2009 FIAT QUBO fuel

●● ●● ● ●
●
●
●● ●● ● ●
●● ●
●● ●● ● ●
●● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●●●
15
FIAT FIORINO/QUBO NATURAL POWER
If the car is mainly used in town, change the engine oil and filter every 12 months.
Thousands of kilometres 30 60 90 120 150 180
Check engine management system operation (using diagnosis socket)
Replace accessory drive belt/s
Replace toothed timing belt (*)
Replace spark plugs
Replace air filter cartridge
Change engine oil and oil filter (or every 24 months)
Change brake fluid (or every 24 months)
Replace pollen filter (or every 24 months)
Visually inspect condition of: methane pipes and connectors,
methane tank fastening, restore, if necessary (**)
Check pressure regulator and, if necessary, replace internal filter (**)
Check operation and parameters of fuel supply system using
the self-diagnosis socket
Check tightening torque of the cylinder fastening bands
(*) Regardless of the mileage, the timing drive belt shall be replaced every 4 years for particularly demanding use (cold climates, town driving,
idling for a long time, dusty areas) or, in any case, every 5 years.
(**) or every 12 months.
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:35 Pagina 15

GENERAL FEATURES 1.4
Engine identification code 350A1000
Cycle Otto
Number and layout of cylinders 4 in line
Piston bore and stroke mm 72 ˘ 84
Total capacity cc 1368
Compression ratio 11.1±0,2
kW
EEC max. power HP
at a speed of rpm
Nm
EEC max. torque kgm
at a speed of rpm
Spark plugsNGKZKR7A-10
Fuel
ENGINE
ENGINE CODE – BODYWORK VERSIONS
Engine code Bodywork version
1.4350A1000 225AXC1A03 (*)
225AXC1A03B (❍)
225BXC1AA7 (❒)
COMBI versions (*) QUBO versions (❍) CARGO versions (❒)
MethaneUnleaded petrol
95 RON
(EN 228 specification)
16
FIAT FIORINO/QUBO NATURAL POWER
51
70
6000
104
10.6
300057
77
6000
115
11.7
3000
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 16

17
FIAT FIORINO/QUBO NATURAL POWER
Versions Versions
Cargo Minimum” Cargo Maximum”
1180 1260
500 420
425 345
900 900
950 950
1680 1680
––
––
100 100
––Versions Versions
Combi M1 5P Qubo M1 5P
1270 1290
480 460
405 385
950 950
950 950
1750 1750
––
––
100 70
––
WEIGHTS
Weights (kg)
Unladen weight (with all fluids,
fuel tank filled to
90% and without optional equipment)
Payload including
the driver (❒):
Payload excluding the driver (❒):
Maximum permitted loads (
❍)
– front axle:
– rear axle:
– total:
Towing loads
– braked trailer:
– non-braked trailer:
Maximum load on the roof
(with roof rack bars):
Maximum load on the ball joint
(braked trailer):
(
❒) In the presence of optional equipment the unladen weight increases and, as a result, the payload decreases in relation to the max-
imum permitted loads.
(
❍) Loads not to be exceeded. The user is responsible for arranging goods in the luggage compartment and/on load carrying plat-
form within the maximum permitted loads.
IMPORTANT A trailer cannot be towed so there are no provisions for fitting a tow hook.
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 17

18
FIAT FIORINO/QUBO NATURAL POWER
Modifications or repairs to the fuel supply system that are not carried out properly or do not take the system’s
technical specifications into account can cause malfunctions leading to the risk of fire.
TRANSMISSION1.4
Gearbox
Clutch
Drive
SUSPENSION1.4
Front
Rear
BRAKES1.4
Service brakes:
– front
– rear
Parking brake
IMPORTANT Water, ice and salt on the roads may become deposited on the brake discs, reducing braking efficiency the first time
the brakes are applied.Disc
Drum
Controlled by hand lever, acting on rear brakes
Independent, McPherson type
Torsion beam
STEERING1.4
Type
Turning circle
(kerb to kerb) mRack and pinion with hydraulic power steering
9.95
Five forward speeds plus reverse with synchronisers for selecting forward gears
Hydraulic drive
Front
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 18

Fuel tank:including a reserve of:
Engine cooling system
Engine sump: Engine sump and filter:
Gearbox/differential casing:
Hydraulic power steering
Hydraulic brake circuit with
ABS:
Windscreen/rearscreen washer
fluid reservoir
(▲) When the vehicle is used in particularly harsh climate conditions, we recommend using a mixture of 60% PARAFLUUPand 40% distilled water.
21
FIAT FIORINO/QUBO NATURAL POWER
CAPACITIES
1.4
litres
45
6
÷7
6.6
2.4
2.6
–
0.38
–
2.2kg
–
–
–
–
–
1.5
0.35
0.50
–
Methane
– Methane (*) . . . . . . . . kg (approx.) 13
(*) The amount of methane depends on
the outside temperature, the supply pres-
sure, the quality of the gas and the type of
refuelling system. Total cylinder volume
about 77 litres.IMPORTANT Please note that, when us-
ing a fuel like methane, the range can vary
greatly as it depends on the temperature
of the gas in the cylinder as well as on the
vehicle driving and maintenance condi-
tions.Methane heats up during filling and cools
down during driving, undergoing changes
in pressure that reduce the quantity that
can be used.
It should also be pointed out that whilst
the vehicle is being run in (up to around
3,000 km) fuel consumption may be high-
er than the figures given. Recommended fuels
Original products
Green unleaded petrol not less than 95 R.O.N.
(EN 228 specification)
Mixture of 50% distilled water and PARAFLU
UP(▲)
SELENIA MULTIPOWER GAS 5W-40
TUTELA CAR TECHNYX
TUTELA GI/E
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL SC 35
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 21

22
FIAT FIORINO/QUBO NATURAL POWER
FUEL SYSTEM (methane)
Electronic injection specifically for meth -
ane.
Type: timed, sequential Multipoint.
Injection pressure: approx. 6 bar.
Stoichiometric metering of the air/meth -
ane gas mixture.
The methane injection system is con-
trolled by the dedicated control unit us-
ing the sensors already on the vehicle, in-
cluding the Lambda sensor for controlling
the fuel metering.
IGNITION
Static advance, electronic, integrated with
the injection.ENGINE COOLING SYSTEM
Engine cooling system with pressure re-
duction unit heating circuit subject to ex-
treme cooling during operation.
PERFORMANCE
Top speed in km/h.
Running on petrol:
– Cargo versions: .............................. 157
– Combi versions: ............................. 155
– Qubo versions: ................................ 155
Running on methane: ......................... 149
Modifications or repairs to
the fuel system that are not
carried out properly or do not take
the system technical specifications in-
to account can cause malfunctions
leading to a fire risk.
IMPORTANT
CO2EMISSIONS
CO2emissions according to the
current European directive (g/km)
CO2EMISSIONS Operation Operationpetrol methane
Combined 158 119
Urban 207 154
Extra-urban 129 98
Cargo/Combi/Qubo versions
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 22

23
FIAT FIORINO/QUBO NATURAL POWER
FUEL CONSUMPTION
N.B.The trip computer data concerning
range, average consumption and instan-
taneous consumption are not available for
this version.
The fuel consumption figures, given in the
table below, are determined on the basis
of the homologation tests laid down by
specific European Directives.The procedures below are followed for
measuring consumption:
– urban cycle: begins with cold starting,
followed by driving simulating the use of
the vehicle in town;
– extra-urban cycle: driving that simulates
using the vehicle out of town with fre-
quent acceleration in all gears; the speed
varies from 0 to 120 km/h;
– combined consumption: determined
through a weighting of about 37% of the
urban cycle and 63% of the extra-urban
cycle.IMPORTANT The type of route, traffic
conditions, weather conditions, driving
style, state of the vehicle in general, trim
level/equipment/
accessories, use of the climate control, ve-
hicle load, presence of a roof rack and oth-
er situations that adversely affect the aero-
dynamics, may lead to consumption figures
that differ from those measured (see
Saving fuel” in the Starting and
driving” chapter in the booklet).
CURRENT EUROPEAN DIRECTIVE
People Petrol Methane Methane Range
Carrier (litres/100 km) (m3/100 km) (**) (kg/100 km) (*) on methane (km)
Urban 8.9 8.6 –
Extra-urban 5.6 5.5 – 300
Combined 6.8 6.6 –
(*) Consumption in kg/100 km according to molecular weight calculation.
(**) Fuel consumption according to the current European directive.
603.97.591 FiorinoQubo Nat P 1ed EN 1-12-2009 14:36 Pagina 23