2009 PORSCHE CAYMAN coolant level

Maintenance, Car Care
187
Coolant LevelfPlease see the chapter “EXERCISE EXTREME
CAUTION WHEN WORKING ON YOUR VEHICLE”
on Page 186.
The cooling system is filled at the factory with a
permanent coolant.
It provides year-round protection from corrosion
and freezing down to –31 °F/–35 °C .
f Only use antifreeze authorized by Porsche. Checking coolant level The expansion tank with its filler orifice is located
in the rear luggage comp artment under the serv-
ice flap.
f Check the coolant level regularly.
When the engine is cold and the car is level the
fluid level must lie between the “MIN” and “MAX”
markings.
Topping off coolant
Warning!
Danger of serious personal injury or death
from scalding. Coolant is hazardous to your
health, and may be fatal if swallowed.
f Do not open the cap of the expansion tank
while the engine is hot.
f Allow the engine to cool down before opening
the cap and protect your hands, arms and face
from any possible escape of hot coolant.
f Keep coolant out of children’s reach.
f Also, keep coolant away from your pets.
They can be attracted to it should there be a
spill, or to used coolant left in an open contai-
ner. Coolant can be deadly to pets if consu-
med.
Risk of damage from overflowing coolant.
f Take care while topping off coolant not to soil the luggage compartment or items of luggage.
1. Switch engine off and let it cool. Please see the chapter “COOLING SYSTEM” on
Page 88. 2. Press catch button on the service flap and
open flap.
3. Cover the expansion tank cap with a thick rag. Open cap slowly and ca refully and allow over-
pressure to escape.
Then unscrew cap completely.
4. Only add a mixture of antifreeze and water in
equal parts, and do not exceed the ”Max.“
mark.
Antifreeze in coolant:
50% gives protection down to –31 °F/–35 °C
60% gives protection down to –58 °F/–50 °C
5. Screw cap firmly on.
6. Close service flap.

188
Maintenance, Car Care
If in an emergency pure water has been added, the
mix ratio must be corrected at an authorized
Porsche dealer.
Marked loss of coolant in
dicates leakage in the
cooling system.
The cause should immediately be remedied at an
authorized Porsche dealer.
Engine-compartment blower,
radiator fan The radiator and radiator fans are in the front of
the car.
The engine-compartment bl ower is mounted in the
engine compartment.
Warning!
Risk of injury.
After the engine is switched off, the engine-
compartment temperature is monitored for
approx. 30 minutes.
During this period, and depending on tem-
perature, the engine-compartment blower
may continue to run or start to run.
f Carry out work in these areas only with the en-
gine off, the ignition off, and exercise extreme
caution.
Risk of injury. The radiator fans in the front
end of the car may be operating or
unexpectedly start operating when the
engine is switched on.
f Carry out work in these areas only with the en-gine switched off.
Engine Oil It is important to perform oil changes regularly in
accordance with the intervals specified in the
“Maintenance” booklet.
Engine oil consumption
It is normal for your engine to consume oil.
The rate of oil consumptio n depends on the quality
and viscosity of oil, the speed at which the engine
is operated, the climate, road conditions as well
as the amount of dilution and oxidation of the
lubricant.
If the vehicle is used for repeated short trips, and
consumes a normal amount of oil, the engine oil
measurement may not show any drop in the oil
level at all, even after 600 miles (1,000 km) or
more. This is because the oil is gradually becom-
ing diluted with fuel or moisture, making it appear
that the oil level has not changed.
The diluting ingredients evaporate out when the
vehicle is driven at high speeds, as on an express-
way, making it then appear that oil is excessively
consumed after driving at high speeds.
If the conditions you drive your vehicle in are
dusty, humid, or hot, the frequency of the oil
change intervals should be greater.

212
Practical Tips, Emergency Service
Exercise Extreme Caution when
Working on your Vehicle
Danger!
Ignoring the following instructions may
cause serious personal injury or death.
f The engine compartment of any motor vehicle
is a potentially hazardou s area. If you are not
fully familiar with proper repair procedures, do
not attempt the adjustments described on the
following pages.
This caution also applies to the entire vehicle.
f O n l y w o r k o n y o u r v e h i c l e o u t d o o r s o r i n a w e l l
ventilated area.
f Ensure that there are no open flames in the
area of your vehicle at any time when fuel
fumes might be present. Be especially cau-
tious of such devices such as hot water heat-
ers which ignite a flame intermittently.
f Before working on any part in the engine com-
partment, turn the engine off and let it cool
down sufficiently. Hot engine compartment
components can burn skin on contact.
f Be alert and cautious around engine at all
times while the engine is running.
If work has to be performed with the engine
running, always set the parking brake, and
make sure the shift lever is in neutral position
or the PDK selector lever in position P or N. f
In particular, be very careful to ensure that
items of clothing (ties, shirt, sleeves etc.),
jewelry, long hair, hand or fingers cannot get
caught in the engine-compartment blower, fan,
belts or other moving parts.
The radiator and radiator fans are in the front
of the car.
The engine-compartment blower is mounted in
the engine-compartment.
The fans can start or continue running as a
function of temperature, even with the engine
switched off.
Carry out work in these areas only with the en-
gine off, the ignition switched off, and exercise
extreme caution.
f Your Porsche is equipped with an electronic ig-
nition system. When the ig nition is on, high volt-
age is present in all wires connected with the
ignition system; therefore, exercise extreme
caution when working on any part of the engine
while the ignition is on or the engine is running.
f Always support your car with safety stands if it
is necessary to work under the car.
Jacks are not suitable for this kind of work.
f When working under the car without safety
stands but with the wheels on the ground,
make sure the car is on level ground, the
wheels are blocked, and that the engine
cannot be started.
Remove the ignition key. f
Do not smoke or allow an open flame around
the battery or fuel.
Keep a fire extinguisher in close reach.
f Incomplete or improper servicing may cause
problems in the operation of the car. If in doubt
about any servicing, have it done by your au-
thorized Porsche dealer.
Improper maintenance during the warranty pe-
riod may affect your Porsche warranty cover-
age.
f Supplies of fluids, e.g. engine oil, brake fluid or
coolant, are hazardous to your health.
Keep these fluids out of children’s reach and
dispose of them in accordance with the appro-
priate regulations.
f Some countries require additional tools and
special spare parts to be carried.
Please make enquiries before driving abroad.

276
Index
CCapacities, overview ................................... 271
Car care ........................ ............................ 203
Car telephone ............. ................................ 103
Car washes .................... ............................ 204
Cargo partition ........... .................................. 97
Carpet ....................................................... 209
Catalytic converters .... ................................ 199
Cautions ........................ .................... 186, 212
Central locking ........... ................................ 236
Emergency operation ...................... 19, 22
In cars with alarm system ...................... 21
In cars without alar m system ................. 19
Overload protection ............................ 236
Central vents .............. ................................ 116
Central warning light ................................... 132
Changing light-emitting diodes (LEDs) ........... 256
Changing wheels ........ ................................ 227
Check engine Warning light .......... ............................ 132
Check engine warning li ght .......................... 133
Opening the oil filler cap ...................... 189
Checking pressure ...... ................................ 228
Child restraint anchor age .............................. 54
Child restraint system s.................................. 50
Chime ............... ......................... ............ 78, 80
CHRONO Stopwatch.... ................................ 144
Cigarette lighter.......... .................................. 90
Circulating-air button ... ........................ 110, 114
Clock ............................................. .... 131, 164
Clutch ............... ............................. ...... 60, 176
Clutch pedal ............... .................................. 60
Combination filter ....... ................................ 201
Comfort seat .............. .................................. 33 Coming home mode ......
.......................... 79, 80
Communication manage ment ....................... 101
Compact disc
Player ...................... .......................... 102
Storage .................... ............................ 92
Compartment monitoring ................ ............... 25
Coolant ........... ........................... 128, 187, 271
Checking ............................................ 187
Level .................................................. 187
Temperature gage .... ..........................1

28
Topping off ........... .............................. 187
Warning light......... .............................. 128
Cooling system ............. ...................... 128, 187
Warning light......... .............................. 128
Cornering light .......... .................................... 78
Indicator light ........ .............................. 127
Crankcase ventilation .................................. 199
Cruise control ................................. 86, 87, 132
Cupholder ......................................... ........... 88
DData bank................................................... 264
Daytime driving lights .................................... 78
Changing bulbs ..... .............................. 256
On-board computer ............................. 164
Defrosting windows ....... ................ 31, 110, 114
Diagnostic socket ..... .................................... 11
Dimensions ....................................... ......... 272
Direction indicator lig ht, front ....................... 256
Door ............................ ................................ 18
Handles ................................................ 18
Locks....................... .................... 18, 205
Mirror....................... ............................ 30
Mirror heating ....... ................................ 31 Mirrors ....................
.............................29
Windows ...................... ...........18, 27, 206
Drive-Off Assistant ....... ................................177
Driving Hints .............. ........................................8
Winter ......................... .......................183
Driving off Drive-Off Assistant .... ...........................177
Launch Control......... ...........................181
Driving performance .... ................................270
Drop-center rim........... ................................223
EElectrical system..... ....................................235
Emergency flasher swit ch ..............................77
Emergency operation . ...................................22
Central locking ......... .......................19, 22
Ignition key ......... ..................................74
Lids................ ......................... ...........238
Tank flap ................. ...........................195
Emergency service ..... ................................212
Emergency starting with jumper cables.245, 246
Emission control system ..............133, 198, 199
Engine Checking the oil leve l ...........................161
Diagram ...................... .......................273
Exhaust ................... ...............................5
Number ..............................................265
Oil consumption ....... .....................10, 188
Oil level ................... ...........................189
Oil level indicator ...................... ...........161
Oils ............................................188, 271
Speeds.................... .............................10
Starting ................................................75