2009 FIAT DUCATO checking oil

17
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
If the needle reaches the red area, stop
the engine immediately and contact
a Fiat Dealership.The failure of the fifth symbol to come on should not be
taken as a fault or the fact that there is not enough oil in
the sump.
IMPORTANT To find out the correct oil quantity,
always check using the dipstick (see paragraph
“Checking levels” in the section “Maintenance and
care”).
After a few seconds, the symbol display indicating the
amount of engine oil disappears and:
❒if the next service is due, the time to the next
service is displayed and the warning light õlights up
on the instrument panel. When the service date is
reached, the display shows some dashes;
❒then, if it is nearly time to change the engine oil, the
time to the next oil change is shown on the top row
of the display and the message “OIL” appears in the
lower part of the display. When the service date is
reached, the display shows five dashes.
Versions with multifunction display
When the ignition key is turned to MAR-ON the display
shows the oil level on the first row by turning five
symbols on/off. ENGINE OIL LEVEL GAUGE
(for versions/markets where provided)
The gauge provides a graphic indication of the level of
oil in the engine.
Versions with digital display
When the ignition key is turned to MAR-ON, the
quantity of oil in the engine is displayed by means of five
symbols.
F0N1017g
The symbols are gradually turned off to indicate
a reduction in the oil level.
If the oil level is lower than the minimum required value
and a top-up is required, the display shows 5 dashes
intermittently.
Four or five symbols light up to indicate a sufficient level
of oil in the sump.
F0N1018g
001-036 DUCATO LUM EN 7ed 6/21/10 2:08 PM Page 17

F0N0016mfig. 17
DIGITAL DISPLAY
STANDARD SCREEN fig. 17
The standard screen shows the following information:
A Headlamp alignment position (only with dipped
headlamps on).
B Time (always displayed, even with the key extracted
and the front doors closed);
C Odometer (distance covered in kilometres or miles)
and TRIP data.
NOTE With key removed (when opening one of the
front doors) the display turns on and shows the time
and km or miles covered for a few seconds. The symbols are gradually turned off as the oil level
drops.
Four or five symbols light up to indicate a sufficient level
of oil in the sump. If the fifth symbol is not lit, this does
not indicate a fault or that insufficient oil is present in
the sump.
If the oil level is lower than the minimum required value,
the display shows a dedicated message indicating
minimum engine oil level and the need for a top-up.
IMPORTANT To find out the correct oil quantity,
always check using the dipstick (see paragraph
“Checking levels” in the section “Maintenance and
care”).
After a few seconds, the symbol display indicating the
amount of engine oil disappears and:
❒when the next scheduled servicing is near, the time
to the next service is displayed and the warning light
õlights up on the instrument panel. When the
service date is reached, the display shows
a dedicated message;
❒then, if it is nearly time to change the engine oil, the
time to the next oil change is shown on the top row
of the display. When the service interval has expired
a dedicated warning will be shown on the display.
18
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
001-036 DUCATO LUM EN 7ed 6/21/10 2:08 PM Page 18

124
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
F0N0158mfig. 138
ACCESSORIES PURCHASED
BY THE OWNER
If after buying the vehicle, you decide to install electrical
accessories that require a permanent electric supply
(alarm, satellite anti-theft system, etc.) or accessories
that in any case burden the electric supply, contact
a Fiat Dealership, whose qualified personnel, besides
suggesting the most suitable devices from Lineaccessori
Fiat, will also evaluate the overall electric absorption,
checking whether the vehicle’s electric system is able to
withstand the load required, or whether it needs to be
integrated with a more powerful battery. The sound system must be installed in the place
occupied by the central oddments compartment, where
you will find the wiring.
For connection to the existing devices
supplied in the vehicle contact a Fiat
Dealership to prevent any problems that could
impair vehicle safety.
WARNING
Take care when fitting additional
spoilers, alloy wheels or non-standard
wheel hubs: they could reduce the ventilation
of the brakes and affect efficiency under sharp,
repeated braking or on long descents. Make
sure that nothing obstructs the pedal stroke
(mats, etc.)
WARNING
037-128 DUCATO LUM EN 7ed 6/21/10 2:11 PM Page 124

213
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
CHECKING FLUID LEVELS
fig. 221 – 100 Multijet versions
fig. 222 – 120 Multijet – 130 Multijet versions
Never smoke while
working in the engine
compartment: gas and
inflammable vapours may be
present, with the risk of fire.
WARNING
Be careful, when
topping up not to
confuse the various
types of fluids: they are all
incompatible with one another
and could seriously damage the
vehicle.
1. Engine coolant fluid
2. Power steering fluid
3. Windscreen washer fluid
4. Brake fluid
5. Engine oil
F0N0099m
F0N0100m
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 213

216
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
ENGINE OIL CONSUMPTION
The maximum engine oil consumption is usually
400 grams every 1,000 km.
When the vehicle is new, the engine needs to be run in,
therefore the engine oil consumption can only be
considered stabilised after the first 5,000 – 6,000 km.
IMPORTANT The oil consumption depends on the
driving style and the conditions under which the vehicle
is used.
IMPORTANT After adding or changing the oil, let the
engine run for a few seconds and wait a few minutes
after switching it off before checking the level.
When the engine is hot, take care when
working inside the engine compartment
to avoid burns. Remember that when the engine
is hot, the fan may cut in: danger of injury. Pay
attention to scarves, ties and other loose fitting
garments: they might get caught by moving
components.
WARNING
Do not add any oil with different
specifications to those of the existing
engine oil.
The used engine oil and the replaced oil
filter contain substances that may be
dangerous for the environment. It is
advisable to have oil and filters changed by a Fiat
Dealership where they will be disposed respecting
the environment and according to legal
regulations.
207-230 DUCATO LUM EN 7ed 6/21/10 2:17 PM Page 216

278
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– positioning
the restraint systems
on the seats ................137-140
– preparation for “Isofix
Universale” child seat ........ 138
Central door
locking/unlocking system ..... 102
Changing a wheel ..................... 174
Chassis (marking) .................... 233
Checking the levels ................. 213
– brake fluid ............................ 219
– engine coolant .................... 217
– engine oil ............................. 215
– power steering fluid .......... 220
– washer fluid for
windscreen/rear
window/headlamps ............ 218
Cigar lighter ............................... 94
Cleaning and maintenance
– bodywork ............................ 227
– engine compartments ....... 229– front headlights .................. 229
– interiors ............................... 229
– leather upholstery ............. 230
– paintwork ............................ 228
– plastic parts ......................... 230
– rubber tubes ....................... 225
– seats and fabric parts ........ 230
– windows ............................... 229
– windows ................................ 229
CO
2emissions ......................... 271
Code card................................... 5
Compartment under front
passenger seat ........................ 92
Controls .................................... 85
Cruise Control (constant
speed regulator) .................... 80
Cup/can holder ........................ 93
Dashboard ................................ 3
Dashboard and controls ........ 3
Dead lock (device) .................. 105
Desk/bookrest .........................96
Digital display ............................ 18
Dimensions ............................... 241
Direction indicators
– bulb replacement ....... 190-192
– control ................................. 75
– front bulb replacement ..... 190
– rear bulb replacement ...... 192
Door lock .................................. 87
Door pockets ........................... 92
Doors ......................................... 102
DPF
(diesel particulate filter) ....... 128
EBD (system) ...........................114
Electric windows ...................... 109
Electricity supply and fuel
cutoff switch ........................... 88
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 278

279
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
– specifications ....................... 234
Environment (protection) ...... 128
EOBD system ........................... 120
ESP system ................................ 116
External lights ........................... 74
Fiat CODE system .................. 4
Fix&Go automatic quick
tyre repair kit ......................... 180
Flap on bench ........................... 97
Flashing the headlights ............ 75
Fluids and lubricants
(quantity and
products) ........................267-268
Fog lights
– alignment ............................. 114
– bulb replacement ............... 191
– control ................................. 85
Follow me home (device) ...... 76
Front air bags ............................ 141Fuel consumption
– engine oil ............................. 216
– fuel ........................................ 270
Fuel flap ......................................127
Fuel level gauge ........................ 16
Fuel reserve ...............................159
Fuel tank cap ............................. 128
Fuel
– consumption........................ 270
– electricity supply
and fuel cutoff switch ........ 88
– fuel cap .................................127
– fuel level gauge ................... 16
– saving .................................... 152
Fuses (if a fuse blows) ............. 198
– fuse list ................................. 201
– fuses (if a fuse blows) ........ 198
– general information ........... 198
– location (fuse boxes) ......... 199
– users list ............................... 201 Electronic alarm ....................... 10
Engine codes ............................. 232
Engine compartment
– bonnet opening/closing ..... 110
– checking the levels ............. 213
– washing ................................. 229
Engine coolant fluid
– checking the level ............... 217
– temperature gauge ............ 16
Engine coolant
temperature gauge ................ 16
Engine oil gauge ........................ 17
Engine oil
– checking the level ............... 215
– engine oil gauge .................. 17
– oil consumption ................. 216
– technical specifications ...... 268
Engine
– bonnet .................................. 110
– identification code .............233
– marking ................................ 233
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 279