2009 PORSCHE CAYMAN clutch

Shifting Gears
175
Shifting Gears
Manual Transmission, Clutch ...................... 176
Drive-Off Assistant ...
................................... 177
Porsche Doppelkupplung (PDK) ................... 178

176
Shifting Gears
Manual Transmission, ClutchThe positions of the gears are shown on the shift
diagram on the gearshift lever.
Warning!
Risk of accident, resulting in serious person-
al injury or death.
f Do not obstruct the pedal travel with floor mats
or other objects.
Nonskid floor mats of the correct size are
available at your authorized Porsche dealer. To avoid damage to the clutch and transmis-
sion:
f
Always depress the clutch pedal fully when
changing gears. Make sure that the gearshift
lever is completely engaged.
f Only shift into reverse when the car has come
to a complete stop.
f When shifting gears, always ensure that the
clutch pedal is fully depressed and the gear
has fully engaged.
f Select reverse only when vehicle is stationary.
Reverse gear can be enga ged after shifting the
gearshift lever as far as possible to the left.
f Select an appropriately low gear on upward
and downward slopes.
This will ensure optimum use of engine power
and engine braking.
When reverse gear is sele cted and the ignition is
on, the backup lights are illuminated.
Permitted engine speedf You should change into a higher gear before
the needle reaches the red mark on the
tachometer, or ease off the accelerator.
If the red zone is reached during acceleration, fuel
feed is interrupted.
Caution!
Risk of engine damage (overrevving) when
shifting down to a lower gear.
f Take care not to exceed the maximum permitted engine speed when shifting down.

Shifting Gears
177
Drive-Off AssistantThe Drive-Off Assistant assists the driver when
moving off on hills.
The vehicle must have sufficient road contact.
The Drive-Off Assistant is available on gradients as
from around 5%.
Danger!
Risk of accident.
Assistance by the Drive-Off Assistant is not
guaranteed when moving off on a slippery
surface (e.g. on icy or loose surfaces). In this
case, the vehicle could slip.
The limits dictated by the laws of physics
cannot be overcome, even with the Drive-Off
Assistant. The responsi bility for moving off
on upward slopes is still the driver’s, despite
the Drive-Off Assistant.
f Always adjust your driving style to the driving
conditions and vehicle load, use the brake
pedal if necessary.
Risk of accident.
If the Drive-Off Assistant is not functioning,
the driver cannot be assisted when moving
off on hills.
f Hold the vehicle with the brake pedal. Driving off with the Drive-Off Assistant
(vehicles with manual transmission)
1. Hold the vehicle secure
ly on the slope with the
brake pedal.
The engine must be running.
2. Fully depress the clutch pedal.
3. Engage a gear corresponding to the direction of travel up the slope (1st gear or reverse
gear).
4. Fully release the parking brake.
5. While keeping the clutch pedal depressed, release the brake pedal.
The vehicle is held on the slope for a short time
in order to allow driving off directly after the
brake is released.
6. Move off as usual.
Note on operation
The Drive-Off Assistant is not active:
– If the clutch is not depressed.
– If the vehicle is not stationary.
– If the engine is not running.
– On gradients of less than 5%.
– If the pressure on the brake pedal is too low. Driving off with the Drive-Off Assistant
(vehicles with PDK transmission)
1. Hold the vehicle securely on the slope with the
brake pedal.
The engine must be running.
2. Select a gear corresponding to the direction of travel up the slope (selector lever position
Dor R).
3. Fully release the parking brake.
4. Release the brake pedal. The vehicle is held on the slope for a short time
in order to allow driving off directly after the
brake is released.
5. Move off as usual.
Note on operation
The Drive-Off Assistant is not active:
– In the event of shift to neutral.
– If the vehicle is not stationary.
– If the engine is not running.
– On gradients of less than 5%.
– If the pressure on the brake pedal is too low.

192
Maintenance, Car Care
Brake Fluid LevelfPlease see the chapter “EXERCISE EXTREME
CAUTION WHEN WORKING ON YOUR VEHICLE”
on Page 186.
f Use only new (unused) Original Porsche
brake fluid.
Warning!
Brake fluid is hazardous to your health, and
may be fatal if swallowed.
Brake fluid also attacks paintwork.
f Keep brake fluid out of children’s reach.
f Take care while topping off brake fluid not to
soil the luggage compartment or items of lug-gage.
Checking the brake fluid levelThe reservoir for the hydraulic braking and clutch
systems is located in the luggage compartment.
1. Open and remove cover flap A.
2. Regularly check the brake-fluid level on the transparent expansion tank through the
window B.
The fluid level should always lie between the
minimum and maximum marks. A slight decrease in the fluid level due to wear and
automatic readjustment of
the disc brakes is
normal.
If, however, the fluid level falls markedly or below
the minimum mark, the br aking system may have
developed a leak.
f Have the brake system checked without delay
at an authorized Porsche dealer.

Technical Data
271
Capacities Use only fluids and fuels authorized by Porsche. Your authorized Porsche dealer will gladly advise you.
Your Porsche has been designed so that it is not necessary to mix any additives with oils or fuels.
Engine Oil change quantity with oil filter approx. 1.98 U.S.gallons/7.5 liters
Please see the chapter “ENGINE OIL RECOMMENDATION” on Page 190.
Coolant Cayman: approx. 6.05 - 6.18 U.S. gallons/22.9 - 23.4 liters
Cayman S: approx. 6.13 - 6.61 U.S. gallons/23.3 - 25 liters
Manual transmission and differential Cayman: approx. 0.79 U.S. gallons/3 liters
Cayman S: approx. 0.85 U.S. gallons/3.2 liters
Porsche Doppelkupplung
Gear set approx. 0.78 U.S. gallons/2.95 liters
Porsche Doppelkupplung
Clutch/Hydraulic fluid approx. 1.37 U.S. gallons/5.2 liters
Power steering approx. 1.1 quarts/1 liter hydraulic fluid Pentosin CHF 11 S
® or CHF 202 S
®
Brake fluidapprox. 0.4 quarts/0.39 liters; use
only Original Porsche brake fluid
Windshield washer approx. 0.66 U.S. gallons/2.5 liters without headlight washer
approx. 1.58 U.S. gallons/6 liters with headlight washer
Fuel tank Refill volume approx. 16.9 U.S. gallons/64 liters, including approx. 2.6 U.S.gallons/10 liters reserve.
Fuel quality Your engine is designed to provide optimum performance and fuel economy using unleaded premium fuel with
an octane rating of 98 RON (93 CLC or AKI).
Porsche therefore recommends the use of these fuels in your vehicle.
Porsche also recognizes that these fuels may not always be available. Be assured tha t your vehicle will operate
properly on unleaded premium fuels with octane numbers of at least 95 RON (90 CLC or AKI), since the engine’s
”Electronic Octane™ knock control“ will adapt the ignition timing, if necessary.

276
Index
CCapacities, overview ................................... 271
Car care ........................ ............................ 203
Car telephone ............. ................................ 103
Car washes .................... ............................ 204
Cargo partition ........... .................................. 97
Carpet ....................................................... 209
Catalytic converters .... ................................ 199
Cautions ........................ .................... 186, 212
Central locking ........... ................................ 236
Emergency operation ...................... 19, 22
In cars with alarm system ...................... 21
In cars without alar m system ................. 19
Overload protection ............................ 236
Central vents .............. ................................ 116
Central warning light ................................... 132
Changing light-emitting diodes (LEDs) ........... 256
Changing wheels ........ ................................ 227
Check engine Warning light .......... ............................ 132
Check engine warning li ght .......................... 133
Opening the oil filler cap ...................... 189
Checking pressure ...... ................................ 228
Child restraint anchor age .............................. 54
Child restraint system s.................................. 50
Chime ............... ......................... ............ 78, 80
CHRONO Stopwatch.... ................................ 144
Cigarette lighter.......... .................................. 90
Circulating-air button ... ........................ 110, 114
Clock ............................................. .... 131, 164
Clutch ............... ............................. ...... 60, 176
Clutch pedal ............... .................................. 60
Combination filter ....... ................................ 201
Comfort seat .............. .................................. 33 Coming home mode ......
.......................... 79, 80
Communication manage ment ....................... 101
Compact disc
Player ...................... .......................... 102
Storage .................... ............................ 92
Compartment monitoring ................ ............... 25
Coolant ........... ........................... 128, 187, 271
Checking ............................................ 187
Level .................................................. 187
Temperature gage .... ..........................1

28
Topping off ........... .............................. 187
Warning light......... .............................. 128
Cooling system ............. ...................... 128, 187
Warning light......... .............................. 128
Cornering light .......... .................................... 78
Indicator light ........ .............................. 127
Crankcase ventilation .................................. 199
Cruise control ................................. 86, 87, 132
Cupholder ......................................... ........... 88
DData bank................................................... 264
Daytime driving lights .................................... 78
Changing bulbs ..... .............................. 256
On-board computer ............................. 164
Defrosting windows ....... ................ 31, 110, 114
Diagnostic socket ..... .................................... 11
Dimensions ....................................... ......... 272
Direction indicator lig ht, front ....................... 256
Door ............................ ................................ 18
Handles ................................................ 18
Locks....................... .................... 18, 205
Mirror....................... ............................ 30
Mirror heating ....... ................................ 31 Mirrors ....................
.............................29
Windows ...................... ...........18, 27, 206
Drive-Off Assistant ....... ................................177
Driving Hints .............. ........................................8
Winter ......................... .......................183
Driving off Drive-Off Assistant .... ...........................177
Launch Control......... ...........................181
Driving performance .... ................................270
Drop-center rim........... ................................223
EElectrical system..... ....................................235
Emergency flasher swit ch ..............................77
Emergency operation . ...................................22
Central locking ......... .......................19, 22
Ignition key ......... ..................................74
Lids................ ......................... ...........238
Tank flap ................. ...........................195
Emergency service ..... ................................212
Emergency starting with jumper cables.245, 246
Emission control system ..............133, 198, 199
Engine Checking the oil leve l ...........................161
Diagram ...................... .......................273
Exhaust ................... ...............................5
Number ..............................................265
Oil consumption ....... .....................10, 188
Oil level ................... ...........................189
Oil level indicator ...................... ...........161
Oils ............................................188, 271
Speeds.................... .............................10
Starting ................................................75