2009 FIAT PUNTO EVO glove box

74
F0U0058mfig. 64
C
B
A
D
F0U0272mfig. 65
INTERIOR FITTINGS
GLOVE COMPARTMENT fig. 64
Use the handle A-fig. 64 to open the compartment.
The glove compartment features a document shelf.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
COMPARTMENTS IN THE GLOVE BOX
Inside the glove compartment, for versions/markets
where provided, there may be a card carrier A-fig. 65,
a pen holder B, a document shelf C and an oddments com-
partment D.
To access the document shelf, use the handle to remove
it from its housing by pulling in the direction shown by the
arrow in fig. 65.
037-081 PUNTO FL EN 3ed 9-12-2009 13:39 Pagina 74

131
CONOSCENZA
DELLA
VETTURA
AVVIAMENTO
E GUIDA
SPIE E
MESSAGGI
IN EMERGENZA
MANUTENZIONE
E CURA
DATI TECNICI
INDICE
PRETENSIONERS
To increase the efficiency of the seat belts, the car is fit-
ted with front pretensioners. These devices, in the event
of a violent crash, rewind the seat belts by a few cen-
timetres. In this way, they ensure that the seat belt adheres
perfectly to the wearer before the restraining action be-
gins.
The seat belt reel locks to indicate that the pretension-
ers have intervened; the seat belt cannot be drawn back
up even when guiding it manually.
This car is equipped with a second pretensioner (in the
kick plate area). Its activation is signalled by the shorten-
ing of the metal cable.
IMPORTANT To obtain the highest degree of protection
from the action of the pretensioning device, wear the seat
so it fits snugly over the chest and hips.
A slight amount of smoke may be detected during opera-
tion of the pretensioners. This smoke is not harmful and
does not indicate a fire.
The pretensioner does not require any maintenance or lu-
brication.
Anything that modifies its original conditions invalidates its
efficiency.
If, due to unusual natural events (floods, sea storms, etc.),
the device has been affected by water and mud, it must
be replaced.
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
The pretensioner can be used only once.
Go to a Fiat Dealership to have it replaced
after it has been deployed. Consult the label in
the glove box to check the status of the preten-
sioners. Go to a Fiat Dealership to have the de-
vice replaced when the expiration date ap-
proaches.
WARNING
Operations which lead to knocks, vibrations
or localised heating (over 100°C for a max-
imum of 6 hours) in the area around the
pretensioners may cause damage or trigger them.
These devices are not affected by vibrations caused
by irregularities of the road surface or low obsta-
cles such as kerbs, etc. Contact a Fiat Dealership
for any assistance.
LOAD LIMITERS
To increase passenger safety, the front seat belt reels con-
tain a load limiter which controls the force acting on the
chest and shoulders during the belt restraining action in
the event of a head-on collision.
129-148 PUNTO FL EN 3ed 9-12-2009 13:39 Pagina 131

146
IMPORTANT Should an accident occur in which any of
the safety devices are activated, take the vehicle to a Fiat
Dealership to have the activated devices replaced and to
have the whole system checked.
Every control, repair and replacement operation con-
cerning the airbags must be carried out only at Fiat Deal-
erships.
If you are having the car scrapped, have the airbag sys-
tem deactivated at a Fiat Dealership first. If the car changes
ownership, the new owner must be informed of the
method of use of the airbags and the above warnings, and
also be given this “Owner’s Handbook”.
IMPORTANT Pretensioners, front airbags and front side
bags are deployed differently according to the type of col-
lision. Non-deployment of one or more of these devices
does not therefore indicate a system fault. IMPORTANT In the event of a side-on crash, the system
offers the best protection if you have a correct position
on the seat because this allows the side bags to inflate cor-
rectly.
IMPORTANT The front airbags and/or side bags may be
deployed if the car is subject to heavy knocks involving the
underbody area, such as violent shocks against steps, kerbs
or low obstacles, the car falling into big holes or hollows
in the road.
IMPORTANT A small amount of dust will be released
when the airbags are deployed. The dust is not harmful
and does not indicate the beginning of a fire. Furthermore,
the surface of the deployed bag and the interior of the
car may be covered in a dusty residue: this may irritate
skin and eyes. Wash with mild soap and water in the event
of exposure.
The expiration dates of the explosive charge and the clock
wire are shown on a label contained in the glove box. Go
to a Fiat Dealership to have the devices replaced when the
expiration date approaches.KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
129-148 PUNTO FL EN 3ed 9-12-2009 13:40 Pagina 146

203
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
7.5
7.5
5
5
10
5
20
20
20
20
5
5
7.5 1
8
13
2
5
11
4
6
14
7
12
3
10
FUSE TABLE
Dashboard fuse box fig. 190
DEVICESFUSE AMPS
Right dipped beam headlight
Lift dipped beam headlight, headlamp alignment corrector
INT/A supply for switch coils on engine fuse box
and switch coils on body computer control unit
Front ceiling light, rear ceiling light, visor lights,
door marker lights, boot light, glove box light
Supply and battery for EOBD diagnostic plug, automatic climate
control system control unit, alarm, sound system, convergence control unit
INT supply for instrument panel, switch on brake pedal
(N.O. contact), third brake light
Door locking/unlocking motors, dead lock activation motors, boot
unlocking motor
Windscreen/rear window washer pump
Electric window motor on driver-side front door
Electric window motor on passenger-side front door
INT supply for dashboard control lights, parking control unit,
tyre pressure measurement control unit, electric wing mirror movement,
rain sensor, sunroof control unit, My Port infotelematic system socket,
electric rear view mirror
Instrument panel
INT supply for brake pedal switch (NC contact), clutch pedal switch,
interior heating unit, convergence control unit, sound system capabilities,
voltage stabiliser control unit, reverse light on rear bumper,
water sensor on diesel filter, glow plug heating control unit, airflow meter,
brake booster sensor, switch coils on engine compartment fuse box
175-210 PUNTO FL EN 3ed 9-12-2009 13:42 Pagina 203

●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●● ●● ● ●
●●
●●
●●
●● ●
●● ●● ● ●
212
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
SCHEDULED SERVICING PLAN
EURO 4/EURO 5 PETROL AND EURO 4 DIESEL VERSIONS
Thousands of kilometres 30 60 90 120 150 180
Check tyre condition/wear and adjust pressure if required
Check operation of lighting system (headlamps, direction indicators,
hazard warning lights, boot, passenger compartment, glove box,
instrument panel warning lights, etc.)
Check operation of windscreen washer system and adjust nozzles
if necessary.
Check windscreen/rear window wiper blade position/wear
Check conditions and wear of front/rear disc brake pads
(for versions/markets where provided) and operation of pad wear indicator
Check condition and wear of rear drum brake linings
Visually inspect the conditions of: bodywork,
underbody protection, pipes and tubes
(exhaust – fuel – brakes), rubber parts (boots, sleeves, bushes, etc.)
Check cleanliness of bonnet and boot locks, and the cleanliness
and lubrication of linkages
Check and, if necessary, top up fluid levels (brakes/hydraulic
clutch, windscreen washer, battery, engine coolant, etc.)
Check the handbrake lever stroke and adjust it, if necessary
Visually inspect the condition of accessory drive belt/s.
Visually inspect the condition of toothed timing belt
Check tension of accessory drive belt/s, and adjust if necessary
(versions 1.2 – 1.4 heated)
Check and, if necessary, adjust tappet clearance (1.2 8v – 1.4 8vversions)
Check exhaust gas emissions
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 212

214
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●● ● ● ●
●●
●● ● ● ●
●● ● ● ●
●
EURO 5 DIESEL VERSIONS
Thousands of kilometres 35 70 105 140 175
Check tyre condition/wear and adjust pressure if required
Check operation of lighting system (headlamps, direction indicators, hazard warning lights,
boot, passenger compartment, glove box, instrument panel warning lights, etc.)
Check operation of windscreen washer system and adjust nozzles
if necessary
Check windscreen/rear window wiper blade position/wear
Check condition and wear of front disc brake pads and operation of pad
wear indicator
Check condition and wear of rear disc brake pads (1.6 Multijet versions)
Check condition and wear of rear drum brake linings (1.3 Multijet version)
Visually inspect the conditions of: bodywork, underbody protection,
pipes and tubes (exhaust - fuel - brakes), rubber parts (boots, sleeves, bushes, etc.)
Check cleanliness of bonnet and boot locks, as well as cleanliness and lubrication of linkages
Check and, if necessary, top up fluid levels (brakes/hydraulic clutch, windscreen washer,
battery, engine coolant, etc.)
Check the handbrake lever stroke and adjust it, if necessary
Visually inspect the condition of accessory drive belts
Check emissions/fumes
Check engine management system operation (via diagnostic socket)
Replace accessory drive belt/s
211-234 PUNTO FL EN 3ed 9-12-2009 13:38 Pagina 214

261
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND DRIVING
WARNING LIGHTS
AND MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS
– armrest .......................................... 76
– cleaning .......................................... 234
– headrests ....................................... 42
– heating ............................................ 41
Fuel
– fuel cut-off (system) .................... 73
– consumption ................................. 253
– fuel tank cap .................................. 126
– gauge and warning light .............. 15
– opening the flap ............................ 126
– refuelling the car .......................... 125
– specifications ......................238-239
Fuel cut-off system ............................. 73
Fuel economy ...................................... 154
Fuel flap ................................................. 126
Fuel gauge ............................................. 15
– type of fuel .........................125-238
Fuel reserve ......................................... 167
Fuel supply
(technical specifications) ................. 240
Fuel tank (capacity) ............................ 250
Fuel tank cap ........................................ 126
Fuse boxes (location) .. 200-201-202-268
Fuse list ...............................203-204-205
Fuse replacement
– list ..................................203-204-205
– general information and
warnings ......................................... 198
– location ..................200-201-202-268
Fuses ....................................203-204-205
– general information
and warnings ................................. 198
– location ..................200-201-202-268Gear lever ............................................ 153
Gearbox ............................................... 153
– technical specifications ............... 240
Glove compartment ........................... 74
Handbrake ........................................... 152
Hazard warning lights
– switching on .................................. 71
Headlamp alignment corrector ....... 101
Headlight alignment corrector ........ 101
Headlights
– alignment corrector .................... 101
– bulbs (type) ................................... 186
– bulb replacement ......................... 186
Headlights ............................................. 101
– alignment corrector .................... 101
– bulbs (type) ................................... 188
– light beam direction .................... 101
– adjusting headlights abroad ........ 102
– bulb replacement ......................... 186
Headrests
– front ................................................ 42
– rear ................................................. 43
Heated rear window ............51-55-72
Heating and ventilation ...................... 47
Heating and ventilation system ........ 47
Heavy-duty use of the car ................ 216
Hill Holder (system) .......................... 106
Ignition lock ......................................... 11
Ignition switch and steering
lock ..............................................11-12
Ignition .................................................. 11
In an emergency........................... 175 Environment
– devices for reducing emissions .. 127
EOBD system ...................................... 109
ESP system ........................................... 105
Extending the boot ........................... 94
Exterior lights (switching on) ........... 61
Fiat CODE system ............................. 4
Fiat CODE ........................................... 4
Fix&Go automatic
(quick tyre repair kit) ...................... 181
Flashing (main beams) ........................ 61
Fluids and lubricants
(specifications) .................................. 251
Fog lights
– bulb replacement ......................... 192
– switching on ................................. 71
Follow Me Home
(headlight device) ............................. 62
Front airbags ...................................... 141
– disabling ......................................... 143
– driver .............................................. 142
– passenger ....................................... 142
Front armrest ...................................... 76
Front ceiling light ................................ 68
– bulb replacement ......................... 195
Front fog lights
– bulb replacement ......................... 192
– switching on .................................. 71
Front light clusters
– bulb arrangement ......................... 189
Front seats ........................................... 39
– adjusting ......................................... 39
259-268 PUNTO FL EN 3ed 9-12-2009 13:42 Pagina 261

268
Fiat Group Automobiles S.p.A. - Customer Services - Technical Services - Service Engineering
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Printed n. 603.81.643 - 11/2009 - 3 edition
ACCESS TO DASHBOARD FUSE BOX
To access the dashboard fuse box fig. 226, open the glove
compartment.
F0U0532mfig. 226
RIGHT HAND DRIVE VERSION
259-268 PUNTO FL EN 3ed 9-12-2009 13:42 Pagina 268