Page 48 of 113
46
FUEL TANK
R e s e r v o i r w h i c h s h o u l d b e r e fi l l e d w i t h
fuel, when the minimum level has been
detected.
Fuel tank capacity: approximately
50 litres. Filling
A l a b e l a f fi x e d t o t h e i n s i d e o f t h e t a n k
reminds you of the type of fuel to be
used depending on your engine.
T o fi l l t h e t a n k i n c o m p l e t e s a f e t y :
it is imperative that the engine is
switched off,
insert the key in the cap, then turn it
to the left,
remove the cap,
fi l l t h e t a n k , but do not continue
after the 3rd cut-off of the pump ;
this could cause malfunctions.
W h e n y o u h a v e fi l l e d t h e t a n k :
put the cap back in place,
turn the key to the right, then remove
it from the cap.
Page 73 of 113
68
BONNET
Component which protects and provides
access to the components of the engine
for checking of the various levels.
- Lift the control and raise the bonnet. - Secure the strut to hold the bonnet
open.
Closing
- Put the strut back in its housing.
- Lower the bonnet and release it at the end of its travel.
- Check that the bonnet is locked.
RUNNING OUT OF FUEL
(DIESEL)
If you should run out of fuel, it is neces-
sary to re-prime the circuit:
- fi l l t h e f u e l t a n k w i t h a t l e a s t fi v e l i - tres of diesel,
- squeeze and release the manual re-priming pump, under the bonnet
under the protective cover, until fuel
appears in the transparent pipe,
- operate the starter until the engine starts.
Opening
- Pull the control located on the left,
below the fascia.
Page 89 of 113
83
or
Fuse N° Rating Functions
1 10 A Pre-heat unit (diesel) - Water in diesel sensor -
R e v e r s i n g l i g h t s w i t c h - S p e e d s e n s o r - A i r fl o w
sensor (diesel)
2 15 A Canister solenoid valve - Fuel pump
3 10 A ABS engine control unit
4 10 A Engine control unit
5 - Not used
6 15 A Front fog lamps
7 - Not used
8 20 A Fan assembly relay - Engine control unit - Diesel
injection pump - Diesel high pressure regulator -
Engine management solenoid valve
9 15 A Left-hand dipped beam
10 15 A Right-hand dipped beam 11 10 A Left-hand main beam
12 10 A Right-hand main beam
13 15 A Horn
14 10 A Front and rear windscreen wash pumps
15 30 A Throttle housing heater - Diesel injection pump -
O x y g e n s e n s o r - E n g i n e c o n t r o l u n i t - A i r fl o w
sensor - Ignition coil - Engine management
solenoid valve - Diesel heater - Injectors
16 30 A Air pump relay
17 30 A High and low speed windscreen wiper
18 40 A Air conditioning fan
Engine compartment fuse box
To gain access to the box in the engine
compartment (next to the battery), un-
clip the cover.
After carrying out work, close the cover
very carefully.
Page 96 of 113
90
ENGINES AND GEARBOXES
Models Model codes
2LHFXA
2MHFXA
2LKFWA
2MKFWA
PETROL ENGINES 1.1 litre (60 bhp) 1.4 litre (75 bhp)
Cubic capacity (cm 3
) 1 124 1 360
Bore x stroke (mm) 72 x 69 75 x 77
EU standard maximum power (kW/bhp) 44.1 55
Maximum power engine speed (rpm) 5 500 5 500
EU standard maximum torque (Nm) 95 120
Maximum torque engine speed (rpm) 3 300 3 400
Fuel Unleaded
Catalytic converter yes
Gearbox Manual (5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) * 3.2 3.2
Gearbox - Final drive 2 2
* D r a i n i n g b y g r a v i t y w i t h o i l fi l l e r c a p o p e n .
Page 97 of 113
93
ENGINES AND GEARBOXES
Models Model codes
2L8HZA
2M8HZA
DIESEL ENGINE
1.4 litre Turbo HDI 70 bhp
Cubic capacity (cm 3
) 1 398
Bore x stroke (mm) 73.7 x 82
EU standard maximum power (kW/bhp) 50
Maximum power engine speed (rpm) 4 000
EU standard maximum torque (Nm) 160
Maximum torque engine speed (rpm) 2 000
Fuel Diesel
Catalytic converter Yes
Gearbox Manual (5-speed)
Oil capacity (in litres)
Engine (with cartridge replacement) * 3.75
Gearbox - Final drive 1.9
* D r a i n i n g b y g r a v i t y w i t h o i l fi l l e r c a p o p e n .
Page 98 of 113
91
The consumption values presented here correspond to the values communicated at the time of printing. These consumption
values were established in accordance with Directive 80/1268/CEE. They may vary depending on the style of driving, driving
conditions, weather conditions, the vehicle load, the maint enance of the vehicle and the use of the accessories.
CONSUMPTION In accordance with directive 80/1268/CEE
Petrol engines Gearbox Model codes:
Urban driving
(litres/100 km)
Inter-urban
driving
(litres/100 km)
Mixed driving
(litres/100 km)
Emission of
CO 2 by weight
(g/km)
1.1 litre 60 bhp
Manual
2LHFXA
2MHFXA 8.2 4.7 5.9 140
1.4 litre 75 bhp
2LKFWA
2MKFWA 9.1 4.8 6.3 150
Quality of the fuel used for petrol engines
The petrol engines are perfectly compatible with E5 type pet rol biofuels (containing 5 % ethanol), conforming to European
standard EN 228.
E85 type fuels (containing up to 85 % ethanol) are reserved e xclusively for vehicles marketed for the use of this type of fuel
(BioFlex vehicles). The quality of the ethanol must comply with European standard EN 15 376.
For Brazil only, special vehicles are marketed to run on fuels co ntaining up to 100 % ethanol (type E100).
Page 99 of 113
94
CONSUMPTION In accordance with directive 80/1268/CEE
Diesel engine Gearbox Model codes
Urban driving
(litres/100 km)
Inter-urban
driving
(litres/100 km)
Mixed driving
(litres/100 km)
Emission of
CO 2 by weight
(g/km)
1.4 litre Turbo
HDI 70 bhp
Manual
2L8HZA
2M8HZA 5.4 3.5 4.2 110
Quality of the fuel used for Diesel engines
The Diesel engines are perfectly compatible with biofuels w hich conform to current and future European standards (diesel
fuel which complies with standard EN 590 mixed with a biofue l which complies with standard EN 14214) which can be
distributed at the pumps (possible incorporation of 0 to 7 % Fatty Acid Methyl Ester).
The use of any other type of (bio) fuel (vegetable or animal oils, domestic fuel...) is strictly prohibited (risk of damage to the
engine and fuel circuit).
The consumption values presented here correspond to the values co
mmunicated at the time of printing. These consumption
values were established in accordance with Directive 80/1268/CEE. They may vary depending on the style of driving, driving
conditions, weather conditions, the vehicle load, the maint enance of the vehicle and the use of the accessories.
Page 113 of 113
91
The consumption values presented here correspond to the values communicated at the time of printing. These consumption
values were established in accordance with Directive 80/1268/CEE. They may vary depending on the style of driving, driving
conditions, weather conditions, the vehicle load, the maint enance of the vehicle and the use of the accessories.
CONSUMPTION In accordance with directive 80/1268/CEE
Petrol engines Gearbox Model codes:
Urban driving
(litres/100 km)
Inter-urban
driving
(litres/100 km)
Mixed driving
(litres/100 km)
Emission of
CO 2 by weight
(g/km)
1.1 litre 60 bhp
Manual
2LHFXA
2MHFXA 8.2 4.7 5.9
135
1.4 litre 75 bhp
2LKFWA
2MKFWA 9.1 4.8 6.3 150
Quality of the fuel used for petrol engines
The petrol engines are perfectly compatible with E5 type pet rol biofuels (containing 5 % ethanol), conforming to European
standard EN 228.
E85 type fuels (containing up to 85 % ethanol) are reserved e xclusively for vehicles marketed for the use of this type of fuel
(BioFlex vehicles). The quality of the ethanol must comply with European standard EN 15 376.
For Brazil only, special vehicles are marketed to run on fuels co ntaining up to 100 % ethanol (type E100).
