2009 OPEL CORSA warning

245
Opel Service, maintenance
Picture no: 18149s.tif
Coolant level
In a closed cooling system, there is hardly
any loss.
If the cooling system is cold, the coolant
should lie above the KALT/COLD mark.
Top up if the level is low. Top up with anti-freeze. If no anti-freeze is
available, fill with clean tap water or
distilled water. Have the anti-freeze
concentration checked.
Have the cause of coolant loss rectified by
a workshop.
Fit the cap on straight and tighten it.
Brakes A screeching noise indicates that the brake
lining is at its minimum thickness.
Continued driving is possible. Have the
brake lining replace as soon as possible.
Once new brake lining is
fitted, do not brake
unnecessarily hard for the first 200 km.
9
Warning
Allow the engine to cool before opening
the cap. Carefully open the cap,
relieving the overpressure slowly.
Caution
Too low a coolant level can cause
engine damage.
Back to overview

246 Opel Service, maintenance
Picture no: 18151s.tif
Brake fluid The brake fluid level must be between
theMIN and the MAX marks. When topping up, ensure maximum
cleanliness as contamination of the brake
fluid can lead to func
tion problems in the
braking system.
Only use approved high performance
brake fluids. Only us e brake fluid DOT4.
After correcting the brake fluid level, have
the cause of the loss of brake fluid
remedied by a workshop. Brake fluid change
Brake fluid is hygroscopic, i.e. it absorbs
water. If the brakes become hot, such as
when driving on long downhill stretches,
vapour bubbles can occur in the water,
which can have an extremely adverse
effect on braking power (depending on the
proportion of water).
Keep to the specified intervals.
9
Warning
Brake fluid is poisonous and corrosive.
Do not allow it to come into contact with
eyes, skin, fabrics or painted surfaces.
9
Warning
Have the brake fluid change performed
by a workshop. Please comply with the
legal environmental and health regula-
tions – concerning the disposal of brake
fluid.
Back to overview

249
Opel Service, maintenance
Protecting electronic components In order to prevent faults in electronic
components in the electrical system, never
connect or disconnect battery with engine
running or ignition switched on. Never start
engine with battery disconnected, e.g.
when starting using jump leads.
To avoid damaging th e vehicle, do not
make any modifications to the electrical
system, e. g. connecting additional
consumers or tampering with electronic
control units (chip tuning).
Laying the vehicle up for a long
period of time If the vehicle is to be laid up for several
months, the following work should be
undertaken to prevent damage:
z Wash and wax the vehicle 3228.
z Have the wax in the engine
compartment and underbody checked.
z Clean and preserve rubber seals.
z Change engine oil.
z Check antifreeze and corrosion
protection 3244.
z Check coolant level, add antifreeze if
necessary 3245.
z Drain the windscreen washer system.
z Increase tyre pressure to value given for
full load 3264. z
Park the vehicle in dry and well
ventilated place. Select first gear or
reverse gear, and with automatic
transmission 3 move selector lever to P.
Use chocks or something similar to
prevent vehicle from rolling.
z Do not apply hand brake.
z Disconnect the clamp from the negative
terminal of the vehicle battery.
Putting the vehicle back into
servicePerform the following work before
recommissioning the vehicle:
zConnect the clamp to the negative
terminal of the vehicle battery.
z Check tyre pressure 3264.
z Top up windscreen washer system 3248.
z Check engine oil level 3242.
z Check coolant level 3245.
z Fit the number plate if necessary.
9
Warning
Electronic ignition systems generate very
high voltages. Do not touch the ignition
system; high voltage can be fatal.
Back to overview

269
Technical Data
Trailer hitch installation
dimensions
Removable coupling ball bar,
passenger vehicle, van All measurements refer to Opel-approved
towing equipment.
9
Warning
Only use towing equipment approved
for your vehicle. We recommend
entrusting retrofitting of towing equip-
ment to your workshop.
Dimension mm
A 267
B 81
C 700
D 528.5
E 532.5
F 473.5
G 418
H 422
I 9
J 51
K 96
L 255M
351
Back to overview

273
Index
GGears ................................................ 14, 144
Generator, see Alternator ....................... 87
Glove compartment ................................ 82
Glove compartment lightingBulb replacement ............................... 227
Graphical information display ................ 94
Gross vehicle weight .............................. 259
Gross vehicle weight rating ................... 259HHalogen headlamp system .................. 212 Bulb replacement ............................... 212
Driving abroad ................................... 117
Hand brake ................................16, 17, 167
Hazard warning lamps ................... 12, 111
Head restraints .................................... 4, 52
Headlamp flash ..................................... 109
Headlamp range adjustment ............... 111
Headlamp switch .....................11, 108, 109
Headlamp washer system ......13, 107, 248
Headlamps ............................................... 11 Daytime running lights ...................... 108
Driving abroad ................................... 117
Fog lamps ........................................... 110
Reversing lamps ................................. 110
Warning device .................................. 105
Headrest height ad justment ..................... 4
Heated exterior mirrors ..................... 13, 43
Heated front seats ............................ 50, 51
Heated rear window .......................... 13, 46 Heating .......................................... 120, 124
Seats ............................................... 50, 51
With climate control system ............. 130
With the air conditioning system ...... 128
Height adjustment Seat belts .............................................. 63
Steering wheel ........................................ 5
High-pressure cleaners ......................... 230
Hill Start Assist ....................................... 167
Horn .......................................................... 12
IIdentification plate ................................ 250
Idling ....................................................... 144
Ignition logic .......................................... 100
Ignition system .......................241, 248, 249
Immobiliser ............................................... 27
Information display ................................. 94
Infotainment system ............................. 118
Inspection system ............................ 91, 231
Instrument display ................................... 90
Instrument illumination ......................... 114 Bulb replacement .............................. 227
Instrument panel ....................................... 6
Instruments .............................................. 84
Interior mirror ....................................... 4, 44
Interruption of power supply .......... 46, 104 Easytronic ........................................... 143
Electric windows ................................... 46
Selector lever lock .............................. 148
ISOFIX ....................................................... 68
JJack ................................................ 198, 202
Jump leads ............................................. 191KKey Extending ............................................. 26
Locking doors ................................ 28, 32
Remove ................................................ 17
Starting the engine .............................. 16
Keys .......................................................... 26LLanguage selection ................................ 99
Lashing eyes ...................................... 55, 56
Lead-me-to-the-car light function ....... 113
Light switch .............................................. 11
Lighting ...................................... 11, 88, 108 Driving abroad .................................. 117
Load-bay floor .................................. 24, 82
Loading .................................................. 187
Locking doors .................................... 28, 32
Locking from the inside .................... 29, 34
Locks ...................................................... 230
Luggage compartment Bulb replacement .............................. 227
Lighting .............................................. 116
Loading ................................ 57, 187, 259
Locking ................................................. 36
Luggage compartment cover .......... 54, 56
Back to overview

275
Index
SSafeguard against unauthorised use .... 16
Safety accessories ........................... 63, 196
Saving energy ........................................ 151
Seat adjustment ........................................ 2
Seat belts ............................................ 58, 62
Seat height adjustment ....................... 3, 49
Seat position ............................................ 50
Seats ........................................................... 2Heated ............................................ 50, 51
Selector lever .................................. 137, 145
Selector lever lock ............................ 15, 145
Self-diagnosis .............................61, 74, 166
Self-help .................................................. 190 Central locking ..................................... 34
Electric sun roof .................................... 47
Electric windows ................................... 46
Information display ............................. 96
Remote control ..................................... 31
Service interval display ......................... 240
Service intervals ..................................... 231 Additional work .................................. 238
Hard driving conditions ..................... 238
Main inspection .................................. 231
Service work ........................................... 240
Side airbags ............................................. 71
Signal system ........................................... 12
Spare keys ................................................ 26
Spare wheel ........................... 196, 197, 200
Speed .............................................. 151, 152 Fuel consumption ...................... 151, 152 Speed warning ......................................... 92
Speedometer ........................................... 90
Sport programme .................................. 140
Starting the engine .......................... 27, 137
Steam-jet cleaners ................................. 230
Steering column lock ......................... 16, 17
Steering wheel adju
stment ....................... 5
Steering wheel remote control ....... 21, 118
Stowage compartments ......................... 82
Sun roof ............................................ 46, 230
Sunblind ................................................... 47
System settings ........................................ 98
TTachometer .............................................. 90
Tail lamps ............................................... 108 Bulb replacement .............................. 221
Tailgate .................................................... 36
Tank Fuel gauge ........................................... 90
Technical data ....................................... 250
Telephone, see Mobile telephone ........ 119
Temperature regulation ............... 123, 130
Tempomat, see cruise control .............. 160
Temporary spare wheel ................ 173, 197
Tightening torque .......................... 203, 264
Time .......................................................... 96
To fold backrest .................................. 3, 49
Tools ....................................................... 198
Top speed .............................................. 254
Top-Tether ............................................... 68
Towing .................................................... 193
Towing equipment ........................ 184, 269 Towing eye .................................... 193, 195
Transmission
Manual transmission ......................... 144
Transmission display ............... 91, 136, 144
Transmission, automatic ........................ 15 Automatic mode ............................... 145
Driving programme ........................... 146
Fault ................................................... 148
Interruption of power supply ............ 148
Kickdown ............................................ 146
Selector lever ............................... 15, 145
Selector lever lock ................................ 15
Winter programme ............................ 146
Transmission, Easytronic Driving programmes ......................... 139
Fault ................................................... 142
Interruption of power supply ............ 143
Kickdown ............................................ 141
Selector lever ............................... 15, 138
Sport programme .............................. 140
Winter programme ............................ 140
Transmission, manual ............................. 14
Tread depth ........................................... 170
Trip computer ............................ 20, 92, 101
Trip odometer .................................... 92, 93
Triple information display ...................... 94
Turn signal lamps .................................... 11
Turn signals Bulb replacement ...................... 220, 221
Tyre chains ..................................... 172, 264
Tyre condition ........................................ 170
Tyre pressure ........................... 22, 169, 264
Tyre repair kit ........................................ 204
Back to overview

276 IndexUUnits of measure .................................... 100
Unleaded fuel ....................... 155, 252, 253VValve cap key ................................ 169, 264
Vehicle care ............................................ 228
Vehicle decommissioning ...................... 249
Vehicle identification number ............... 251
Vehicle keys, see Keys ............................. 26
Vehicle recommissioning ....................... 249
Vehicle tools ........................................... 198
Ventilation ............................. 120, 124, 133WWarning buzzers .................................... 105
Warning triangle .................................... 196
Washer fluid reservoir, windscreen washer system ................. 248
Wheels .................................................... 168
Wheels, tyres .................................. 168, 264
Windows ................................................... 44 Demisting
and defrosting .................. 125, 128, 131
Windscreen washer system ............. 13, 107 Antifreeze protection ......................... 248
Washer fluid reservoir ........................ 248
Windscreen wipers ................................... 12
Winter mode Starting-off aid .................................. 140 Winter operation
Battery ................................................ 150
Coolant, antifreeze ............................ 244
Fuel consumption .............................. 152
Fuel for diesel engines ....................... 153
Heating ....................................... 120, 128
Locks ................................................... 230
Tyre chains ................................. 172, 264
Window demisting and defrosting ... 125
Windscreen washer system,
antifreeze protection ......................... 248
Winter programme ........................ 140, 146
Winter tyres .................................... 172, 264
Back to overview