and turn it as far as it will go to the left.
6. Close the housing cover.

Practical Tips, Emergency Service
251
Changing bulb for low beam/high beam
Bi-Xenon headlights1. Unscrew the 3 screws A on the control unit and
remove the control unit. 2. Turn the plug counter-clockwise and pu
ll it off. 3. Disengage both fixing clips.
4. Replace defective bulb.When doing so, ensure bulb is seated properly.
5. Engage both fixing clips, push on plug and turn right as far as the stop.
6. Fit control unit and screw tight.
Closing the cover of the headlight housing
1. Push on cover until it is felt to engage.
2. Fasten cover with the 4 screws.

Practical Tips, Emergency Service
257
Adjusting HeadlightsfPlease see the chapter “LIGHTS, REPLACING
BULBS” on Page 247.
Adjustment
The adjustment is made wi th the vehicle ready to
drive and the fuel tank completely filled.
The driver’s seat must be loaded by a person or a
165 lbs. (75 kg) weight and the tire pressures
must meet the prescribed values.
After being loaded, the car must be rolled a few
meters so that the suspension can settle.
For checking the headlight adjustment, the verti-
cal position of the cutoff of the lowbeam (see fig.)
has to be projected on a ve rtical screen (wall) in
distance of 24.6 ft. (7.5 m) from the front lens of
the headlamp.
The correct position of the cutoff is 2.0 in. (5 cm)
at 24.6 ft. or 7.5 m (0.4 °) below a horizontal line,
x cm from ground to the center of the headlamp
lens. Lateral adjustment of the
headlights should be
carried out at a specialist workshop with an optical
adjustment unit.
Distance
Visual aim shall be perf ormed at not less than
24.6 ft./7.5 m (this value is a rounded down con-
version from the 25-foot distance typical of field
aim using a screen). The 24.6 ft./7.5 m distance
is measured from the headlamp lens to the view-
ing screen.

Index
277
Stopping .............................................. 76
Engine compartment Blower ....................... .................. 76, 128
Blower fan .............. ............................ 128
Care .................................................. 205
Engine oil Change .............................................. 190
Consumption ............................... ......... 10
Performance class .. ............................ 191
Recommendation ........ ........................ 190
Topping off............. ............................ 189
Viscosity ................ ............................ 191
Exhaust Pipes ......................... ............................ 5
System ................................................ 55
Tailpipes, stainless st eel ...................... 207
External antenna ......... ................................ 104
FFiller flap .................................................... 195
Fire extinguisher ........................................... 85
Flat tire ...................... ................................ 229
Floor mats.................. ................................ 209
Fluids ......................................................... 201
FM reception .............................................. 101
Fog light ........................ .............................. 80
Fog light, rear................. ........................ 78, 80
Fog lights
Changing bulb......... ............................ 254
Footbrake ........................................... ......... 56
Footwell lights ............ .................................. 69
Fresh air intake ........... ................................ 116
Front lid ......................... ...................... 94, 100
Front luggage compartm ent .......................... 94 Fuel .....................
..............................130, 195
Containers ................ ......................4, 197
Economy .................. ..........................194
Evaporation control .............................197
Fuels containing etha nol.......................197
Level gage ............... ..........................130
Level warning light ..............................130
Recommendation ........................196, 197
Recommendations .... ..........................196
Tank ..................................................196
Function keys ........... ....................................40
Fuses, replacing ....... ..................................237
GGarage
Door ....................................................76
Door opener .......................................106
Lift ............... ......................... .............232
Gear display ................. ......................120, 122
Gear shift indicator ......................................127
Glove compartment... ....................................92
Gong.................... ..............14, 73, 78, 80, 137
Ground clearance...... ......................................4HHandbrake.................... ................................55
Hands-free microphone ...............................104
Head restraints ......... ....................................32
Headlights .................... ..............................248
Adjusting .................. ..................257, 258
Beam adjustment .. ................................79
Changing bulbs ......... ..................249, 251
Cleaning system ...................82, 200, 271 Flasher ................................................ 81
Removing ................
.......................... 248
Heated rear window ..................................... 31
Heated rear window/Door mirror heating ..... 117
Heater ......................... .............................. 113
Heating ........................................... .......... 110
High beam Indicator light ....... .............................. 127
Lever....................... ...................... 78, 80
High beam, additional Changing bulb ...... .............................. 251
High-pressure cleaning units........................ 203
Home mode..................... ...................... 79, 80
HomeLink .................... .............................. 106
Hoods ............................. .................... 94, 100
Horn ........................................... .......... 12, 21
Hot exhaust pipes ... ....................................... 5
IIgnition key ............. ..................................... 72
Emergency operation ........................... 74
Ignition lock ............ ..................................... 72
Withdrawing ignition key,
PDK transmission ..................... .......... 180
Immobilizer ...................................... ............ 15
Indicator lights ................. .................. 120, 122
INFO Warning message s ............................. 140
Instrument
Illumination........... .............................. 124
Lights ...................... ...................... 78, 80
Panel ........................... ...... 120, 122, 166
Interior ............................................ ............ 69
Interior lights .......... ..................................... 69
Interior mirror ......... ..................................... 30

278
Index
JJumper cables ............................................ 245KKey codes ...................... .............................. 15
Keys ................. ......................... ............ 15, 16LLATCH System ............... .............................. 53
Launch Control ........................................... 181
Leather care .............. ................................ 208
License plate light................................... 78, 80
Lids ............................................... 93, 94, 100
Emergency unlocking .......................... 238
Lifting vehicle ............. ................................ 232
Light
Daytime driving ....... .............................. 78
Flasher....................... ...... 78, 80, 81, 127
Low beam .................. .............. 78, 80, 81
Sensor for instrument illumination 120, 122
Switch........................ .............. 78, 80, 81
Light alloy wheels
Inscription .............. ............................ 223
Light functions, indivi dual............................... 81
Lights ................................................. ......... 69
Care .................................................. 208
Headlight beam adju stment ................... 79
LIMIT Acoustic warning signal for speed limit 137
Load switch-off ........... ................................ 236
Loading information .... ................................ 224
Locking.......................... ........................ 20, 23
Low beam ...................... .............................. 81
Luggage compartment ............................ 94, 96 Lid warning light........
...................... 93, 95
Lids ..................................................... 93
Unlocking lid ......... ................................ 16
Luggage compartment, warning lights ............ 93
Luggage cover ............. ................................ 99
Luggage net ................. ................................ 96
MMaintenance ................. .............................. 186
Make-up mirror ............. ................................ 41
Maximum permitted engi ne speeds ................ 10
Manual transmission ............................ 176
Microphone ....................................... ......... 104
Mirror Folding in.............. ................................ 30
Heating .................... .................... 31, 117
Inside ................................................... 29
Mirrors ............................. ...................... 29, 71
Anti-glare ................................... ........... 30
Multi-functional steeri ng wheel ........................ 40NNavigation .................... .............................. 101
Selection field, on-board computer ....... 150
Notes on Car care ................... .......................... 203
Maintenance ............. .......................... 186
Number plate light ........ .......................... 78, 80
Changing bulb ....... .............................. 256OOctane rating................ ...................... 196, 197
Odometer.......................................... ......... 125Off delay ....................
............................79, 80
Oil...................... ............................. ...188, 271
Change........................ .......................190
Checking level.......... ...........................161
Consumption............ .............................10
Level checks............ ...........................189
Level indicator ......... ...........................161
Recommendation ......... .......................190
Topping off engine oi l ..........................189
OIL Display and measurement
of the engine oil leve l...................................161
On-board computer ..... ................................134
Basic settings .......... ...................135, 163
Calling on-board computer functions .....135
Functions and display possibilities ........135
General information . ............................164
Language versions ... ...........................163
Operation, controls... ...........................134
Selecting a radio station ......................150
Setting the clock ...... ...........................164
Switching daytime driving lights on/off ..164
Switching on navigation .......................150
Tire pressure warnings ........................156
Warnings and messag es ......................166
On-board literature ..........................................2
Operating voice contro l ...............................134
Operating your Porsche in other Countries ....194
Orientation light ...... ......................................69
Outside temperatur indicator........................131
Oxygen sensor............ ................................199