2009 FORD F650 climate control

Introduction 4
Safety and environment protection 4
Vehicle Inspection Guide 11
Instrument Cluster 22
Warning lights and chimes 22
Gauges 28
Entertainment Systems 33
AM/FM stereo 33
AM/FM stereo with in-dash six CD 40
Climate Controls 46
Heater only 46
Manual heating and air conditioning 47
Lights 49
Headlamps 49
Turn signal control 50
Interior lamps 51
Bulb replacement 51
Driver Controls 54
Windshield wiper/washer control 54
Steering wheel adjustment 54
Power windows 56
Mirrors 57
Speed control 59
Locks and Security 64
Keys 64
Locks 64
Seating and Safety Restraints 65
Seating 65
Safety restraints 69
Child restraints 79
Table of Contents
1
2009 F-650/750(f67)
Supplement
USA(fus)

HEATER ONLY SYSTEM
(IF EQUIPPED)
1.Fan speed adjustment:Controls
the volume of air circulated in the
vehicle.
2.Temperature selection:
Controls the temperature of the
airflow in the vehicle.
3.Air flow selections:Controls the direction of the airflow in the
vehicle. See the following for a brief description on each control.
:Distributes outside air through the instrument panel vents.
OFF:Outside air is shut out and the fan will not operate.
:Distributes outside air through the instrument panel vents and the
floor vents.
:Distributes outside air through the floor vents.
:Distributes outside air through the windshield defroster vents and
floor vents.
:Distributes outside air through the windshield defroster vents.
Operating tips
•To reduce fog build up on the windshield during humid weather, place
the air flow selector in the
position.
•To reduce humidity build up inside the vehicle during cold or warm
weather, do not drive with the air flow selector in the OFF position.
•Under normal weather conditions, do not leave the air flow selector in
OFF when the vehicle is parked. This allows the vehicle to “breathe”
using the outside air inlet vents.
•Do not put objects under the front seats that will interfere with the air
flow to the back seats.
•Remove any snow, ice or leaves from the air intake area at the base of
the windshield.
2009 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
46

To aid in side window defogging/demisting in cold weather:
1. Select
.
2. Set the temperature control to full heat.
3. Set the fan speed to its highest speed.
4. Direct the outer instrument panel vents towards the side windows.
To increase airflow to the outer instrument panel vents, close the vents
located in the middle of the instrument panel.
WARNING:Do not place objects on top of the instrument panel
as these objects may become projectiles in a collision or sudden
stop.
MANUAL HEATING AND AIR CONDITIONING SYSTEM
(IF EQUIPPED)
1.Fan speed adjustment:Controls
the volume of air circulated in the
vehicle.
2.Temperature selection:
Controls the temperature of the
airflow in the vehicle.
3.Air flow selections:Controls the direction of the airflow in the
vehicle. See the following for a brief description on each control.
MAX A/C:Uses recirculated air to cool the vehicle. Air flows from the
instrument panel vents only.
A/C:Uses outside air to cool the vehicle. Air flows from the instrument
panel vents only.
:Distributes outside air through the instrument panel vents.
OFF:Outside air is shut out and the fan will not operate.
:Distributes outside air through the instrument panel vents and the
floor vents.
:Distributes outside air through the floor vents.
:Distributes outside air through the windshield defroster vents and
floor vents.
:Distributes outside air through the windshield defroster vents.
2009 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
47

Operating tips
•To reduce fog build up on the windshield during humid weather, place
the air flow selector in the
position.
•To reduce humidity build up inside the vehicle: do not drive with the
air flow selector in the OFF or MAX A/C position.
•Under normal weather conditions, do not leave the air flow selector in
OFF or MAX A/C when the vehicle is parked. This allows the vehicle
to “breathe” using the outside air inlet vents.
•Do not put objects under the front seats that will interfere with the
airflow to the back seats.
•Remove any snow, ice or leaves from the air intake area at the base of
the windshield.
To aid in side window defogging/demisting in cold weather:
1. Select
.
2. Select A/C.
3. Modulate the temperature control to maintain comfort.
4. Set the fan speed to its highest speed.
5. Direct the outer instrument panel vents towards the side windows.
To increase airflow to the outer instrument panel vents, close the vents
located in the middle of the instrument panel.
WARNING:Do not place objects on top of the instrument panel
as these objects may become projectiles in a collision or sudden
stop.
2009 F-650/750(f67)
Supplement
USA(fus)
Climate Controls
48

Severe climates
If you drive in extremely cold climates (less than –34°F [–36°C]):
•It may be necessary to increase the coolant concentration
above 50%.
•NEVER increase the coolant concentration above 60%.
•Engine coolant concentrations above 60% will decrease the
overheat protection characteristics of the engine coolant and
may cause engine damage.
•If available, refer to the chart on the coolant container to
ensure the coolant concentration in your vehicle will provide
adequate freeze protection at the temperatures in which you
drive in the winter months.
If you drive in extremely hot climates:
•It is still necessary to maintain the coolant concentration
above 40%.
•NEVER decrease the coolant concentration below 40%.
•Engine coolant concentrations below 40% will decrease the
corrosion protection characteristics of the engine coolant and
may cause engine damage.
•Engine coolant concentrations below 40% will decrease the
freeze protection characteristics of the engine coolant and may
cause engine damage.
•If available, refer to the chart on the coolant container to
ensure the coolant concentration in your vehicle will provide
adequate protection at the temperatures in which you drive.
Vehicles driven year-round in non-extreme climates should use a 50/50
mixture of engine coolant and distilled water for optimum cooling system
and engine protection.
Fan clutches
Your vehicle’s cooling system is equipped with a viscous fan clutch.
•The fan clutch helps control cooling, increase performance, improve
fuel economy and reduce noise.
•The fan clutch is controlled by bimetallic spring sensors. Do not
tamper with these sensors as this may change their calibration or keep
the fan clutch from operating at all.
2009 F-650/750(f67)
Supplement
USA(fus)
Maintenance and Specifications
185

A
Air conditioning ..........................47
manual heating and air
conditioning system .................47
Air suspension ...........................121
Anti-lock brake system
(see Brakes) ..............................119
Audio system
(see Radio) ......................33, 35, 40
Automatic transmission ............123
fluid, adding ............................201
fluid, checking ........................201
fluid, refill capacities ..............234
fluid, specification ..................220
Auxiliary power point .................55
Axle ............................132, 173, 206
lubricant specifications ..........220
refill capacities ........................232
B
Battery .......................................182
charging system warning
light ............................................22
jumping a disabled battery ....153
voltage gauge ............................28
Belt-Minder...............................75
Booster seats ...............................88
Brakes ........................100, 105, 174
adjustment ..............................176
anti-lock ...................................119
anti-lock brake system (ABS)
warning light .....................22, 119
brake warning light ..................22
fluid, checking and
adding ..............................176, 198
fluid, specifications .................220
parking ....................101, 108, 177Bulbs ............................................51
C
Catalytic converter
(see Emission control) .............177
CD-single premium .....................33
Cell phone use ..............................7
Child safety seats ........................82
attaching with tether straps ....86
in front seat ..............................84
in rear seat ..........................84, 86
tether anchorage hardware .....86
Child safety seats - booster
seats .............................................88
Cleaning your vehicle
chrome and aluminum
parts .........................................167
engine compartment ..............167
exterior ....................................169
instrument panel ....................168
interior .....................................168
interior trim ............................168
plastic parts ............................167
washing ....................................166
waxing .....................................166
wheels ......................................167
Climate control (see Air
conditioning or Heating) ......46–47
Clutch ................................126, 199
adjusting ..................................200
fluid ..........................................199
operation while driving ..........126
specifications ..........................220
Controls
power seat .................................66
Coolant ......................................184
refill capacities ........................234
specifications ..........................220
2009 F-650/750(f67)
Supplement
USA(fus)
Index
272

fluid, checking and adding ....197
fluid, refill capacity ................234
fluid, specifications .................220
Power Take-Off (PTO)
operation .................................130
Power Windows ...........................56
R
Radio ................................33, 35, 40
Relays ........................................145
Remote entry system
locking/unlocking doors ...........64
Roadside assistance ..................143
S
Safety belts (see Safety
restraints) ........................69–70, 72
Safety defects, reporting ..164–165
Safety restraints ..............69–70, 72
Belt-Minder.............................75
cleaning the safety belts ..........74
extension assembly ..................73
for adults .............................70, 72
for children ...............................79
lap belt ......................................71
warning light and
chime .............................22, 74–75
Safety seats for children ............82
Scheduled Maintenance
Guide .........................................237
General Maintenance
Information .............................237
Seat belts
(see Safety restraints) ...............69
Seats ............................................65
child safety seats ......................82heated ........................................67
Special notice ................................5
Specification chart,
lubricants ...................................220
Speed control ..............................59
Speedometer ...............................28
Starting your vehicle ..................92
jump starting ..........................153
preparing to start your
vehicle .......................................92
Steering .....................................178
Steering wheel
controls ................................54, 59
tilting .........................................54
Suspension ........................121, 204
T
Tachometer .................................28
Temperature control
(see Climate control) ...........46–47
Tires ...........................................212
Towing
wrecker ....................................157
Traction control
off light ......................................22
Transmission .....................123, 127
automatic operation ...............123
fluid, checking and adding
(automatic) .............................201
fluid, checking and adding
(manual) .................................202
fluid, refill capacities ..............234
lubricant specifications ..........220
manual operation ....................127
Turn signal ..................................50
V
Vehicle loading ..................136–137
2009 F-650/750(f67)
Supplement
USA(fus)
Index
275